2020 CHRYSLER PACIFICA Complaints

Twice now the A/C has quit, and a short time later the Hybrid battery severely overheats and the van shuts down. This happens at highway speeds, and the vehicle loses power and shuts down. This is dangerous to have a sudden shutdown at 75 MPH. When driving in hot weather for a couple hours, the electric A/C compressor quits. On this van, the Hybrid battery is cooled by the passenger HVAC system. When the A/C quits first you feel the air from the ducts getting warm. Then you get a message on the dash for "Battery Conditioning" and a Check Engine light. If you keep driving, it stalls and will not restart until the battery cools off. It takes about 3-4 hours to get the van to move again at reduced power. If you let it cool overnight, the van drives normally until the next incident. There are trouble codes set for battery overheating, P0A7E, P1AA6, P1A9A, P1A21, P1AA2, P1A9E. There have been multiple unsuccessful attempts to diagnose the van by Chrysler dealers. Dealers can't/won't replicate this due to having to drive for approximately 2 hours in high ambient temps. The vehicle is fine in moderate or cold temps due to not needing the A/C to cool the battery, it is cooled and heated by secondary systems in those conditions. This issue is very dangerous because lithium batteries do not like extreme high temperatures, this issue could cause a thermal runaway event of the battery. Many of the codes that were set are for the battery temperature exceeding 131F (55C), which is severely hot for Li-Ion. This is much hotter than safe high temp recommendation for Li-Ion. Recall 03A for not giving warning before stalling was performed, however this issue is not the same symptom, nor the same cause as that recall. That recall involves a transmission short, not battery overheating. My van has had multiple reflashes and is up to date on all software. My vehicle was a "lemon law" buyback for the same stall issue, and was purported to have been fixed before I purchased the van.

The second row seats recline locking mechanism failed. It does not lock leaving the seat to collapse and extend. It is unsafe because it does not lock making it unsable for anyone that sits in it and could cause injury. The component has not been inspected by the manufacturer or anyone. I am taking to dealership. Last time I did they did not inspect but told me they have seen problem before and requires seat replacement at $3600 per seat. I left without inspection when one seat failed. Now my other second row seat is also failing. My car is no longer able to transport my children as I do not have enough available safe seats with the second seat failing. There were no warning lamps. I noticed this when my daughter said her seat was moving while I was driving.

Vehicle shut off and locked up while driving. I was leaving my neighborhood and coming to a stop to turn right on to a major road. The vehicle powered down while in motion and the ignition locked. I could not restart it, I could not turn the wheel, I could not put it in neutral. The brake pedal was pushed down and would not release. I had children in the van. I turned hazards on and rolled the windows down but due to the sun shining, other motorists could not seem to see my hazards and we were nearly rear ended. I called 911 for assistance and AAA for a tow. At some point the entire vehicle was non operational and the windows would not roll back up and the hazard lights did not work. Police were there by that time. The vehicle was towed to Larry Miller Dodge where it now sits. I also independently had AAA battery service check the battery and have been told it needs replaced but that the vehicle should not just stop and lock up mid drive. We suspect an issue with the stop/start feature or multiple issues. Date of 8/4/2023. Vehicle has 3 months remaining on original warranty and approx 23k miles.

The car has lost power while driving multiple times. It was in the shop for many months more than once regarding the issue. An error came on the screen saying “vehicle speed may be reduced” then it stopped. The most recent time. After the recall fix. I got a second warning telling me to pull over because the car was going to stop. I barely made it off the highway into a parking lot. The time before that I was off the side of the road on a frontage road because the car could not make it to a parking lot.

Power steering will go out, therefore I have no power steering and have to pull over. The power steering light will come on the dash, and the power steering goes out. I did take the van to a Chrysler dealer in Warnes Robins, GA. Got on where with them, they made a list of things they suggested to be done. When ask will that fix the issue with the power steering, they stated could not guarantee that. Felt they were trying to take advantage of the situation. My van is a 2020 Chrysler Pacifica and 3 years old with 41,000. miles on it. The power steering should be the last thing that goes out, the light comes on and the power steering goes out making it hard the drive and steer. On top of all this the van isn't even paid for, still making monthly payments, can't afford 4,500.00 car repaid on top of car payment. Something is wrong with the power steering in 2020 Chrysler Pacifica power steering, like in the prior years.

The contact owns a 2020 Chrysler Pacifica Hybrid. The contact stated while driving 75 MPH, the vehicle independently accelerated and slowed down with a message to “Pull Over Safely – Engine Will Shut down” displayed. The contact pulled over and the vehicle shut off. The contact was able to restart the vehicle, but the failure persisted. The vehicle was towed to the dealer and the contact was informed that software update needed to be performed. The vehicle was repaired but the failure reoccurred. The manufacturer was contacted, and a case was filed but no assistance was provided. The failure mileage was 58,000.

The contact owns a 2020 Chrysler Pacifica Hybrid. The contact stated while driving 70 MPH, the vehicle lost motive power and stalled. The contact stated that after waiting for approximately 15 minutes, the vehicle failed to restart and was towed to the residence. The contact stated that prior to the failure the vehicle was repaired June 16, 2023, under NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System). The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.

My family was driving down the highway and an error message came on the dashboard telling us to " stop safely. Vehicle will shut off soon". The vehicle lost acceleration power making it dangerous to change lanes. We made it to the shoulder and turned off the car. We called our service station since they had just done a recall update regarding these types of error messages. We were able to start the car again with only the engine service light on. We assumed there was some type of issue as we transferred from battery to gas since it's a hybrid. We had just drained the battery when this error message had appeared. However, this happened again less than an hour later into our trip but and our battery had gained some power due to hills. We again pull to the shoulder. We're able to turn off the car. Let rest for 1 minute restart and then it was drivable. In total this happened six times on this long distance trip. Never before have we had this issue. The car has 24,000 mi on it. Our safety was put at risk because we had to pull onto the shoulder on busy highways and restart the car. We've scheduled a service appointment at the first available time with the local dealership. We are currently out of town on vacation and cannot take it to the dealership that did the recall.

My 2000 Chrysler Pacifica has only 65,000 miles on it I heard a popping noise when I turned the steering wheel took to Chrysler dealer to have it checked they said my steering box and stabler bars are worn out to fix it $4,100. No way should they be worn out with only 65,000 miles

When pulling up to a stop light the car shuttered and shifted into park and engaged the parking brake with no warning. Then it said safe hold temporarily disabled as well as the auto start stop light on the dash came on