2005 DODGE GRAND CARAVAN Complaints

THE ELECTRIC DOOR LOCKS COMPLETELY QUIT WORKING. WE TRIED THE PULLING OF THE FUSE AND UNHOOKING OF THE BATTERY AND THAT WORKED. NOW A FEW YEARS LATER HERE WE ARE AGAIN. THE ELECTRICAL LOCKS HAVE COMPLETELY QUIT AGAIN 09/2014. THIS VAN HAS HAD ONE ELECTRICAL PROBLEM AFTER ANOTHER. OUR ELECTRIC WINDOWS HAVE GONE OUT AT LEAST 3 TIMES AND BEEN REPLACED. WE HAVE FINALLY GIVEN UP REPLACING AND THE PASSENGER WINDOW WON'T GO DOWN. *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED AND THE HORN FAILED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE CLOCK SPRING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 226,000.

TOOK OWNERSHIP OF THE VEHICLE IN JANUARY 2014. NEARLY EVERY TIME THE GAS TANK HAS BEEN FILLED UP (TO FULL), THE VEHICLE WILL RUN OK FOR A BRIEF PERIOD OF TIME, IT WILL THEN BEGIN TO BUCK AND STALL. THIS HAPPENS AT NEARLY ANY ENGINE SPEED. ONCE THE VEHICLE STALLS IT IS DIFFICULT TO RESTART FOR ONE ATTEMPT. AFTER THE GAS TANK GETS JUST UNDER FULL THE OPERATION IS COMPLETELY NORMAL. THIS IS DANGEROUS AS USUALLY YOU ARE IN TRAFFIC. *TR

HAVE HAD NUMEROUS PROBLEMS WITH VAN STARTING 3 MONTHS AFTER PURCHASE. DASH LIGHTS FLASH BUT ONLY FOR SECONDS SO NO CODE CAN BE READ. ELECTRIC WINDOWS FAILING, BATTERIES REPLACED NUMEROUS TIMES. HAVE GOTTEN TO POINT I PURCHASE WINDOW TRACKS AND REPLACE MYSELF TO SAVE ON COST. MOST RECENTLY DASH LIGHTS AND HEADLIGHTS FLASHING RAPIDLY RADIO AND AIR GO OUT AND VEHICLE WANTING TO STALL. THIS IS A CONVERSION VAN BY BRAUN. HAD HANDICAPPED PERSON IN WHEELCHAIR IN PASSENGER SIDE FRONT. VAN STALLED IN INTERSECTION BUT WAS ABLE TO GET OFF TO SIDE OF ROAD. WHERE I WAS, I COULD NOT GET WHEELCHAIR OUT OF VAN. WE COULD HAVE BEEN KILLED NOT TO MENTION I LIVE IN FLORIDA AND HEAT WAS AT A FEEL LIKE TEMP OF 108. AFTER 10 OR 15 MINUTES VAN RESTARTED AND WAS ABLE TO LIMP HOME. AUTO ELECTRIC REPAIR SHOP REPLACED IGNITION WIRING HARNESS BUT AFTER 30 DAYS IT IS NOW DOING SAME AGAIN ONLY WORSE. I NOW HAVE NO TRANSPORT FOR HANDICAPPED PERSON BECAUSE WHY FIX SOMETHING THAT CANNOT BE RESOLVED WITHOUT CHANGING EVERY PART TO FIGURE OUT REAL PROBLEM. I KNOW EVEN IF THE BCM IS REPLACED THAT IS ONLY TEMPORARY ACCORDING TO OTHER REPORTS OF SAME PROBLEM I HAVE. *TR

VEHICLE STALLS OUT AFTER FILLING UP WITH GAS. IT WILL RUN ROUGH AFTER A FILL UP AND STALL OUT AT THE NEXT STOP YOU HAVE TO MAKE. *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT AFTER REFUELING AND DRIVING AT 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MENTIONED THAT THE VEHICLE STALLED AFTER REFUELING. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS NOT ABLE TO BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000. UPDATED 10/8/14*CN 10/24/14*CN UPDATED 02/03/15*JB

NEARLY EVERY TIME THE WE FILL THE TANK FULL OF FUEL THE ENGINE SHUTS DOWN AFTER LEAVING THE STATION. TYPICALLY IT WILL HAPPEN MID TURN WHILE PULLING OUT OF THE STATION OR ELSE WITHIN A BLOCK OF LEAVING. WHEN IT HAPPENS THE STEERING STOPS WORKING NORMALLY. WE HAVE TO SHIFT THE VEHICLE TO NEUTRAL AND RESTART IT AND THEN PUT IT BACK IN DRIVE AND GO. *TR

THE LEFT SIDE REAR SLIDING DOOR STOPPED WORKING IN JUNE 2013 BY ONLY OPENING ABOUT 3 INCHES AND STOPPING, THEN LATER STARTED NOT UNLOCKING AUTOMATICALLY. YOU THEN HAD TO EITHER PULL THE DOOR OPEN OR PULL IT SHUT. IN JULY OF 2014 THE RIGHT SIDE REAR SLIDING DOOR STOPPED WORKING AND UNLOCKING AUTOMATICALLY. WE ACTUALLY STARTED HAVING PROBLEM WITH IT SHORTLY AFTER WE BOUGHT IT IN APRIL 2005. IF YOU HAD IT OPEN, IT WOULD OCCASIONALLY NOT CLOSE AT ALL EVEN MANUALLY UNTIL YOU PULLED ON IT FOR A WHILE. WE TOOK IT TO THE DEALER MORE THAN ONCE AND THEY SAID NOTHING WAS WRONG WITH IT. NOW, BOTH HAVE TO BE MANUALLY UNLOCKED AND ON OCCASION THE RIGHT SIDE WILL OPEN AUTOMATICALLY AFTER YOU MANUALLY UNLOCK IT. NEITHER OF THE REAR SLIDING DOORS LOCK OR UNLOCK AUTOMATICALLY WITH THE BUTTON ON THE HEADLINER, THE AUTOMATIC BUTTON ON THE DOOR, OR WITH THE KEY. THE LEFT DOOR DOES NOT EVEN WANT TO OPEN MANUALLY FROM THE INSIDE. THIS GETS SCARY WHEN YOU HAVE A BABY SEAT ON THE OTHER SIDE AND OTHERS HAVE LEFT THE VEHICLE BEFORE YOU AND YOU HAVE NO ONE TO OPEN THE DOOR AND ARE UNABLE TO CLIMB OVER THE FRONT SEATS DUE TO HEALTH ISSUES. WHEN WE BOUGHT THE VAN WE WERE SHOWN AT THE DEALER HOW THE DOORS WOULD STOP IF THERE WAS A HAND, FOOT, OR SOMETHING IN THE DOORWAY TO AVOID INJURY, SO COULD THE MECHANICALS THAT WORK THIS BE AT FAULT?? WE NEVER WANTED TO TRY THIS TO SEE, BUT THIS IS ABOUT WHERE THE DOOR STOPS WORKING ON THE LEFT SIDE. I NOTICED THAT THERE ARE MANY, MANY COMPLAINTS ABOUT THESE DOORS NOT WORKING. I BELIEVE THIS TO BE A SAFETY ISSUE AND CANNOT UNDERSTAND WITH ALL THE COMPLAINTS WHY THIS ISSUE HAS NOT BEEN ADDRESSED BY CHRYSLER. TO BE HONEST WE HAVE HAD MULTIPLE ISSUES WITH THIS VAN SINCE WE BOUGHT IT AND SPOKE TO LOTS OF PEOPLE WITH THE SAME COMPLAINTS. WE FEEL THERE NEEDS TO BE A RECALL. *TR

AFTER MAKING A RIGHT HAND TURN, MY STEERING WHEEL LOCKED UP AND I COULD NOT RETURN TO CENTER. I WAS GOING SLOWLY, SO I WAS ABLE TO STOP THE CAR BEFORE IT WENT INTO THE DITCH. IF THIS HAD HAPPENED AT HIGHWAY SPEEDS OR WHERE MOST ROADS IN MISSOURI HAVE LIMITED SHOULDERS, I WOULD HAVE CRASHED INTO THE DITCH. I WAS ABLE TO WORK IT LOOSE AND THEN LIMP IT HOME VERY SLOWLY, ESP. AROUND CURVES OR CORNERS WHEN IT WOULD STICK AGAIN. UPON TAKING IT TO A MECHANIC, HE FOUND OUT THAT THE RACK AND PINION HAD TO BE REPLACED. IT PROCEEDED TO GO OUT 2 MORE TIMES SINCE THE FIRST INCIDENT. *TR

IN APRIL OF 2013, THE AIR BAG WARNING LIGHT ILLUMINATED ON THE DASHBOARD. TOOK IT TO THE DEALER TO CHECK. FOUND THAT THE RIGHT SENSOR WAS NOT WORKING PROPERLY AND THAT THERE WERE "BROKEN WIRES." REPAIRED THE WIRING AND SAID THAT ALL WAS OKAY. I WAS CHARGED OVER $220 FOR THIS REPAIR. THERE WAS A 2007 RECALL FOR THIS ISSUE AND MY CAR SUPPOSEDLY HAD THE FRONT SENSORS REPLACED AT THAT TIME. THEN, IN JUNE OF 2014, THE SAME AIR BAG WARNING LIGHT APPEARED AGAIN. THIS TIME I RESEARCHED RECALLS AND FOUND OUT THAT THERE WAS ANOTHER RECALL IN 2010 FOR THIS SAME ISSUE. AFTER CONTACTING CHRYSLER SERVICES, I WAS TOLD TO GO BACK TO THE DEALER AND THEY WOULD PERFORM THE REPAIR/REPLACEMENT AT NO COST. AFTER THEY PERFORMED THE WORK, WHICH THEY SAID AGAIN WAS A BROKEN WIRE, I WAS CHARGED ANOTHER $200. THEY STATED THAT IT HAD NOTHING TO DO WITH SENSOR, JUST THE WIRING, AND THEREFORE WAS NOT COVERED BY THE RECALL. JUST WAITING TO SEE WHEN IT WILL HAPPEN AGAIN. *TR