2002 DODGE DURANGO Complaints

I PURCHASED A NEW DURANGO 2 YEARS AGO, AND AT PRESENT THE SUV HAS SLIGHTLY OVER 14,000 MILES. THE DEALER HAS INFORMED ME THAT THE ROTORS MUST BE TURNED AND NEW BRAKE PADS INSTALLED. THIS TYPE OF WORK AT 14,000 MILES (7,000 MILES PER YEAR) IS UNACCEPTABLE. AT THIS RATE 30,000 MILES WILL REQUIRE NEW PADS AND ROTORS. APPARANTLY, THE BRAKES/ROTORS ARE UNDERSIZED FOR THE SIZE AND WEIGHT OF THE VEHICLE OR THE PADS AND/OR ROTORS ARE DEFECTIVE, BOTH SAFETY ISSUES IN MY OPINION. *AK

CONSUMER COMPLAINED ABOUT A BALL JOINT PROBLEM. CONSUMER TOOK THE VEHICLE TO AN INDEPENDENT TIRE SHOP TO GET THE TIRES BALANCED AND ALIGNED AND IT WAS DETERMINED THAT BALL JOINTS WERE DEFECTIVE. *AK THE VEHICLE COULD NOT BE ALIGNED DUE TO THE BALL JOINTS. THE DODGE DEALER DENIED THAT THERE WAS A PROBLEM WITH THE BALL JOINTS. FINALLY THE DEALER FOUND PLAY ON ONE SIDE AND WANTED TO REPLACE BOTH UPPER BALL JOINTS. (THE DEALER REP STATED THAT THEY WERE TRAINED TO CHECK THEM A CERTAIN WAY AND THEY WOULD NOT HAVE FOUND PLAY THE WAY THAT THEY WERE CHECKING THEM) THE TRANSMISSION WOULD INTERMITTENTLY NOT UPSHIFT, HOWEVER THE DEALER WAS UNABLE TO DUPLICATE. *SC *JB

CHRYSLER USED INFERIOR STEEL IN THE FRONT BRAKE ROTORS ON 2002 DODGE DURANGOS CAUSING PREMATURE FAILURE AND A SERIOUS SAFETY HAZARD. I HAVE THE BRAKE ROTORS FOR PROOF. THE STEEL FLAKES OFF LEAVING LARGE PITS AND CAUSES SEVERE BRAKING PROBLEMS. *MR

NO OBVIOUS SYMPTOMS, JUST GETTING AN INSPECTION TO RENEW LICENSE. MECHANIC SAYS IT FAILED DUE TO BAD UPPER RIGHT BALL JOINT. HE SHOWED ME THE WHEEL AND IT WOULD MOVE SIDEWAYS A FULL 1" BACK AND FORTH! THIS JOINT IS READY TO FAIL COMPLETELY AND I HAVE HAD NO WARNING, NO NOISE, NO LOOSE FEELING IN THE STEERING, NOTHING. ONLY 46,000 MILES ON VEHICLE, DIDN'T EXPECT A PROBLEM LIKE THAT. THANK GOD THAT MISSOURI REQUIRES AN INSPECTION EVERY OTHER YEAR! I WILL REQUEST THE MECHANIC SAVE THE PART WHEN REPLACED.*AK

WINDSHIELD WIPERS MALFUNCTIONED, RESULTING IN POOR VISIBILITY. DEALER INDICATED THAT WINDSHIELD WIPERS WERE NOT RECALLED. *AK

ON OR ABOUT NOVEMBER 14, 2002, RAYMOND NOTTNAGEL WAS SEVERELY BURNED BY A SEAT HEATER IN THE DRIVER'S SEAT OF A 2002 DODGE DURANGO 4X4 R/T, VIN: 1B4-HS78Z72F-139578. MR. NOTTNAGEL IS A PARAPLEGIC. HE DID NOT INITIALLY FEEL THE BURN OCCURING. THE 3RD DEGREE BURN REQUIRED MR. NOTTNAGEL TO SPEND THE BETTER PART OF 5 MONTHS ON HIS STOMACH, AND THEN HE GRADUALLY RETURNED TO BEING ABLE TO SIT FOR LIMITED PERIODS OF TIME WITH THE CORRECT PADDING. THE SEAT HEATER APPARENTLY DID NOT TURN OFF AFTER REACHING A NORMAL TEMPERATURE AND REACHED A SUFFICIENT TEMPERATURE TO CAUSE A 3RD DEGREE BURN. THE CASE IS NOW IN LITIGATION IN SACRAMENTO SUPERIOR COURT. *AK

I HAVE A 2002 DODGE DURANGO WITH 4WD AND IT HAS 37,000 MILES ON IT. I HAVE TO CHANGE BOTH FRONT WHEEL BRAKE ROTORS. WHEN I TOOK THE BRAKE PADS OUT, I FOUND THAT ON BOTH WHEELS THE INSIDE BRAKE PAD HAS BEEN COMPLETELY WORN OUT AND PITTED INTO THE ROTOR WHILE BOTH OUTSIDE BRAKE PADS HAS ONLY LESS THAN 1/3 WEAR OUT OF THE MATERIAL. IT LOOKS LIKE THE DISK BRAKE SYSTEM IN THE FRONT WHEEL HAS SOME KIND OF DESIGN FLAW. I AM A VERY GOOD MECHANICAL ENGINEER, I THINK THE CLIP LOCATED ON THE OUTSIDE OF THE DISK BRAKE PREVENTED THE OUTSIDE PAD FROM EFFECTIVELY ENGAGING WITH THE ROTOR WHEN THE BRAKE WAS APPLIED.*AK

I HAVE A 2002 DODGE DURANGO THAT IS EXPERIENCING EVERY PROBLEM THAT IS KNOWN WITH DODGE BALL JOINTS AND BRAKES. APR-2004 I HAVE BEEN EXPERIENCING WHILE DRIVING, THE STEERING WHEEL FREEZING WHILE TURNING LEFT AND THE STEERING LOCKS AT 20-25MPH. I TOOK THE TRUCK TO GREENFIELD DODGE AND INFORMED THEM OF THE PROBLEMS, ALSO THE PROBLEMS WITH THE FRONT BRAKES. THEY NOTED THAT THEY "TEST DROVE THE VEHICLE FOUND THE LOWER BALL JOINTS TO HAVE EXCESSIVE PLAY (.075). THE SERVICE GROUP INFORMED ME THAT THIS INCIDENT WAS NOT COVERED UNDER MY WARRANTY. AFTER SEVERAL HOURS THEY FINALLY DECIDED TO REPLACE THE PART. THEY INFORMED ME THAT THE CAR WOULD BE READY AT 7:00PM THAT EVENING THE CAR WOULD BE READY. AFTER WAITING SEVERAL HOURS I MADE ARRANGEMENTS TO GET TO THE SERVICE SHOP, WHERE THEY TOLD ME THAT THEY NEVER BROUGHT THE CAR IN BECAUSE "OTHER THINGS CAME UP". I HAD NO WAY TO GET HOME SO I HAD TO RENT A CAR FROM THE DEALER SHIP. THE NEXT DAY I PICKED UP THE CAR AND HAD TO PAY $30 FOR THE RENTAL AND $108 FOR MY DEDUCTIBLE. REGARDING THE BRAKES. I DECIDED TO HAVE THE BRAKES FIXED AT MIDAS BECAUSE I WAS NOT HAPPY WITH THE SERVICE AT DODGE. THE MECHANIC AT MIDAS REMOVED THE PADS AND THE CALIBER AND INFORMED ME THAT THE PINS THAT GO INTO THE CALIBER WERE STRIPPED. HE STATED THAT THIS IS A COMMON THING THAT THEY HAVE SEEN WITH THE DODGE TRUCKS. THEY HAD TO TAP AND INSTALL A HELI-COIL. I PICKED UP THE CAR AND HAD TO PAY $30 FOR THE RENTAL AND $108 FOR MY DEDUCTIBLE. THE ENTIRE FEE FOR THE BRAKE SERVICE WITH THE ADDITIONAL PARTS THAT INCLUDED A HELI-COIL KIT AND SERVICE CAME TO $292.13. THE TWO DAY EXPERIENCE LEFT A VERY BAD TASTE IN MY MOUTH AND WALLET.*AK

ON APRIL 20 MY WIFE TOOK OUR 2002 DODGE DURANGO TO THE DEALERSIP TO HAVE A PA INSPECTION PERFORMED. THE INSPECTION IN 2003 WAS ROUTINE AND SHOWED NO SIGNS OF ABNORMAL WEAR. SINCE THE LAST INSPECTION MY DROVE THE DURANGO 10,010 MILES. THE VEHICLE IS GARAGED EACH NIGHT AT OUR HOME. THE INSPECTION MECHANIC AT THE DEALERSHIP FAILED OUR DURANGO DUE TO THE LEFT FRONT BRAKE ROTOR BEING SEVERLY RUSTED. EVEN THE RETAINING CLIPS THAT HOLD THE BRAKE PADS IN PLACE ARE RUSTED OFF AFTER ONLY 10,010 MILES FROM LAST YEAR. HOW CAN A BRAKE ROTOR BECOME RUSTED WHEN IT IS BEING DRIVEN EACH DAY BY MY WIFE. HER WORK IS EIGHT MILES FROM OUR HOME, ONE WAY. I SUSPECT THE ROTOR IS MADE FROM DEFECTIVE STEEL. WE HAVE ALL THE SERVICE RECORDS AS THE DEALERSHIP SERVICES THE DURANGO WHEN NEEDED. TOTAL MILEAGE ON THE VEHICLE IS 22,458 OVER 2 YEARS. WE ARE PAYING TO HAVE THE WORK COMPLETED BUT FEEL THE ROTORS ARE DEFECTIVE AS ARE THE BRAKE PADS. I MYSELF INSPECTED THE ROTOR AND FOUND THE AXEL TO BE RUSTING ALONG WITH THE SPINDLE ARM ATTACHED TO POSSIBLY DEFECTIVE BALL JOINTS.. COMMON FOLKS SUCH AS MYSELF AND MY WIFE DEPEND ON YOUR AGENCY TO REPRESENT US. HAD WE KNOW OF THE POOR QUALITY OF THE DURANGO WE NEVER WOULD HAVE SPENT OUR MONEY ON IT. I HAVE CONTACTED DODGE CUSTOMER SERVICE AND THEY HAVE BEEN OF NO HELP. I HAVE INSTRUCTED THE MECHANIC AT THE DEALERSHIP TO GIVE ME BACK ALL THE PARTS BEING REPLACED SO I WILL HAVE THEM FOR EVIDENCE. I ALSO HAVE THE SUPPORTING PAPERWORK. UNSAFE VEHICLES SHOULD NOT BE ALLOWED ON THE HIGHWAYS WHERE PEOPLE CAN GET KILLED. AT 60 MILES PER HOUR IF YOUR ROTOR BREAKS OR THE BALL JOINT POPS OUT SOMEONE WILL BE DEAD. THANK YOU IN ADVANCE FOR YOUR HELP.*AK

WHILE DRIVING AT ANY SPEED CONSUMER HEARD A SQUEAKING NOISE COMING FROM THE FRONT OF THE VEHICLE. CONSUMER DROVE THE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT BOTH UPPER BALL JOINTS NEEDED TO BE REPLACED. *AK