2018 CHEVROLET VOLT Complaints

The contact owns a 2018 Chevrolet Volt. The contact stated that while driving at an undisclosed speed, the vehicle lost automotive power. The check engine warning light illuminated. Shortly afterward, the message "Reduce Propulsion, Engine will not Start" was displayed on the instrument panel. The vehicle was towed to a local dealer where it was diagnosed with a defective EGR valve. The contact was informed that the EGR valve needed to be replaced. The vehicle was not repaired due to the cost and lack of parts availability. The vehicle was towed to the residence. The contact believed that the cause of the failure was related to high temperatures. The manufacturer was made aware of the failure. The failure mileage was approximately 69,000.

Driving on gas on the highway, the adaptive cruise control suddenly disabled with a "Reduced Propulsion" message on the dash and a check engine light. The car started struggling in its propulsion. We found an AutoZone and scanned the codes, and multiple were returned. A Google search pointed us to the "walk home" fuse, which indeed had been blown. Replacing that fuse and disconnecting/reconnecting the battery eliminated the errors. Less than a week later during highway driving (the next time the battery charge was used up and it switched to the ICE) I got another check engine light, but this time without the "reduced propulsion" message. Scanning at AutoZone again revealed a P0404 message referencing the EGR valve. Due to the limited availability of the part I have called into Covert Bastrop (Bastrop, TX) and am waiting to hear back on their ability to fix the car.

The issue started with a forward push while lowering my speed while coming to a stop. It then progressed to a trembling engine. Then it progressed to the car struggling to effectively switch from electric to gas and back. It then would only be usable on electric range and the engine would not start and would be greyed out. Now, it only works on engine mode, it uses fuel like a pick up truck, it loses power while driving due to trying to switch to electric mode and back, and it struggles to accelerate. It will do it while idle as well as while driving 45mph and up. It barely has any propulsion power and I have to turn my hazards on any time I am going to accelerate. If I brake hard the engine will shake violently and then shut off. I then have to switch gears from drive to park or neutral to park to drive to reengage the engine. Recently it has turned on all the accessories but the ev and the gas is greyed out and there is zero propulsion power. I replaced the 12v battery thinking it might have been dying and it still has the same issue. I read about the class action lawsuit for the BCEM and have made an appointment the dealership but when I told them what was wrong with it the said we need to wait for the diagnostics.

Took my 2018 chey volt to the dealer after trying to start the car and shifting into reverse a Action Required and shift to park massage appears. Towed the car to the Chevy dealership of on 11-19-2024 and on 12-17-2024 after the dealership has been talking with GM they tell me the car needs a new battery pack and there are none to be found. Car is still under GM warranty! Service adviser recommends calling GM to buy back or get a Lemon law Attorney

The contact owns a 2018 Chevrolet Bolt. The contact stated while driving at a moderate speed, the check engine warning light illuminated, and the “Propulsion Power” message was displayed. The contact pulled over and upon an attempting to restart the vehicle, the vehicle failed to restart. Due to the failure, the vehicle was towed to an independent mechanic where it was discovered that the BECM (Battery Engine Control Module) was defective. The mechanic discovered that the vehicle was under warranty and contacted that the local dealer for assistance. The mechanic drove the vehicle to the dealer who acknowledged the failure; however, the dealer stated that the failure was not covered under warranty. The manufacturer was also notified of the failure and the contact was provided a case number. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 100,000.

I was driving and a message "engine popuslison reduce" appeared and i was not able to drive at the speed of traffics which was unsafe.

On [XXX], while driving on [XXX] in Virginia, the check engine light came on in my Chevy Volt. A message on dash said that there was reduced propulsion, and the gas engine quit running. The car switched to battery power, which would not have lasted long enough to get us home. At this point, we were stranded on a very busy highway which seemed quite dangerous. Using battery power, we were able to get off the highway. We then made arrangements to have the car towed, approximately 150 miles to a car dealer/repair business in Frederick MD. The vehicle was checked out by the car dealer who identified the EGR valve as the problem. However, they did not know when the part would be available , and still, 4 weeks later, do not have any date for availability of the broken part. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On 9/18/24 I was driving my Chevrolet 2018 Volt on a freeway, traveling at approximately 55 mph while starting to exit the freeway. In the middle of fast-moving traffic, on the freeway offramp and starting to decelerate, the car suddenly displayed a message saying "Propulsion Power is Reduced." A micro-second later, the displayed message changed to read "Action Required: Shift to Park" and in that moment I lost control of the car's powertrain. I continued to break, coming to a slow stop in the middle lane of a multi-lane offramp, with other cars speeding past and around me. I attempted to power the car down and reboot it, moving the gear shift into "Park" position as instructed, but nothing changed. The car remained totally inoperable. I was on a slight decline and noticed the car moving forward pulled by gravity, so I steered the car to the farthest right of the offramp/parallel street, where I put my hazard signals on and requested the car be towed to a mechanic. I was endangered because the car lost entire propulsion while in the middle of fast-moving freeway traffic, and fellow motorists were endangered as well. I have learned that this same behavior occurs routinely with 2nd generation Volts; that there is a special bulletin related to the car's BCEM *and* a related class-action lawsuit posed against GM/Chevrolet. I requested Chevrolet take preemptive action to repair the BCEM, as I am fearful the issue will repeat and cause additional danger to myself and fellow motorists, but Chevrolet says they cannot repair the part until it is diagnosed as defective... which will occur when/if the part fails again, and I'm already in danger.

while driving my vehicle when the outside temperature is 50 degrees Fahrenheit or below I turn my defrost on and for 30 plus seconds my front window completely fogs up and I am unable to see out of my front window and have zero visibility which caused me to crash.

On 8/30/2024 I had driven my 2018 Volt (purchased new on 3/27/2019), with about 45,000 miles on it, on a normally 5 hour trip. About 3 hours into my trip on I-94 my car suddenly slowed down with a "Reduced Propulsion" message and a check engine light that came on. (The engine probably has run less than 25,000 miles of the total miles I have driven it, with the rest being purely on battery.) I was extremely fortunate to have been in the slow lane when the car suddenly stopped accelerating. This could have easily turned out very, very bad. The next day I had a dealer diagnose the car for a little over $400 - they told me there was a problem with my engines EGR valve and that the parts were back ordered so they couldn't give me an indication of when it could be repaired. I got the car back to my home dealer and they charged me another $200 to re-diagnose the problem and came the same conclusion of a bad EGR valve. They too have been unable to get a valve from GM. They have quoted me about $4,000 to have a new valve installed when they can get one. Heck, the car only has 45,000 miles on it!!