1997 DODGE CARAVAN Complaints

TL*THE CONTACT OWNS A 1997 DODGE CARAVAN. THE REAR DRIVER SIDE VENT WINDOW IS STUCK IN AN INWARD POSITION AND CANNOT BE OPENED. WHILE DRIVING AT ANY SPEED, THE INSTRUMENTAL PANEL LIGHTS BEGIN TO FLASH AND THE VEHICLE SHUTS OFF. THE VEHICLE CAN ONLY BE RESTARTED AFTER WAITING 15 MINUTES. THE DEALER HAS NOT DIAGNOSED THE VEHICLE. THE FAILURE MILEAGE WAS 150,000.

TL*THE CONTACT OWNS A 1997 DODGE CARAVAN. THE CONTACT STATED THAT THE VEHICLE WOULD START, SHUT OFF, AND THE ELECTRICAL SYSTEM WOULD MALFUNCTION. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE WOULD TURN OFF AND THE SPEEDOMETER WOULD MALFUNCTION. THE CONTACT HAS TAKEN THE VEHICLE TO BE SERVICED MULTIPLE TIMES. THE CURRENT MILEAGE WAS 142,000 AND FAILURE MILEAGE WAS 32,000.

ON RAINY DAYS WHEN MAKING SHARP LEFT TURN, THE 97 DODGE CARAVAN (3.0 V6) LOOSES POWER STEERING AND GOES OUT OF CONTROL. THE SERPENTINE DRIVE BELT SLIPPED OUT OF THE TENSIONER PULLEY CAUSING THE POWER STEERING LOSS LEADING TO THIS HAZARDOUS CONDITION WHILE DRIVING IN ADDITION TO THE ROAD BEING WET AND SLIPPERY. THERE IS A POTENTIAL FOR A CRASH OR DEADLY ACCIDENT IF THIS CONDITION HAPPENS. THIS CONDITION HAPPENED FOUR TIMES IN THE PAST TWO MONTHS. *TR

(1) NO BRAKES, BRAKE FAILURE. (2) BADLY RUSTED BRAKE LINES. (3) REPLACE BRAKE LINES. *TR

THE STRUT TOWER ON THE 1997 DODGE CARAVAN, THAT HAS ONLY 85,500 MILES RUSTED AND NEEDED TO BE REPLACED. AFTER RESEARCHING THIS PROBLEM I DISCOVERED THAT THIS WAS A COMMON PROBLEM. DODGE ADMITTED TO A DESIGN FLAW FOR THE PREMATURE RUSTING STRUT TOWERS. A TECH SERVICE BULLETIN FROM CHRYSLER DATED OCTOBER '02 EXPLICITLY STATED THAT ALL '1996 TO 19'99 CHRYSLER VANS PLYMOUTH, DODGE, AND CHRYSLER, HAD THE PROBLEM WITH THE STRUT TOWERS. ALL OF THEM WILL EVENTUALLY RUST FROM THE BOTTOM UP. AS I STATED, THE STRUT TOWERS WERE DEFECTIVE IN THERE DESIGN. CHRYSLER HAS A WARRANTY PART NUMBER 05086513AA BUT REFUSES TO FIX A KNOWN DANGEROUS DEFECT, BECAUSE THE VAN IS OVER THE 7 YEAR, 100,000 MILE, WHICH EVER COMES FIRST WARRANTY. THIS IS OUTRAGEOUS, ESPECIALLY SINCE THIS VAN HAS BEEN TAKEN TO THE DODGE DEALER FOR ALMOST ALL MAINTENANCE NEEDS AND YEARLY STATE OF MAINE SAFETY INSPECTIONS, AND THIS ISSUE WAS NEVER MENTIONED. CLEARLY, WHEN THE RUSTED STRUT TOWER GIVES, THE STRUT WILL COME UP THROUGH THE HOOD. AT THAT POINT, LIVES WILL BE IN DANGER, AS THE PROBABILITY OF LOSING CONTROL OF THE VEHICLE IS INEVITABLE. PLEASE CONSIDER THIS MY FORMAL COMPLAINT. WILL CHRYSLER LIVE UP TO THE RESPONSIBILITY AND REPAIR THIS KNOW DEFECT FOR THOSE OF US OUT OF THE WARRANTY TIMELINE.*AK

TL*THE CONTACT OWNS A 1997 DODGE CARAVAN. THE CONTACT STATED THAT THE TRANSMISSION AND THE O-RINGS ON THE FUEL INJECTORS ARE FAILING. CHRYSLER STATED THAT THE VEHICLE WAS NOT INCLUDED IN RECALL # 00V268000 (FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM). THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE IS 192,000 AND FAILURE MILEAGE WAS 30,000.

I HAVE A 1997 DODGE CARAVAN SE PURCHASED NEW. TWO YEARS AGO I NOTICED A SPOT ON THE ROOF, AND ANOTHER ON THE HOOD WHERE THE POLYCOAT WAS BEGINNING TO PEEL. WITHIN TWO YEARS THE CAR LOOKED AS IF IT HAD SOME KIND OF DISEASE. I BEGAN TO NOTICE OTHER CARAVANS OF SIMILAR AGE, AND THEY HAD THE SAME PROBLEM. I SAW OTHER MAKES OF CARS THAT WERE MUCH OLDER WITH ORIGINAL PAINT JOBS AND THEY WEREN'T EXPERIENCING THIS PROBLEM. I AM REALLY DISAPPOINTED WITH THE PAINT JOB AND POLY COAT ON THE DODGE CARAVAN. I FEEL FOR WHAT WE PAYED FOR, AND WITH THE PROBLEMS WE HAVE EXPERIENCED , SUCH AS THE WINDSHIELD WIPERS COMING ON BY THEMSELVES, THE SERVICE ENGINE LIGHT COMING ON AND GOING OFF, THE INTERIOR LIGHT COMING ON OR NOT WHEN THE DOOR WAS OPENED, THE WARNING BELL NOT GOING OFF WHEN THE DOOR WAS OPEN, THE EMERGENCY BRAKE WORKING OR NOT WORKING, THE FOGGING OF THE PLASTIC HEADLIGHTS - AT LEAST THE PAINT JOB SHOULD HAVE LASTED!*AK

THE VAN HAS A HARD TIME GOING IN REVERSE WHEN IT IS COOL OUTSIDE. AND WHEN GOING IN DRIVE THE VAN HAS A HARD TIME SHIFTING INTO ANY GEAR. SOMETIMES THE WHILE DRIVING DOWN THE ROAD THE SPEEDOMETER FLIPS OUT AND SHOOTS TO 0 TO 80 3 TIMES BEFORE IT STOPS AND GOES BACK TO THE RIGHT SPEED THAT I AM GOING. *JB

MARCH 3,2007 I WAS DRIVING TO WORK IN THE RAIN. I DROVE FOR 30 MINUTES AND THEN THE SERPENTINE BELT CAME OFF MY 97 DODGE CARAVAN AGAIN. THIS HAS HAPPENED SEVERAL TIMES. WHEN THIS HAPPENS, THE VEHICLE IS ALMOST IMPOSSIBLE TO STEER. ONCE AGAIN, I WAS LUCKY AND DID NOT HAVE AN ACCIDENT. SECONDLY, MY SMALL CHILD WAS NOT IN THE VEHICLE. THIS IS A VERY DANGEROUS SITUATION AND ON THIS MODEL AND YEAR OF DODGE CARAVAN THERE ARE NUMEROUS COMPLAINTS ON THE INTERNET OF THIS PROBLEM. I DID MISS A DAY OF WORK AND HAD TO HAVE THE BELT PUT BACK ON THE CAR, AS WELL AS HAVING THE VEHICLE TOWED FOR ABOUT 25 MILES. *JB

TL* THE CONTACT OWNS A 1997 DODGE CARAVAN. THE CONTACT RECEIVED A SAFETY RECALL NOTICE FOR THE VEHICLE AFTER PAYING FOR THE RELATED REPAIRS. THE CONTACT STATED THAT THE FUEL PUMP WAS REPLACED THREE TIMES. THE CONTACT HAD TWO FAULTY FUEL PUMPS, AND BROKE DOWN TWICE WHILE DRIVING 35 MPH. THE VEHICLE WAS TOWED TWICE . THE FAILURE MILEAGE WAS 110,000. AFTER THE THIRD FAILURE THE MECHANIC INSTALLED A BRAND NAME OTHER THAN THE ONE LISTED ON THE RECALL NOTICE. THE CONTACT REQUESTED 100% REIMBURSEMENT AND RECEIVED 50% FOR THE REPAIRS. THE REPLACEMENT FUEL PUMP WASAN AFTER MARKET FUEL PUMP MODULE AND THE SAFETY RECALL NOTICE WAS FROM RECALL MANAGEMENT, INC., AND THE MANUFACTURER OF THE PART WAS MASTER/TIGAS. THE CONTACT WOULD LIKE A COPY OF THE COMPLAINT SENT TO MASTER TIGAS AND NOT DAIMLER CHRYSLER DUE TO THE SPECIFICS LISTED ON THE RECALL NOTICE. THE CURRENT MILEAGE WAS 145,000. *AK UPDATED 03/19/07. *JB