2003 CHRYSLER PT CRUISER Complaints

FORTUNATELY AT A PARKING LOT INTERSECTION, THE RF TIE ROD END SUFFERED A CATASTROPHIC FAILURE CAUSING NO INJURY, DEATH OR ACCIDENT. THE BOLTED END WHICH FITS INTO THE SOCKET PULLED OUT FROM THE SOCKET. THERE WAS NO INDICATION AHEAD OF TIME THE TIE ROD END WAS NEAR FAILURE. I HAD PREVIOUSLY REPLACED THE LF TIRE ROD END. IN DOING SO, I WAS APPALLED AT THE POOR DESIGN OF THE PART. CHRYSLER'S OBJECTIVE TO PRODUCE A LOW PRICE JUST BARELY ADEQUATE PART WAS OBVIOUS. TYPICALLY, THIS PART IS MADE FROM A FORGING, CHRYSLER CHOSE TO PRODUCE THE PART FROM STAMPED SHEET METAL. I REPLACED THE PART WITH A FORGED, AFTER MARKET PART FROM MOOG. IT IS MY OPINION THIS IS AN UNSAFE DESIGN. IT WAS VERY FORTUNATE THIS FAILURE OCCURRED WHERE IT DID OTHERWISE, MY WIFE COULD HAVE KILLED OR SEVERELY INJURED. *TR

TL* THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THE CONTACT STATED THE POWER STEERING HOSE WAS LEAKING ON THE ENGINE. THE CONTACT ALSO HEARD A LOUD NOISE AND THE SMELL OF BURNING FUMES EMITTING INTO THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE HOSE AND MOTOR MOUNT NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT OFFER ANY ASSISTANCE SINCE HER VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 37,000 AND THE CURRENT MILEAGE WAS 42,000.

I WAS DRIVING MY 2003PT CRUIZER AND ALL OF THE SUDDEN MY WATER GAUGE WENT INTO RED ,HAD TO PULL OVER LATER ON CHANGED THERMOSTAT AND FLUSHED RADIATOR,RAN FINE FOR A DAY THEN OVERHEATING AGAIN FOLLOWING DAY SEEMS TO BE NOTHING WRONG NO LEAKING,JUST HAD TRANI.FIXED 2 MONTHS,HUSBAND DROVE CAR AGAIN AFTER ABOUT SEVEN MILES CAR STARTED OVERHEATING AGAIN,WENT TO RED HAD TO PULL OVER FOR CAR TO COOL DOWN,WHAT IS GOING ON,DOES CHRYSLER HAVE ANY RECALLS ON THIS PROBLEM? *JS

AT APPROXIMATELY 70,000 MILES THE FOG LIGHTS WOULD REMAIN ON EVEN IN THE OFF POSITION. PLACING THE TURN SIGNAL IN THE DOWNWARD POSITION WHEN EXITING THE VEHICLE WOULD REMEDY SITUATION, FURTHER FIXED BY PULLING THE FOG LIGHT FUSE. LATTER ON AT 80,000 MILES THE LOW BEAMS FAILED AND WOULD NOT TURN ON. HIGH BEAMS WOULD WORK OR THE FOG LIGHTS WOULD WORK (AFTER PUTTING THE FUSE BACK IN). THE DANGER WAS FURTHER ENHANCED BY WHEN YOU WOULD USE THE TURN SIGNAL THE FOG LAMPS WOULD SHUT OFF. THIS WAS FIXED BY REMOVING THE MULTI-STICK FROM THE STEERING COLUMN AND REPLACING IT WITH A NEW COMPONENT. ALL ISSUE WERE RESOLVED BY THIS FIX. *TR

CAR IS MANUAL TRANS, MY WIFE DRIVES IT AND HAS COMPLAINED FOR QUITE A WHILE OF CAR JUMPING I TOLD HER IT WAS HER, THE CAR NEVER DID IT FOR ME DURING TEST DRIVES. IN JANUARY SWITCHED CARS WITH HER IT TOOK 2 WEEKS FOR IT TO HAPPEN. COMING TO A STOP CLUTCH WOULD NOT DISENGAGE. HAS ALSO TRIED TO ENGAGE ON ITS OWN AT LIGHTS. WENT TO DEALER THEY SAID NO RECALLS ARE OPEN ON CAR AND RECALL FOR SAME PROBLEM WAS ALREADY DONE SO YOU ARE ON YOUR OWN. SEEMS LIKE NEWER OF THE SAME PART WAS INSTALLED. CAR IS OFF THE ROAD AND I HAVE SAID MY SORRIES TO MY WIFE. PLEASE ADVISE. THANK YOU. *TR

TL* THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THE VEHICLE WAS PREVIOUSLY INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 03V076000 (POWER TRAIN:CLUTCH ASSEMBLY) AND WAS REPAIRED PRIOR TO THE CONTACT HAVING OWNERSHIP OF THE VEHICLE. WHILE DRIVING APPROXIMATELY 30 MPH, THE THE CONTACT WAS UNABLE TO SWITCH GEARS. THE CONTACT WAS DEPRESSING THE CLUTCH WHEN HE NOTICED THAT THE GEAR SHIFTER WAS FRACTURED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN STATED THE CLUTCH ASSEMBLY AND THE SHIFTER CABLE WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 67,000.

YEAR: 2003 MAKE: CHRYSLER MODEL: PT CRUISER ENGINE: 2.4L TURBOCHARGED COMPONENTS: POWER STEERING HIGH PRESSURE HOSE THE POWER STEERING PRESSURE HOSE WAS RUBBING UP AGAINST THE TRANSMISSION OF THE VEHICLE LISTED ABOVE. THE RESULT OF THE POWER STEERING PRESSURE HOSE RUPTURED DUE TO CONTACT WITH THE HOT TRANSMISSION DURING NORMAL DRIVING. THIS HAS BEEN THE FIRST INCIDENT SINCE THE OWNER PURCHASED THE VEHICLE. THE OWNER PURCHASED NEW POWER STEERING PRESSURE HOSE AND HAD IT INSTALLED AT A LOCAL AUTOMOTIVE SHOP. *TR

I AM HAVING OVERHEATING PROBLEMS. I HAVE TALKED WITH OTHER OWNERS OF PT CRUISER WHO HAVE HAD THE SAME ISSUES. IT OVERHEATS AT IDLE AND WHILE DRIVING. I HAVE NOT FOUND A SOLUTION TO THE PROBLEM YET. I HAVE HAD IT PRESSURE TESTED AND THE THERMOSTAT CHANGES AND IT IS STILL OVERHEATING TO DANGEROUS LEVELS. *KB

I AM HAVING ISSUES WITH MY 2003 CHRYSLER PT CRUISER. THE FOG LIGHT SWITCH HAS WORN OUT AND IS CAUSING MY CAR BATTERY TO BE DRAINED DUE TO THE FOG LIGHT STAYING ON. I WAS GOING TO REPLACE THE PART. HOWEVER I WAS CHECKING ONLINE FOR QUOTES WHEN I STUMBLED UPON A FORUM FULL OF COMPLAINTS FOR THE SAME ISSUE. THERE ARE OVER 600 COMMENTS REGARDING PROBLEMS WITH THE PT CRUISER, MOST OF THEM WITH THE SAME ISSUE. I HOPE THERE IS SOMETHING SOMEBODY CAN DO ABOUT THIS. I AM HOPING FOR A RECALL OF THE PART, I WILL BUY A NEW PART I JUST DON'T WANT THE SAME PART AGAIN. THIS IS A DANGEROUS PROBLEM BECAUSE I HAVE BEEN LEFT STRANDED DUE TO MY CAR BEING DRAINED OF BATTERY LIFE MORE THAN 5 TIMES. *TR

WHEN STARTING CAR IN MORNING, IT MADE A VERY UNFAMILIAR SOUND THEN THE SOUND DISAPPEARED. AFTER DRIVING A SHORT DISTANCE THE CAR WAS PARKED. UPON RESTARTING THE CAR, WE HEARD TWO LOUD THUDS AS IF SOMETHING HAD FALLEN TO THE PAVEMENT. WE SAW NOTHING UNDER THE CAR, BUT AFTER LOOKING UNDER THE HOOD TWO MOTOR MOUNTS WERE BROKEN AND ENGINE WAS COMPLETELY DISLODGED. MECHANIC TOLD US THIS WAS HIS THIRD REPAIR OF THIS TYPE BECAUSE THE MOTOR WAS TOO HEAVY FOR THE TYPE OF MOTOR MOUNTS CHRYSLER USED IN THE PT CRUISER. PLEASE CALL OWNERS TO HAVE THIS PROBLEM CORRECTED BEFORE OFFICIAL RECALL DAMAGES CHRYSLERS IMAGE. *TR