2017 DODGE GRAND CARAVAN Complaints

We purchased this car in 2019 at 55k miles. We had a transmission failed at 92k miles. My wife was left at a light and had to baby it home. It was replaced by a Mopar remanufactued unit that was supposed to be reinforced and have fixed parts from design flaws. A local dealership fixed it after several weeks and getting a loaned car. Next failure was 2 years later in 2023 at around 130k miles. This part was under Mopar 3 year 100k mile warranty and left my wife stranded on the road. The transmission was replaced by the local dealership this time cars were scarce and they didn't have a loaner. We had to get a rental and we're reimbursed. At 177k?miles it's happening again. I can't do this anymore. This transmission is defective and should be recalled. Timeline 92,000 miles – original transmission failed 130,000 miles – Mopar reman failed 180,000 miles – slipping, hard shifts, high RPM

I believe my door actuator on the driver’s side has failed as of 2/23/26 The door will not unlock. I cannot open or close it. The court case that was open has closed as of September 2025 and the recall is no longer active.

Seized sliding door latch. In an emergency we cannot exit threw the door. There was a recall on the door lock latch. Dealer will not repair do to the mileage.

I am writing to formally request that the National Highway Traffic Safety Administration review and consider an investigation into a potential safety-related defect affecting 2017 Dodge Grand Caravan vehicles. My vehicle recently experienced a failure of the engine oil filter housing, which cracked and leaked oil and required an expensive repair. According to the repair facility, Pro Auto Service, this failure is not isolated. I was advised that the shop has repaired a significant number of identical failures over the past year, to the extent that replacement parts have at times been difficult to obtain. The repair facility also indicated that many similar failures have occurred in recent weeks, coinciding with extreme cold weather conditions. The oil filter housing is a critical engine component responsible for maintaining proper oil circulation and pressure. Failure of this component can lead to oil loss, reduced lubrication, engine damage, or potential engine shutdown if not immediately addressed. Because this defect directly impacts engine operation, it presents a powertrain-related safety concern. Based on the frequency of reported failures, the consistency across the same model year, and the apparent correlation with cold weather conditions, this issue appears to be the result of a design or material defect rather than normal wear and tear. I respectfully request that NHTSA review this matter for possible investigation and recall consideration to protect vehicle owners from unexpected engine failure and costly repairs. Thank you for your attention to this concern and for your continued commitment to vehicle safety.

Both of my sliding passenger doors have become stuck closed due to failed lock actuators. (The doors do not open when placed in the "manual" option either. They cannot be opened in any way.) This happened a few years ago, but my vehicle was past the original warranty period for any repairs, and there were no recalls existing. Last spring (2025), I received notification of an extended warranty period to have this problem fixed. The issue is that my vehicle was not eligible because by that point it was over 100,000 miles. Doors not opening renders the vehicle unusable or unsafe for any passengers besides the front seat passenger. I bought my Dodge Grand Caravan to be a family car, and I can only have one child ride safely with me. In the event of a wreck, passengers would be trapped in the vehicle. I have submitted this concern before, and I have written to the warranty company associated with Dodge. Dodge recognizes this is a common safety problem with the vehicles, as evidenced by the extended warranty for this issue. However, this is not a warranty concern; it is a recall concern due to safety.

On December 29, 2025, my wife put her van in park, turned off the vehicle and proceeded to exit the vehicle. The drive is on an incline after exiting the vehicle it began to roll backwards. She was caught in the door and attempted to press the brake to no effect. She was drug about fifty feet before separating from the vehicle. The vehicle then rolled down a steep embankment and continued another hundred feet or so where it struck a building. Upon entering the vehicle, the gear shift was in the park position and the engine was turned off. The vehicle sustained over $5,000 in body damage from the impact to the building. And an unknown amount of damage to the steering and exhaust system from rolling down the embankment.

My engine has begun the "Pentastar tick", which is surprisingly well-known, but not recalled. This is a serious safety issue because it can cause engine failure, which would cause an accident. Dodge has known about this problem for years, but refuses to fix it. I cannot afford to replace the engine and my van is sitting at the dealership, as of today. Please make them fix this! Why is there not a recall on these engines!?! Thankfully, there was no accident and I had the vehicle towed to the dealership, only to be told they are aware of it and I'm looking at $3,000-5,000 to "fix" it. However, the replacement parts would be the same as the original parts, so it's just going to keep happening. They are willfully and knowingly endangering families by not fixing this!

Check engine light codes match possible recall for vehicle now I'm having the same issues

The Flex Plate comes loose and rattles really loud. Needs to get repaired so that it doesnt break loose and starter falls out. This is a well known issue with this type of vehicle and costs a couple thousand to get fixed. Dodge dealership said this happens a lot with their vans.

The lock actuators on my 2017 Dodge Grand Caravan sliding passenger doors are both frozen, so the doors are not able to be opened at all. The doors for the backseat are unusable, and passengers must climb in through the back hatch door of the van. My car began smoking from the engine (visible from the hood), and I had to pull my vehicle over. My children were unable to exit the vehicle in a swift manner, because they had to leave through the rear hatch of the vehicle instead of opening the doors next to their seats. This is extremely unsafe and seems to be a widespread safety risk with this vehicle. The company issued an extended warranty in 2025, but because my vehicle was purchased in 2018 and I commuted to my job, my vehicle is over the 100,000 mile qualifier now. It wasn't at 100,000 miles when the doors seized up. Dodge/Chrysler should recall this lock actuator part, because passenger safely should come first. An extended warranty that excludes drivers now over 100,000 miles is not acceptable. This defect could have caused my children to become trapped in a burning vehicle.