1999 DODGE GRAND CARAVAN Complaints

AIRBAG WARNING LIGHT ILLUMINATED (REMAINS ON). BOTH CRUISE CONTROL AND HORN ARE INOPERATIVE. RESEARCH HAS REVEALED THAT THIS IS AN IDENTICAL PROBLEM RELATED TO THE 96-98 RECALL FOR THIS VERY PROBLEM. SUGGEST THAT PROBLEM IS NOT LIMITED TO THOSE YEARS. VEHICLE MILEAGE 133000.*AK

AFTER STARTING THE VEHICLEAIR BAG WARNING LIGHT ILLUMINATED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

HEADLIGHTS HAVE BECOME CLOUDY AND LIGHT TRANSMISSION HAS DIMINISHED GREATLY. LIGHT IS VERY DIM DUE TO THE CLOUDINESS. IF THIS CONTINUES WILL BE UNABLE TO DRIVE AT NIGHT. THIS WAS BROUGHT TO THE ATTENTION OF DODGE SERVICE MANAGER WHO SAID THERE WAS NOTHING HE COULD DO ABOUT IT. *JB

AIRBAG LIGHT CAME ON OUR 1999 DODGE GRAND CARAVAN. ALSO THE HORN AND CRUISE CONTROL WERE NOT WORKING. TOOK IT INTO THE DEALER TO HAVE IT REPAIRED AND FOUND OUT IT WAS THE CLOCK SPRING. IT WAS REPLACED AT A COST OF $232. SINCE THEN I HAVE FOUND OUT THAT THIS HAS BEEN AN ISSUE WITH THE CARAVAN MODEL FOR THE LAST COUPLE OF YEARS AND THAT THERE IS A RECALL ON THE CLOCK SPRING ON THE '96, '97, AND '98 MODEL YEARS. IS THIS RECALL GOING TO EXTEND TO THE '99 MODEL YEAR? *JB

AIR BAG LIGHT TURNS ON AND OFF WHILE DRIVING. USUALLY TURNS OFF AFTER STARTING ENGINE, BUT TURNS ON AND OFF PERIODICALLY. HORN STILL WORKS AT THIS TIME AND CRUISE CONTROL STILL WORKS...FOR HOW LONG? *JB

I HAVE A PROBLEM WITH MY 1999 GRAND CARAVAN, THE AIR BAG LIGHT IS ON AND THE HORN WILL NOT BLOW, AND THE CRUISE WON'T WORK. I GOT IN CONTACT WITH CHRYSLER AND THEY TOLD ME THEY DON'T KNOW OF A RECALL. IT IS DANGEROUS TO DRIVE A CAR WITH NO HORN, AND WHAT IF THE AIRBAG COMES OUT AND CAUSE AN ACCIDENT. *AK

THE CLOCK SPRING INSIDE OF THE STEERING WHEEL MALFUNCTIONED. AS A RESULT THE AIR BAG SENSOR LIGHT STAYED ON AND THE HORN BECAME INOPERATIVE. *AK THE CRUISE CONTROL WAS ALSO INOPERATIVE AND THERE WAS A CHANCE THAT THE AIR BAG WOULD NOT HAVE FUNCTIONED DURING A CRASH. *NM

CAR WAS REPORTED TO (CHRYSLER) TO HAVE RUST AT WELD SEAMS IN VARIOUS PLACES, BUT ONLY ON THE DRIVERS SIDE OF THE VAN. THE VEHICLE WAS AT THE END OR ONLY ONE WEEK OUT OF WARRANTY AND THE CHRYSLER SERVICE REP. WOULD NOT EVEN LOOK AT THE PROBLEM. IT IS AN OBVIOUS MANUFACTURING DEFECT FROM IMPROPER PAINT / WELD PREP AND COULD CAUSE A SERIOUS ACCIDENT (SHOCK TOWER RUST). THE SHOCK TOWER RUST IS ADMITTED IN A FACTORY SERVICE BULLETIN, BUT IS NOT A CURRENT RECALL (AS PER FORD'S RECENT RECALL) THAT COULD CAUSE THE STRUT TO PUNCH THROUGH THE SHOCK TOWER AND LODGE INTO THE ENGINE BAY, CAUSING AN ACCIDENT / VEHICLE FIRE. ADDITIONAL AREAS OF RUST EXIST AT THE BOTTOM OF THE DOOR SLIDER AT THE ROCKER AND AROUND THE REAR WHEEL LIP. VAN IS GARAGE KEPT AND WASHED REGULARLY, NEVER BEEN IN AN ACCIDENT AND DOES NOT OPERATE IN A CORROSIVE ENVIRONMENT. ABSOLUTE POOR WORKMANSHIP HAS LED TO THIS DEFECT.*AK

CONSUMER STATED THAT AIR BAG LIGHT CAME ON, AND TOOK VEHICLE TO THE DEALER. UPON EXAMINING THE VEHICLE MECHANIC FOUND THAT CLOCK SPRING WAS DEFECTIVE. LOOKED AT THE INTERNET, AND WAS TOLD THAT PART WAS ON ODI INVESTIGATION. *AK

FIRST AIR BAG LIGHT CAME ON, FOLLOWED BY SUBSEQUENT FAILURE OF HORN & CRUISE CONTROL. OUR DEALERSHIP MENTIONED THE CLOCKSPRING AND THE AIR BAG MODULE NEEDED REPLACEMENT. THANKS TO THE SUMARRIES ON THIS SITE, WE WILL NOT BE APPROVING THE MODULE REPLACMENT (AN ADDITIONAL COST OF ABOUT 650). LAST EIGHT VIN: XB527782. *AK