2007 DODGE GRAND CARAVAN Complaints

MY WIFE IS HANDICAPPED. I OWN A LOWERED FLOOR MINIVAN WITH A RAMP FOR WHEELCHAIR ACCESS. VANTAGE MOBILITY INTERNATIONAL ("VMI"), 5202 SOUTH 28TH PLACE, PHOENIX, AZ 85040, (602) 243-2700 DID THE CONVERSION OF MY 2007 DODGE GRAND CARAVAN TO MAKE IT HANDICAPPED ACCESSIBLE ("RAMP VAN"). DODGE/CHRYSLER ("DODGE") WORKS WITH VMI AND A DODGE DEALER IN TEMPE ARIZONA TO SELL RAMP VANS NATIONWIDE THROUGH A DEALER NETWORK. RAMP VANS ARE SOLD THROUGH LOCAL DEALERS WHO PROVIDE BOTH WARRANTY AND NON WARRANTY SERVICE FOR THE CONVERSION ELEMENTS OF THE RAMP VANS. LOCAL DODGE DEALERS PROVIDE NON-CONVERSION WARRANTY AND NON-WARRANTY SERVICE. IT IS NOT UNUSUAL FOR EACH TO POINT THE FINGER AT THE OTHER CONCERNING ELECTRICAL AND MECHANICAL PROBLEMS. THE DRIVER'S SIDE FRONT AIR BAG DOES NOT WORK PROPERLY. IT ONLY OPERATES INTERMITENTLY. IT HAS BEEN TAKEN TO BOTH VISION DODGE (920 PANORAMA TRAIL SOUTH, ROCHESTER, NY 14625, (585) 385-5700, AND AUTOCRAFTING 72 HINCHEY ROAD, ROCHESTER, NY 14624 ON SEVERAL OCCASIONS FOR REPAIRS TO THE AIRBAG SYSTEM. AUTOCRAFTING REPORTED THAT VMI WAS INVOLVED IN TROUBLESHOOTING THE PROBLEM. BETWEEN VISION DODGE AND AUTOCRAFTING THERE HAVE BEEN 3 OR 4 ATTEMPTS TO FIX THE AIRBAG PROBLEM TO NO AVAIL. VISION DODGE CHARGED ME SUBSTANTIAL COSTS FOR REPAIRS THAT DID NOT FIX THE PROBLEM. NEITHER DODGE NOR VMI HAS BEEN ABLE TO FIX THE PROBLEM. THE AIR BAG FAILURE AND THE INABILITY OF DODGE AND VMI TO FIX IT INDICATES A MAJOR DESIGN FAILURE IN AN ESSENTIAL AND LEGALLY REQUIRED SAFETY SYSTEM. THE AIRBAG SYSTEM GOES ON AND OFF WHILE BEING DRIVEN ON CITY STREETS AND HIGHWAYS AS REPORTED BY THE VEHICLE'S WARNING LIGHTS. WHOEVER IS DRIVING THE VEHICLE IS AT SERIOUS RISK OF DEATH OR INJURY SHOULD THE VAN BE INVOLVED IN AN ACCIDENT WITH THE AIRBAG NOT WORKING. OCCURRED 12/2015 AND FROM OCTOBER 2016 TO DATE.

WITHIN MINUTES OF FUELING, THE ENGINE WILL STALL CAUSING A LOSS OF STEERING AND BRAKES.

HEADLIGHTS AND DASH LIGHTS RANDOMLY SHUT OFF WHILE IV AM DRIVING DOWN THE HIGHWAY STRAIGHTAWAY IN THE DARK I MONKEY WITH HEADLIGHT SWITCH AND THE LIGHTS COME BACK ON. THIS HAS HAPPENED TO ME ABOUT 8 TIMES IN THE LAST YEAR. BUT RECENTLY IT HAS GOTTEN WORSE.

SEAT BELT LIGHT STAYS ON EVEN THOUGH THERE HAVE BEEN NO ACCIDENTS OR BAG DEPLOYMENTS.

CAR STALLS AFTER YOUR FILL THE GAS TANK THIS IS A KNOWN ISSUE WITH SEE CASE #66165038FL DOES SOMEONE HAVE TO DIE ? THIS IS A SAFETY CONCERN YOUR CAR COULD DIE IN TRAFFIC

THERE HAVE BEEN MANY MECHANICAL ISSUES (ELECTRICAL?) INCLUDING SLIDING DOORS THAT DO NOT WORK ANYMORE (THEY MUST BE CLOSED MANUALLY). BUT THE MAIN PROBLEM I WANT TO REPORT IS RUST. UNDER THE WHEELWELLS, UNDER THE SLIDING DOORS, ON THE BOTTOM OF THE TRUNK HATCH DOORS... IT'S RUSTING APART. FOR A 2007 VEHICLE THIS IS QUITE EXCESSIVE. I'VE ALSO NOTICED THAT OTHER DODGE GRAND CARAVANS OF THE SAME MARINE BLUE GREEN COLOR HAVE THE SAME EXACT PROBLEM. HAS THIS BEEN INVESTIGATED? RUSTING APART... AND IT'S BEEN HAPPENING FOR A COUPLE OF YEARS NOW. YOU WOULD THINK A VEHICLE WOULDN'T START TO HAVE NOTICEABLE AND PERVASIVE RUST IN 7 OR 8 YEARS TO THE POINT WHERE YOU ARE EMBARRASSED TO DRIVE IT.

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE DRIVER AND PASSENGER AIR BAG INDICATORS FLASHED ON AND OFF. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. ON SEVERAL OCCASIONS, THE VEHICLE STALLED AFTER BEING FILLED WITH FUEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE VAPOR LIQUID SEPARATOR VALVE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE RECURRED SIX TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. ....UPDATED 08/29/16 *BF UPDATED 08/31/16.*JB

STALLING AFTER REFUELING WHEN I FILL UP MY GAS TANK, ALMOST IMMEDIATELY AFTERWARD PULLING OUT OF THE GAS STATION MY VAN SPUTTERS, MISSES, HESITATES, CALL IT WHAT YOU WILL. THE PAST COUPLE OF TIMES THE ENGINE HAS ACTUALLY STALLED AS WELL.

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE DRIVING 25 MPH AND ATTEMPTING TO MAKE A TURN, THE POWER STEERING FAILED AND THE BATTERY AND TEMPERATURE GAUGE LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TIMING BELT FRACTURED AND THE TIMING CHAIN AND ENGINE COVER NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 153,000.