2002 DODGE DAKOTA Complaints

RIGHT FRONT BRAKE CALIPER STUCK, BRAKE GOT HOT, SMOKE CAME OUT OF WHEEL WELL. *TR

MY TRUCK ONLY HAS 60K MILES, DON'T DRIVE A WHOLE BUNCH, BOUGHT IT BRAND NEW IN 2002. 2 TIMES I HAVE HAD THE FRONT PASSENGER WHEEL AND BREAKS CATCH ON FIRE DUE TO THE BRAKES/CALIPER LOCKING UP. ONE INCIDENT WAS ONLY GOING ABOUT 25 MPH, THE OTHER INCIDENT ON HIGHWAY AROUND 55 MPH. BETWEEN TOWING AND REPLACING BRAKES, ROTORS, CALIPER, BRAKE LINES, AROUND $500-$750 EACH TIME. I AM ON HERE BECAUSE MY BRAKE LINE FROM FRONT TO BACK HAS ERODED AWAY NEAR GAS TANK, SAME AS EVERYONE'S I HAVE READ AND BECAUSE MY PASSENGER WHEEL HAS BEGAN TO GIVE SIGNS THAT IT WILL BE LOCKING UP AGAIN. HAVE ALSO HAD TO REPLACE THE FRONT DRIVERS SIDE BRAKE LINE DUE TO THE LINE BEING CRACKED WHERE THE BANJO BOLT IS. THESE SEEM TO ALL BE HUGE ISSUES AND VERY DANGEROUS THAT NEED TO BE ADDRESSED. THANK YOU *TR

TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. WHILE DRIVING APPROXIMATELY 20 MPH, THE CALIPERS SEIZED ON THE PASSENGER SIDE ROTORS. THE FAILURE OCCURRED SEVERAL TIMES AND THE CONTACT REPLACED THE CALIPERS HIMSELF. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 44,000. UPDATED 9/4/14*CN

TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT NOTICED SMOKE RISING NEAR THE FRONT PASSENGER SIDE WHEEL AND THE VEHICLE BEGAN TO VEER TO THE RIGHT. THE CONTACT DISCOVERED THAT THE FRONT PASSENGER SIDE BRAKE CALIPER FAILED. THE FAILURE OCCURRED NUMEROUS TIMES. THE CONTACT REPLACED THE FRONT PASSENGER SIDE CALIPER AND ROTOR AND REMEDIED THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 50,000.

WHILE I WAS TRAVELING UPHILL THE ENGINE SHUT OFF AS I WAS GOING OVER THE FREEWAY OVERPASS TO ENTER THE SOUTH BOUND FREEWAY ENTRANCE. I LOST ALL POWER STEERING AND BRAKES AND HAD JUST ENOUGH POWER TO ROLL DOWNHILL PAST THE FREEWAY ENTRANCE TO TURN ON A STREET TO ROLL TO A STOP JUST AS I TURNED THE CORNER. THANK GOODNESS I WASN'T ON THE FREEWAY WHEN THIS HAPPENED OR HAVE ANY CARS IN FRONT OF ME AS I WAS ROLLING DOWNHILL BECAUSE I DIDN'T HAVE BRAKES. I TRIED TO START THE ENGINE AND GOT NO POWER, BUT NOTICED THE MILEAGE READER SAID "NO BUS". I HAD THE TRUCK TOWED HOME. FOR THE NEXT 2-3 MONTHS THE TRUCK WOULD START SOMETIMES AND RUN FOR ABOUT 15 MINUTES AND SHUT OFF AND OTHER TIMES IT WOULD JUST TURN OVER AS IF IT HAD A BAD ALTERNATOR.THE STRANGE THING IS WHEN IT WAS 70-74 DEGREES OUTSIDE AND BELOW THE TRUCK WOULD START AND RUN FOR ABOUT 15 MINUTES BEFORE SHUTTING OFF AND WHEN YOU TRIED TO START THE ENGINE RIGHT AFTER IT WOULD JUST TURN OVER AND NOT START. IF IT WAS CLOSE TO 80 DEGREES OR HOTTER OUTSIDE, THE TRUCK WOULD NEVER START, IT WOULD JUST TURN OVER LIKE A BAD ALTERNATOR. AFTER DOING SOME RESEARCH ON THE "NO BUS" CODE, I FOUND OUT THAT THIS WAS AN INDICATION THAT THE POWER CONTROL MODULE (PCM/ECM COMPUTER) WAS BAD. AFTER FURTHER RESEARCH I FOUND THAT HEAT AFFECTED THE PCM AND THAT'S WHY IT STARTED ON SOME DAYS AND NOT OTHERS. I BOUGHT A REBUILT PCM AND THE TRUCK DID THE SAME THING AFTER A MONTH AND A HALF. THIS PART SHOULD NOT BE SOLD BY AS A REBUILD BECAUSE THE COMPUTER BOARD MELTS AND LEAKS A GREASY LIKE SUBSTANCE. MY BROTHER IN-LAW HAS EXPERIENCE WITH COMPUTERS AND SAID IT RESEMBLED MELTED HEAT COATING FROM THE COMPUTER BOARD. WE HAD SUCCESS WITH A REMANUFACTURED PCM. THIS PART SHOULD BE RECALLED AND CORRECTED. THERE IS A LIST OF PEOPLE ON THE DODGE FORUM WHO HAVE SUFFERED WITH THE SAME ISSUES AND I'M SURE SOMEONE OUT HERE HAS WRECKED OR DIED OVER THIS. *TR

I WAS PARKED IN A SPACE. I STARTED THE VEHICLE AND PUSHED THE BRAKE PEDAL TO TAKE THE VEHICLE OUT IF PARK. I FELT THE PEDAL GO TO THE FLOOR AND HEARD A NOISE UNDER THE VEHICLE. I PUT THE VEHICLE BACK IN PARK AN GOT OUT TO SEE WHAT THE NOISE WAS AND SAW FLUID DRIPPING FROM MY GAS TANK. AFTER FURTHER INSPECTION I REALIZED THE BRAKE LINE NEXT TO THE FUEL TANK HAD BURST DUE TO RUST AND CORROSION. THE ENTIRE BRAKE LINE FROM THE FRONT OF THE VEHICLE TO THE REAR NEEDED TO BE REPLACED. THE WORST DAMAGE WAS THE SECTION TUCKED BEHIND THE FUEL TANK WHERE IT WAS MORE DIFFICULT TO GET CLEANED DURING NORMAL WASHING. *TR

16 YEAR OLD SON WAS DRIVING MY TRUCK TO A SCHOOL FUNCTION, STEPPED ON THE BRAKES TO MAKE THE TURN OFF THE HIGHWAY INTO THE SCHOOL AND BRAKE PEDAL WENT TO THE FLOOR. I WENT TO GET THE VEHICLE AND THE BRAKE LINE THAT RUNS ALONG THE FRAME RAIL TO THE REAR AXLE HAD CORRODED THROUGH IN SEVERAL PLACES CAUSING HIM TO LOSE BRAKE FLUID. I'VE HAD A LOT OF CARS MUCH OLDER THAN THIS TRUCK (MY FAMILY HAD A CAR DEALERSHIP) AND THIS IS THE FIRST TIME I'VE EVER SEEN A HARD BRAKE LINE GO BAD. LOOKING ONLINE FOR A REPLACEMENT PART IT QUICKLY BECAME APPARENT THAT THIS IS A VERY COMMON PROBLEM WITH THE DODGE DAKOTAS AND THEY ALL CORRODE IN THE SAME PLACE. BEHIND THE FUEL TANK. DEFINITELY A SAFETY ISSUE THAT CHRYSLER SHOULD CORRECT. *TR

BRAKE LINE TO THE LEFT REAR TIRE RUSTED OUT AND LEAKED. LOST ALL BRAKE FUNCTIONS. LOCATION OF THE LEAK WAS NEXT TO THE GAS TANK. REPETITIVE PROBLEM WITH OTHER DODGE TRUCKS. LUCKY I WAS GOING DOWN THE HIGHWAY OR NEEDED A SUDDEN STOP. *JS

TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. THE CONTACT STATED THAT WHILE MAKING A LEFT TURN, THE THROTTLE BECAME STUCK AND CAUSED HIM TO LOSE CONTROL OF THE VEHICLE AND ROLL OVER. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 96,000.

I WAS TURNING LEFT ON TO WAX RD AT A RED LIGHT GOING UP HILL WHEN IT WAS RAINING THE TRUCK RIGHT REAR TIRE BROKE TRACTION PUT ME IN A FISHTAIL LOST CONTROL OF THE VEHICLE AND FLIPPED THE TRUCK ON ITS TOP DAMAGED THE DRIVER SIDE BENT THE FRAME CAVED IN THE ROOF BUSTED MY WINDSHIELD I WAS PULLED OUT BY AN PEDESTRIAN BUT THE AIRBAG DID NOT DEPLOY NONE OF THE SAFETY FEATURES DID NOT WORK BUT THE SEAT BELT ONLY. WHERE THE THROTTLE WAS STICKING THAT GAVE THE IMPRESSION THAT I WAS PLAYING CARELESSLY. *TR