1999 DODGE GRAND CARAVAN Complaints

A WORN BUSHING/BEARING IN THE TENSIONER PULLEY ALLOWED THE DRIVE BELT TO SLIP OFF WHILE CORNERING. THE LOSS OF POWER STEERING ASSIST NEARLY CAUSED THE VEHICLE TO DRIVE OFF THE ROAD. THE VEHICLE THEN QUICKLY OVERHEATED LEAVING MY WIFE AND CHILDREN STRANDED ON A COUNTY ROAD IN A POTENTIALLY LIFE THREATENING SITUATION. THE ACTUAL TEMP WAS +5 F WITH A WIND CHILL OF -30 F. THEY WERE THANKFULLY RESCUED WITHIN ABOUT 20 MINUTES THANKS TO HER CELLPHONE. I UNDERSTAND CHRYSLER HAS ISSUED A TSB FOR BELTS THAT SLIP OFF WHEN DRIVING THROUGH SNOW OR WATER DUE TO PULLEY FAILURE. THIS IS AN EXTREMELY DANGEROUS SITUATION AND SHOULD BE SUBJECT TO A RECALL. THANK YOU. ROGER STITES. *AK

MY BRAKES HAVE BEEN SQUEAKING AND GRINDING SINCE ABOUT A MONTH AFTER WE BOUGHT THE CAR BRAND NEW. I HAVE HAD THE VAN INTO THE DEALERSHIP NUMEROUS TIMES WITH COMPLAINTS ABOUT IT AND ONLY ONCE, AFTER MY BRAKE WARRANTY EXPIRED DID THEY FEEL THE NEED TO INFORM ME THAT THE FRONT BRAKES WERE SHOT AND THE MASTER CYLINDER FOR THE BACK BRAKES WAS DEFECTIVE DUE TO A LEAK. IT HAS NOW BEEN ABUT TWO MONTHS SINCE THE NEW BRAKES WERE PUT ON AND WE HAD THE VAN IN AGAIN FOR THE SAME PROBLEMS. THIS TIME THE DEALERSHIP TOLD US THERE WAS A LARGE BUILDUP OF METALLIC RESIDUE WHICH WAS CAUSING THE PROBLEM. THEY REPLACED THE FRONT BRAKE PADS AGAIN AT NO CHARGE BUT NOEW, A WEEK TO THE DAY LATER, MY BRAKES ARE STARTING TO SQUEAK AGAIN. MY WARRANTY ON THIS VAN IN GENERAL IS ALMOST UP. I WANT TO MAKE SURE THAT THIS PROBLEM AS WELL AS THE OTHER MINOR ONES I HAVE WITH THE VAN ARE CORRECTED ONCE AND FOR ALL.*AK

EXCESSIVE WEAR AND TEAR ON THE PADS AT 13,000 MILES. THE SERVICE DEPT FAILED TO INSPECT WHEELS AND BRAKES. THEN AT 28,000 MILES A TOTAL BRAKE FAILURE OCCURRED. ADDITIONALLY, A STRUT IS DEFECTIVE.*AK

TIRE TREAD SEPARATION. *AK (TIRESIZE: P215/65R15)( DOT NUMBER: TIRE SIZE: P215/65R15 )

CONSUMER WAS DRIVING AT 60-65MPH ON FREEWAY AND SWITCHING LANES WHEN TRANSMISSION SLIPPED , RPM'S WENT OVER 3000, TRANSMISSION WAS STUCK IN 1ST GEAR. DEALER TOLD CONSUMER THAT SENSOR NEEDED TO BE REPLACED. *AK

WHILE TRAVELING WITH WINDSHIELD WIPERS RUNNING, PASSENGER'S SIDE WINDSHIELD WIPER STOPPED WORKING, CAUSING DRIVER'S SIDE TO RUN ALONE. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. *AK

DESIGN DEFECT AS PER CERTIFIED TRANSMISSION REPAIR SHOP: VERTICAL PIN BREAKS OFF WHICH CAUSES A SLIPPAGE FOR THE MAIN ROTATING MECHANISM CAUSING IT TO PUNCTURE THE TRANSMISSION. *AK

ORIGINAL SET OF TIRES WORN OUT 20,824 2ND SET AT 44,800 POSSIBLE MANUFACTURE DEFECT **WHEEL SIZE CANNOT BE CHANGED NO OTHER TIRE MANUFACTURED TO FIT**PUBLIC NEEDS WARNED-CONSUMER NEEDS ADVICE. *AK (TIRESIZE: P225-60-17)( DOT NUMBER: TIRE SIZE: P225-60-17 )

ORIGINAL SET OF TIRES WORN OUT 20,824 2ND SET AT 44,800 POSSIBLE MANUFACTURE DEFECT. *AK (TIRESIZE: P225-60-17)( DOT NUMBER: TIRE SIZE: P225-60-17 )

PROBLEM STARTED GRADUALLY. IGNITION JAMMED AND KEY WOULDN'T TURN, BUT WITH CONSTANTLY JIMMYING BACK AND FORTH WOULD EVENTUALLY TURN. PROBLEM PERSISTED UNTIL KEY WOULD NO LONGER TURN IN IGNITION. VAN HAD TO BE TOWED TO THE DEALER. THEY STATED THEY REPLACED THE CYCLINDER LOCK AND LUBED THE INSIDE. THE IGNITION STARTED GRADUALLY CATCHING AGAIN UNTIL IT LOCKED UP. VAN WAS TOWED AGAIN TO THE DEALER. DEALER STATED ORIGINAL REPLACEMENT PART FAILED, SO THEY ORDERED ANOTHER ONE AND INSTALLED IT. LAST WEEK THE PROBLEM STARTED AGAIN. IGNITION JAMMED BUT STARTED AFTER I JIMMYED THE KEY BACK AND FORTH. I HAVE NOT CONTACTED THE DEALER YET ABOUT THE THIR INCIDENT. ALSO, MY NEIGHBOR HAS A 1999 PLYMOUTH VOYAGER MINIVAN, AND HAS HAD THE SAME EXACT PROBLEM, TWICE. *AK