2005 DODGE DURANGO Complaints

WHILE OPERATING THE VEHICLE THE SERVICE 4WD LIGHT CAME ON. AT SOME POINT AFTER THAT THE TRANSFER CASE SHIFTED INTO 4HI LOCK.I SCANNED THE OBDII AND HAD NO CODES PRESENT. ALSO SCANNED THE 4WD SELECTOR SWITCH AND IT SHOWED THE SWITCH WAS OPERATIONAL, BUT THE TRANSFER CASE SHIFT MOTOR WAS NOT SHIFTING. DROPPED THE VEHICLE OFF AT AN INDEPENDENT TRANSMISSION SHOP ONE WEEK LATER AND IT SAT FOR A FEW HOURS AND WHEN THEY WENT TO ROAD TEST IT NO WARNING LIGHTS AND IT WAS NOW IN AWD. AGAIN THE REPAIR SHOP DID AN OBD SCAN AND CAME UP WITH NO CODES.IF THESE VEHICLES WERE TO SHIFT INTO FOUR WHEEL DRIVE (LOW OR HIGH RANGE ) AT HIGHWAY SPEEDS OF 65 MPH I FEEL MAJOR DRIVELINE DAMAGE AND OR FAILURE WILL RESULT,WHICH COULD LEAD TO SERIOUS INJURY OR DEATH. *TR

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE FOUR WHEEL DRIVE SYSTEM ENGAGED INDEPENDENTLY AND CAUSED THE STEERING WHEEL TO BECOME DIFFICULT TO TURN. THE CONTACT RESTARTED THE VEHICLE AND IT FUNCTIONED PROPERLY UNTIL THE FOLLOWING DAY. THE CONTACT WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 112,000.

EVERY TIME IT RAINS THE CAR RIDES ROUGH. IT'S SCARY. WE OWN 2 OF THESE AND FOUND OUT THAT THIS ISN'T BEING ADDRESSED BY DODGE. TOTALLY DISAPPOINTED IN LACK OF CONSIDERATION BY THE DODGE CORP. *JB

2005 DODGE DURANGO 5.7 HEMI STALLS UPON ACCELERATION. DURING ACCELERATION IN THE FORWARD DIRECTION THE VEHICLE WILL LOSE ALL ELECTRICAL FUNCTION AND SHUT DOWN THE ENGINE CAUSING THE MOTORIST TO BE STRANDED IN THE MIDDLE OF AN INTERSECTION OR OTHER DANGEROUS SECTION OF ROADWAY. LOSS OF ELECTRICAL FUNCTION CAN BE ATTRIBUTED TO THE CLOSE PROXIMITY OF THE POSITIVE BATTERY CABLE TO THE EGR PIPE ON THE RIGHT SIDE OF THE ENGINE. DURING ACCELERATION THE ENGINE WILL TORQUE OVER CAUSING THE EGR PIPE TO MAKE CONTACT WITH THE BATTERY CABLE THUS CAUSING THE PLASTIC SHEATHING TO BECOME CHAFED. OVER TIME THIS CHAFING WILL WEAR THROUGH THE PLASTIC SHEATHING AND EXPOSE THE BARE COPPER WIRE ALLOWING IT TO COME IN CONTACT WITH THE METAL EGR PIPE. THE CONTACT OF THE COPPER WIRE FROM THE POSITIVE BATTERY CABLE TO THE METAL EGR PIPE CREATES A DIRECT SHORT WHICH IN TURN SHUTS DOWN THE ELECTRICAL SYSTEM AND ANY ENGINE CONTROL FUNCTIONS. IN SOME INSTANCES THIS SHORT CAN CAUSE THE BATTERY CABLE TO HEAT UP ENOUGH TO CATCH THE PLASTIC INSULATION ON FIRE AND POSSIBLY LEAD TO BATTERY EXPLOSION.

I WAS DRIVING HOME FROM SHOPPING WITH MY HUSBAND AND WHEN I TURNED THE REAR END, IT JERKED AND ALMOST MADE ME WRECK. I HAD TO PULL OVER AT TIM HORTON'S AND THE VEHICLE FINALLY CORRECTED ITSELF AND EVERYTHING WAS OKAY. IT HAPPENED AGAIN LAST NIGHT, AS I WAS LEAVING FROM GOODWILL AND AS I WAS TURNING OUT OF MY PARKING SPOT IT DID IT AGAIN, BUT THIS TIME WORSE IF SOMEONE WAS IN FRONT OF ME I WOULD HAVE HIT THEM WITHOUT MY CONTROL. AS I WAS TURNING ONTO MY NARROW BRIDGE LAST NIGHT IT DID IT AGAIN AND I ALMOST WRECKED INTO THE BRIDGE AND INTO MY CREEK, I THEN DECIDED THAT IT WAS DANGEROUS AND WASN'T GOING TO DRIVE THIS VEHICLE UNTIL IT GETS FIXED. *JB

I HAVE A TRANSMISSION PROBLEM THAT CAN'T BE DEFINED OR PIN-POINTED. IT HAS OCCURRED OVER THE LAST YEAR NUMEROUS TIMES. NO ONE CAN SEEM TO FIX. THE TRANSMISSION DROPS OUT INTO NEUTRAL AT HIGH SPEEDS OR DROPS INTO 4WD LOW AT MODERATE SPEEDS, LATELY THE TRANSFER CASE WILL MAKE NOISE WHEN I UNLOCK THE TRUCK AND WHEN I GO TO START IT THE TRANSMISSION GRINDS AND DROPS INTO 4WD LOW!!! IF IT WASN'T FOR MY AWARENESS OF THE SOUNDS OF THE TRUCK AND READY TO MAKE A SAFE MANEUVER, THERE COULD HAVE BEEN A SERIOUS CRASH. THIS IS A COMMON PROBLEM WITH THESE TRUCKS! LOOK ON THE INTERNET. IT HAPPENS RANDOMLY AND WITHOUT WARNING. NO MECHANIC CAN FIX IT YET! THEY SAY CHANGE THE TRANSFER CASE OUT $2000, BUT IT DOESN'T ALWAYS FIX IT... THIS IS A SEVERE HAZARD AND I WILL NOT LET ANYONE DRIVE MY TRUCK BUT ME.. I FOUND IF YOU SHUT DOWN THE CAR AND PUT IT IN NEUTRAL AND PUSH THE TOWING NEUTRAL BUTTON IT SOMETIMES KICKS IT BACK IN TO THE RIGHT SETTING. YOU WILL SEE IT SCROLL THROUGH 4WD LOW .. 4WD HIGH AND SERVICE 4WD ON THE DASH. THEN GO TO NORMAL.. THIS IS A VERY SERIOUS DEFECT!!! THE FEDS NEED TO GO AFTER DODGE TO FIND THE ISSUE AND ISSUE A RECALL!!!! I WILL SUE DODGE FOR EVERYTHING IF ANY ACCIDENT OCCURS FROM THIS. I SHOULD SUE THEM NOW JUST FOR MY EXPENSE, LOSS OF WORK TIME AND ANXIETY!!!! THEY NEED TO TAKE RESPONSIBILITY FOR THIS AND STOP "LOOKING THE OTHER WAY"! PLEASE SOMEONE AT THE FEDERAL LEVEL NEEDS TO TAKE THE LEAD AND FORCE DODGE TO DO WHAT'S RIGHT! *TR

WHEN FILLING THE TANK WITH GASOLINE, THE PUMP HANDLE WILL SHUT DOWN BUT GAS SPEWS FROM THE FILLER OPENING ON THE VEHICLE. THERE IS AN EXISTING RECALL FOR THIS PROBLEM ISSUED IN 2009; HOWEVER, MY PARTICULAR VIN IS NOT COVERED UNDER THAT RECALL EVEN THOUGH I AM HAVING THE EXACT SAME PROBLEM. PERHAPS A FIRE CAUSING INJURIES IS NECESSARY TO HAVE THIS PROBLEM COVERED BY CHRYSLER. *TR

WHEN VEHICLE IS OFF, SWITCHING NOISE FROM THE TRANSFER CASE SWITCHING MOTOR ON THE AWD DODGE DURANGO MOVING ON ITS OWN FROM AWD TO 4LOCK TO 4LO OCCURS. SRC 4WD LIGHT MAY COME ON BUT THEN CLEARS WHEN ENGINE IS TURNED OFF. THE SWITCHING IS NOT CONTROLLED BY THE NORMAL OPERATIONAL CONTROL THAT WOULD BE DONE BY DRIVE. I AM CONCERNED ABOUT SHORTING WIRING IN VEHICLE CAUSING A FIRE DUE TO SHORTING. WHEN UNLOCKING THE DOORS WITH THE KEY FLOB, THE SWITCHING ACTION MAY START WHICH SHOULD NOT BE RELATED TO THE CHANGING OF AWD, 4LOCK & 4LO. *TR

EVERY TIME I FILL UP THE VEHICLE WITH FUEL IT SPRAYS GASOLINE OUT ALL OVER THE SIDE OF THE VEHICLE AS WELL AS WHOEVER IS FUELING IT. SEVERAL LIKE MODEL DURANGOS FROM THIS YEAR AND CLOSE TO THE SAME YEAR HAVE HAD RECALLS TO FIX THIS ISSUE. IM NOT AT ALL SURE WHY MY VIN DOES NOT QUALIFY FOR THE RECALL BUT IT NEEDS TO BECAUSE THE PROBLEM IS OBVIOUS AND WAS DEFINITELY A MANUFACTURER ERROR. PLEASE CONSIDER THIS REQUEST AND TAKE CARE OF THE ISSUE. *TR

THE FIRST TIME IT HAPPENED, THE TRANSFER CASE WENT INTO NEUTRAL, ON IT'S OWN, WHILE DRIVING ON A DIVIDED HIGHWAY, WITH NO SHOULDER. IT KIND OF CREATED A TRAFFIC JAM. LONG STORY SHORT. A FRIEND TOWED ME HOME. I RESET THE TRANSFER CASE PER THE INSTRUCTION MANUAL, AND IT WENT BACK INTO GEAR. STILL DO NOT KNOW WHY IT WENT INTO NEUTRAL IN THE FIRST PLACE. NOW, WHEN YOU OPEN THE DOORS, THE TRANSFER CASE MOTOR OPERATES LIKE CRAZY, FOR UP TO 30 SECONDS, AND SOME TIMES LONGER. I GOT ON LINE AND HAVE FOUND OUT THAT IS A PROBLEM EXPERIENCED BY MANY DURANGO AWD OWNERS. I BOUGHT IT USED AND THE PREVIOUS OWNERS CLAIMED THAT IT NEVER DID IT BEFORE. ALSO, WHEN FILLING THE TANK UP, THE FILLER NECK WILL "PURGE" FUEL OUT ONTO THE GROUND AND YOUR FEET. THIS IS LISTED AS A DEALER RECALL, AND MINE WAS LOOKS TO HAVE BEEN DONE, BUT THE PROBLEM IS STILL THERE. *TR