1996 DODGE CARAVAN Complaints

BCM-1, (WARRANTY) LOSS OF DASH FUNCTIONS 1996: BCM-2 ESTIMATE $1200 REPLACED CHRYSLER P/N P4686727 LOST 95,000 MILE ODOMETER FOR A WORKING BCM FROM JUNKYARD (2001), BCM-3, LOST FUEL GAUGE AND SPEEDOMETER BCM FROM JUNKYARD FIXED P/N P46867(2006) BAD WINDSHIELD REPLACEMENT LEAKS WATER INTO CABIN, BCM-3, FAILED AGAIN CURRENTLY NO WIPERS, NOT ABLE TO FIND A 1996/1997 BCM ONLY 1998 PLYMOUTH VOYAGER BCM P/N P04801062AE. WILL TRY TO VALIDATE COMPATIBILITY TONIGHT. ADEL CHRYSLER ESTIMATE $1,400 PLUS LABOR. ALREADY GAVE THEM $742 FOR TUNE UP AND TROUBLE SHOOTING WHAT THEY SAID WAS A BAD MULTI-SWITCH ($110) DID NOT FIX AND NO DISCOUNT FOR NOT KNOWING HOW TO DIAGNOSE A PROBLEM PROPERLY. THEIR NUMBER IS 515-993-4587 CORY (KARL IS THE SERVICE MANAGER-OWNER'S SON). *TR

TL*THE CONTACT OWNS A 1996 DODGE CARAVAN. THE VEHICLE WAS REPAIRED ACCORDING TO A RECALL, BUT THE FAILURE HAS RESURFACED. FUEL IS LEAKING FROM THE FUEL RAIL INTO THE ENGINE COMPARTMENT, WHICH IS A FIRE HAZARD. THE DEALER STATED THAT THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COST. NHTSA CAMPAIGN ID NUMBER 00V268000 THE FAILURE MILEAGE WAS 150,000. UPDATED 03/23/09. *LJ THE CONSUMER STATED THE DEALER FIXED THE RECALL FOR RECALL. UPDATED 03/23/09.*JB

COMPLETE AND SUDDEN BRAKE FAILURE WHILE APPROACHING A STOPLIGHT. I WAS VERY LUCKY TO BE ABLE TO STEER AROUND THE VEHICLE IN FRONT OF ME TO AVOID A SERIOUS ACCIDENT. PRIOR TO THE INCIDENT THE BRAKES WERE WORKING FINE. THIS IS AN EXTREMELY DANGEROUS AND SERIOUS FAILURE MODE. I HAVE SEEN OTHER REPORTS OF THIS ON THE WEB AND IT IS ONLY A MATTER OF TIME BEFORE SOMEONE GETS SERIOUSLY INJURED OR KILLED... *TR

TL*THE CONTACT OWNS A 1996 DODGE CARAVAN. THE CONTACT STATED THAT THE SHOCKS UNDERNEATH THE DRIVER'S SIDE OF THE VEHICLE WERE GOING STRAIGHT THROUGH THE METAL, WHICH HOLDS THE WHEEL IN PLACE. THE FAILURE CAUSES THE VEHICLE TO HESITATE AT TIMES. WHILE DRIVING OVER SMALL BUMPS IN THE ROAD AT 15 MPH, THE VEHICLE SUDDENLY VEERED TO THE OPPOSITE SIDE OF THE ROAD. THE CONTACT HAS TAKEN THE VEHICLE TO THE DEALER A FEW TIMES, BUT THEY STATED THAT THERE WAS ONLY A KIT USED TO SEAL THE SHOCKS IN PLACE; HOWEVER, IT IS A TEMPORARY REMEDY AND THE FAILURE WOULD MOST LIKELY RECUR. THERE IS CURRENTLY NOT A PERMANENT REPAIR FOR THIS DEFECT. THE FAILURE MILEAGE WAS 90,000 AND CURRENT MILEAGE WAS 115,000.

TL*THE CONTACT OWNS A 1996 DODGE CARAVAN. THE CONTACT ATTEMPTED TO DRIVE HER VEHICLE AND NOTICED THAT THERE WAS A FIRE NEAR THE HEADLIGHT SWITCH. THE FIRE WAS EXTINGUISHED BY THE CONTACT. THERE WERE NO INJURIES AND THE FIRE DEPARTMENT WAS NOT CALLED. THE VEHICLE WAS ABLE TO BE DRIVEN BACK TO THE CONTACT'S RESIDENCE. THE VEHICLE HAS NOT BEEN TO THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 192,400.

TL*THE CONTACT OWNS A 1996 DODGE CARAVAN. WHEN THE KEY IS NOT IN THE IGNITION, THE VEHICLE WILL SHIFT OUT OF THE PARK POSITION. THE VEHICLE BACKED INTO A FENCE AND THEN STRUCK A TREE. THE DEALER AND MANUFACTURER HAVE NOT BEEN NOTIFIED. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 110,000.

TL*THE CONTACT OWNS A 1996 DODGE CARAVAN. WHILE DRIVING IN INCLEMENT WEATHER CONDITIONS, WATER, OR WITH THE AIR CONDITIONER ACTIVATED, THE VEHICLE TEMPORARILY LOSES CONTROL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE SERPENTINE BELT SLIPPED OFF. NO WARNING LIGHTS ILLUMINATED AT THE TIME OF THE FAILURE. THE VEHICLE WAS REPAIRED APPROXIMATELY FIVE TIMES, HOWEVER, THE FAILURES RECURRED TWO MONTHS LATER. THE MANUFACTURER WAS UNABLE TO PROVIDE ASSISTANCE. THE SPEED WAS UNKNOWN. THE FAILURE MILEAGE WAS 119,000 AND CURRENT MILEAGE WAS 135,000. UPDATED 01-23-08. *KB THE DEALER STATED UPPER RADIATOR LOOSE, LOOSE CLAMPS, FRONT BRAKE PADS, BELT TENSIONER, OXYGEN SENSOR, AND ALTERNATOR BRACKET. UPDATED 01/23/08 *TR

FRONT STRUT MOUNTS ON EVERY 96 THRU 00 CARAVAN, VOYAGER, CHRYSLER MINIVANS THAT I'VE LOOKED AT,HAVE SERIOUS RUST PROBLEMS, ESPECIALLY THE LEFT SIDE, RESULTING IN THE STRUT ITSELF BREAKING THROUGH AND HITTING THE BOTTOM OF THE HOOD, AND RESULTING OF LOSS OF CONTROL OF THE VEHICLE WHEN THIS HAPPENS. THE REPAIR COST TO HAVE THIS REPAIRED IS VERY COSTLY,$300-1000 TO MAKE THE VEHICLE SAFE TO DRIVE. I WOULD LIKE TO SEE THE NHTSA LOOK INTO THIS PROBLEM ON ALL 96 THRU 00 MINI-VANS BEFORE SOMEBODY HAS A FAILURE WHILE DRIVING WITH THEIR FAMILY, AND HAVE A FATAL ACCIDENT. PLEASE CURE THIS PROBLEM BEFORE AND NOT AFTER PEOPLE ARE KILLED DUE TO THIS STRUCTURAL FRONT STRUT TOWER FAILURE. *TR

TL*THE CONTACT OWNS A 1996 DODGE CARAVAN. THE CONTACT STATED THAT THE FUEL TANK CAUSES FUMES TO ENTER THE PASSENGER COMPARTMENT OF THE VEHICLE, AS WELL AS FUEL LEAKAGE. HE STATED THAT THE FUEL TANK WAS REPLACED A YEAR AGO, BUT STILL EMITS FUMES. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER RECALL # 99V216000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP). THE INCIDENT AND PURCHASE DATES WERE UNKNOWN. THE CURRENT MILEAGE IS 165,000 AND FAILURE MILEAGE WAS 100,000.

1999 DODGE CARAVAN. WHILE DRIVING ON THE OHIO TURNPIKE IN THE LEFT LANE THE RIGHT FRONT TIRE SEPARATED FROM THE AXLE . *MC *JB