2003 CHRYSLER PT CRUISER Complaints

The front passenger seat heating system experienced a catastrophic electrical malfunction. While the vehicle was started and parked in our driveway, the front passenger seat suddenly developed an extreme hot spot and became engulfed in flames even though the heated seat switch was in the OFF position and had not been activated. The failed heated seat component has been retained and is available for inspection. The vehicle has not been inspected by a dealer or service center because the incident occurred at our residence and the vehicle is currently undriveable due to burned electrical wiring. Attempting to start or operate the vehicle could result in an electrical short because of the exposed and damaged wiring caused by the fire. Both the local police department and fire department responded to the scene and inspected the vehicle. There were no warning lights, warning messages, unusual odors, or prior symptoms indicating a problem before the fire occurred. This incident represents a significant fire hazard because the heated seat ignited without being turned on. Had this occurred while the vehicle was being driven or while occupants were seated in the vehicle, it could have resulted in serious injury or death due to burns, smoke inhalation, or loss of vehicle control. Likewise, had the vehicle been parked inside an attached garage, the fire could have spread to the residence and placed lives at risk.

WHen the fog lights are engaged, smoke and burning smell appears to be coming inside the steering wheel on the left side.

The clutch will not disengage every time and never fully disengages. I noticed my car had a recall for this problem in the past, so before doing the work, I called a dealer for Chrysler and was informed that the recall had already been performed. So I took it upon myself at my own expense to have the clutch replaced. It worked fine for a few months, but it started doing the same thing again.

The contact owns a 2003 Chrysler equipped with Douglas, Tire line: Dug Xtra-Trac II, Tire size: 205/55R/16 91T and DOT number: N60FN11R. The contact stated that while driving at an undisclosed speed, the contact noticed that the vehicle started to perform slowly when the front passenger side tire inadvertently exploded. No warning lights illuminated. The vehicle was taken to Walmart where the tire was replaced. The contact stated that the front passenger side tire started to leak air. The contact then stated that she noticed that a bubble had developed on the sidewall of the tire. The vehicle was not diagnosed or repaired. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 157920.

On the way home from work my vehicle began smoking. The next exit off the freeway I80 was taken. As I exited my vehicle became hard to steer. I was able to get it to the closest auto repair shop which was Firestone. The power steering hose had a leak which caused the smoke and my vehicle being hard to steer. After 3 attempts with Firestone and them consulting with Chyrsler Service Department in Fairflied, California I had my vehicle towed to my mechanic. He also had trouble getting the new hose to fit on my vehicle. My mechanic also consulted with the Chrysler Service Department in Antioch, California. They assured him that was the correct replacement hose that Chrysler had replaced because the original hose had been recalled and they no longer carried the orignal hose. The only problem is my mechanic nor the Firestone mechanics could get it to fit. I have contacted Chrysler several times with them not taking reponsibility for the non fitting hose as the claim my VIN is not one of the vehicles affected. Attached you will find the original recall notice sent to me in 2011, the letter I sent to the address on the recall notice and all the receipts of attempts to fix my vehicle. The letter I sent to the address on the recall notice was returned as "unable to forward". I'm hoping other PTs with VIN not listed had the same problem as I and can cause Chrysler to repair and reimburse such vehicles.

Was warming my car up and drove 2 miles to my mom's house and turned it off. Came out about 30 minutes later and the car was full of smoke. Aired out the car and noticed a burnt hole in the middle of the passenger seat. The seat warmer had malfunction and started the seat on fire. Even with the vehicle turned off.

I REPLACED MY VEHICLES BATTERY 2 DAYS AGO(NOV 12, 2019)(VERY OLD BATTERY AND WITH THE COLD IN MASSACHUSETTS IT NEEDED TO BE CHANGED). NOW WITH A PROPERLY FUNCTIONING BATTERY THE VOLTAGE REGULATOR IN PCM (NOT ALTERNATOR) IS SIGNALING ALTERNATOR TO RAISE CHARGING VOLTAGE INTERMITTENTLY TO AS HIGH AS 17.1VOLTS, BUT HAS BEEN FREQUENTLY BOUNCING BETWEEN 14.1V -16.7VOLTS. THIS INCREASE OF VOLTAGE TO A UNSAFE LEVEL CAUSES ALL ELECTRICAL ACCESSORIES THAT ARE IN CONNECTED TO THE CHARGING SYSTEM AND ARE OPERATIONAL TO FLASH/ FLICKER. EXTREMELY DISTRACTING AT NIGHT WITH HEADLIGHTS AND DASHBOARD FLASHING/ FLICKERING. AFTER A LOT OF RESEARCH I FOUND OUT THE PCM NEEDS TO BE REPROGRAMMED WITH THE PROPER UPDATED FIRMWARE IN ORDER TO FIX THE FACTORY WEAK PARAMETERS. I SPOKE WITH A SERVICE MANAGER TODAY(NOV 14,2019) AT MY LOCAL CHRYSLER DEALERSHIP (CENTRAL JEEP CHRYSLER DODGE RAM FIAT @ 56 BOSTON PROVIDENCE TPKE, NORWOOD, MA 02062) ABOUT THE PROBLEM AND ASKED TO HAVE MY PCM REPROGRAMMED SINCE ONLY THAT SPECIFIC MODEL CAR MANUFACTURES SERVICE SHOP WILL HAVE THE CAPABILITY AND PCM FIRMWARE TO REPAIR IT. THE MANAGER REFUSED TO DO ANY WORK ON MY CAR SINCE HE SAID, "I WONT TOUCH CARS OLDER THAN 10YEARS AND CLOSE TO 100,000MILES". THEN ASKED IF I WAS EVEN A CUSTOMER AT THAT SPECIFIC LOCATION, SAYING NO AGAIN AFTER I SAID I WASN'T. THERE IS NO OTHER OPTION THAN THE FACTORY DEALERSHIP TO FIX A FACTORY FLAWED PCM, WHICH MAKES THE RISK OF MY BATTERY EXPLODING DUE TO THE INCREASED REGULATED VOLTAGE VERY LIKELY. THIS PROBLEM ISN'T NEW TO CHRYSLER SINCE THEY HAVE ISSUED SEVERAL TSB(S) IN MY SPECIFIC VEHICLE AND THIS EXACT PROBLEM: 18-112-16 18-026-03 REV.A 18-016-03 18-020-04

THERE WAS AN ELECTRICAL FIRE WHERE THE RADIO CUP HOLDERS AND THE SHIFTER. CAR IS UNDRIVEABLE DUE TO THE DAMAGE. MY CAR WAS STATIONARY AT THE TIME. THE RADIO KEPT TURN ON AND OFF. I HEARD CRACKING WHEN I WENT INTO WORK. WHEN I CAME OUT I SAY THERE WAS A WHOLE LOT OF DAMAGE. I DID GET THE CAR STARTED AND WAS ABLE TO GET IT HOME, BUT IT'S NOT DRIVABLE SINCE THE CAR DIED AS I WAS PULLING INTO MY DRIVEWAY. WHEN I WENT TO PUT IT INTO PARK IT WAS LIKE PARK WAS NOT AN OPTION. AMD THE CAR KEPT MOVING SO I PUT THE E BREAK ON.

I DON'T TRULY KNOW WHAT'S HAPPEN TO IT N IF IT'S BEEN FIXED BUT I DO KNOW THAT PRIOR IT WOULD HAVE UNCONTROLLABLE SPEED CONTROL N STEERING PROBLEMS N GPS N VIDEO N AUTO RECORDING N RADIO FREQUENCIES.

VEHICLE IS LEAKING POWER STEERING FLUID. FOUND RECALL NOTICE FOR MY YEAR MODEL BUT CHRYSLER SAYS MY VIN IS NOT INCLUDED IN THE RECALL. ADDED FLUID ABOUT 3 MONTHS AGO AND STEERING WAS FINE UNTIL A WEEK AGO. SINCE THEN, FLUID ONLY LASTS A DAY BEFORE IT HAS TO BE REFILLED.