2005 DODGE DURANGO Complaints

WHEN FILLING THE GAS TANK (AT ANY STATION) THE CHECK VALVE ENGAGES TOO EARLY CAUSING FUEL TO SHOOT OUT OF THE FILLER TUBE. SUPPOSEDLY THIS WAS FIXED BUT EITHER A FAULTY ONE WAS INSTALLED OR THE WORK WAS NEVER DONE (PREVIOUS OWNER). VEHICLE WAS ALSO SUPPOSEDLY NOT COVERED UNDER RECALL BASED ON THE VIN BUT MATCHED THE MANUFACTURE DATE BUT NOT SERIAL NUMBER. NO ONE HAS AN ANSWER WHY IT IS STILL DOING THIS?

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. WHILE ATTEMPTING TO START THE VEHICLE, THE IGNITION FAILED WITHOUT WARNING. THE FAILURE WAS PERSISTENT. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TIPM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REPLACED SEVERAL PARTS TO REPAIR THE FAILURE PRIOR TO THE CURRENT DIAGNOSTIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* TAKATA RECALL. THE CONTACT OWNS A 2005 DODGE DURANGO. THE CONTACT RECEIVED A RECALL NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V313000 (AIR BAGS) AND STATED THAT THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

THE VEHICLE TRIES TO SHIFT INTO 4 WHEEL DRIVE ON ITS OWN WHILE TRAVELING DOWN THE ROAD. DEPENDING ON SPEED IT IS SOMETIMES SUCCESSFUL CAUSING DIFFICULT STEERING ON DRY PAVEMENT. IT ALSO SOMETIMES SOUNDS LIKE IT IS TRYING TO SHIFT INTO 4 WHEEL DRIVE WHEN THE VEHICLE IS PARKED AND NOT RUNNING; ESPECIALLY RIGHT AFTER UNLOCKING THE DOORS WITH THE KEY FOB.

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. WHILE REFUELING THE VEHICLE, FUEL SPEWED OUT OF THE FILLER NECK WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP MODULE SEAL FRACTURED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000.

UPON FILLING UP THE TANK THE FUEL WILL SPRAY OUT ALL OVER THE PLACE. I TOOK IT TO THE DEALER AND THEY STATED THERE WAS A RECALL FOR THIS ISSUE BUT IT HAD ALREADY BEEN DONE AND EVEN THOUGH IT FAILED AGAIN IT IS MY PROBLEM. I SEE 2006 AND ON HAVE A UNLIMITED TIME AND MILEAGE WARRANTY FOR THIS ISSUE. NUMBER: 14-001-12 GROUP: FUEL SYSTEM DATE: JANUARY 20, 2012 SUBJECT: FUEL SPIT BACK DURING REFUELING DUE TO FAULTY INLET CHECK VALVE X39 (UNLIMITED TIME AND MILEAGE WARRANTY EXTENSION) OVERVIEW: THIS BULLETIN INVOLVES REPLACING THE FUEL FILLER TUBE IF THE CONDITION OCCURS. MODELS: 2006 - 2008 (HB) DURANGO 2007 - 2008 (HG) ASPEN NOTE: THIS EXTENDED WARRANTY BULLETIN APPLIES TO VEHICLES EQUIPPED WITH A NATURALLY ASPIRATED GASOLINE ENGINES. SYMPTOM/CONDITION: SOME CUSTOMERS MAY EXPERIENCE A FUEL SPIT BACK CONDITION DURING A REFUELING EVENT. DIAGNOSIS: IF THE CUSTOMER EXPERIENCES THE SYMPTOM/CONDITION, PROCEED TO THE REPAIR PROCEDURE. PARTS REQUIRED: QTY. PART NO. DESCRIPTION AR (1) CNNZX390AA TUBE, FUEL FILLER (4) 6500911 RIVET, SPLASH SHIELD ATTACHING

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. THE CONTACT STATED THAT THE TRANSFER CASE SHIFTER WOULD SHIFT AUTOMATICALLY WITHOUT WARNING . THE FOUR WHEEL DRIVE WARNING LIGHT ILLUMINATED WHENEVER THE TRANSFER CASE SHIFTER WOULD SHIFT INDEPENDENTLY. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC, WHO ATTEMPTED SEVERAL REPAIRS. HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 153,661.

WHEN FUELING, THERE IS NO SHUTOFF SO FUEL GOES EVERYWHERE. DEALERSHIP SAYS PROBLEM WAS FIXED BUT IT IS NOT FIXED. IT HAS BEEN DOING THIS SINCE I PURCHASED THE VEHICLE. IT IS VERY UNSAFE AND CAUSES A WET SLIPPERY SURFACE AT GAS PUMP, ALONG WITH GAS LEAKAGE DOWN THE SIDE OF VEHICLE, WHICH HAS CREATED RUST NOW.

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING AT ANY SPEED, THE VEHICLE SEIZED INTO FOUR WHEEL DRIVE AS THE SERVICE FOUR WHEEL DRIVE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECURRED SEVERAL TIMES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 202,000.

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. THE CONTACT STATED THAT WHILE ACCELERATING FROM A STOP LIGHT, THE SERVICE FOUR WHEEL DRIVE WARNING LIGHT ILLUMINATED AS THE VEHICLE INDEPENDENTLY SHIFTED INTO FOUR WHEEL DRIVE. IN ADDITION, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO MOVE FORWARD. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 158,000.