2005 DODGE GRAND CARAVAN Complaints

AIRBAG LIGHT JUST CAME ON.FLASHES INTERMITTINGLY ,SOMETIMES WHEN BRAKING, SOMETIMES WHEN ACCELERATING.FROM MY RESEARCH,IT SEEMS LIKE THE CLOCK SPRING IS DEFECTIVE.MY MILEAGE IS 150,000 MILES. WEATHER HAS BEEN VERY RAINY IN SOUTHERN CALIF. RECENTLY(AFTER YEARS OF DROUGHT-LIKE WEATHER).READING OF OTHER VANS HAVING PROBLEM ON EAST COAST.

HAVE FUEL SMELL AT BACK MIDDLE OF VAN, FOUND FUEL LEAKING AT MIDDLE OF FUEL TANK, REPLACED FUEL LINE CONNECTED TO FUEL PUMP OUTPUT CONNECTOR. DID NOT STOP FUEL LEAK, FOUND CRACKED FUEL PUMP AT THE OUTPUT AREA. LEAKS AS LONG AS THE HIGH PRESSURE SIDE OF FUEL PUMP IS PRESSURIZED.

NOTICED GASOLINE SMELL EVERY TIME I STOP/PARK CAR & GET OUT. AFTER FEW WEEKS, CHECKED UNDERNEATH VAN & SAW GAS SLOWLY DRIPPING FROM ABOUT MIDDLE OF GAS TANK. IT WAS RUNNING DOWN THE SIDE FROMN THE TOP OF TANK. STOPPED DRIPPIONG AFTER STOPPED FOR FEW MINUTES, BUT FOUND OUT THAT WHILE VAN WAS RUNNING IT DRIPPED CONSTANTLY. GOOGLED THIS PROBLEM & OTHER ARE HAVING SAME PROBLEM WITH CRACKS IN FUEL PUMP. THIS COULD BE A SERIOUS PROBLEM WITH A SPARK/HOT EXHAUST PIPE/MUFFLER CLOSE BY.

THE HEAD LIGHTS GO OUT WHILE DRIVING. NO WARNING SIGNS, YOU LOSE ALL HEADLIGHTS. IF THE SWITCH IS TURNED ON AND OFF SEVERAL TIMES THEY WILL COME BACK ON. MY LIGHTS WENT OFF WHILE I WAS DRIVING DOWN A COUNTY HIGHWAY GOING 55 MPH. THERE WERE NO STREET LIGHTS. IT HAPPENED A TOTAL OF 4 TIMES ON MY 40 MINUTE DRIVE HOME THROUGH THE COUNTRY. VERY SCARY!

2205 DODGE GRAND CARAVAN STALLS AFTER REFUELING. MULTIPLE OCCURENCES. HAPPENS IN MOTION STRAIGHT LINE, WHILE ACCELERATING.

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. AFTER REFUELING THE VEHICLE, THE ENGINE STARTED AND STALLED. THE OIL WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.

SMELLED RAW GASOLINE SMELL OUTSIDE OF VEHICLE AFTER RUNNING VEHICLE. OCCURRED ON TWO OCCASIONS ON AUG 23, 2016. LOOKED UNDER VEHICLE ON 8/30/16 AND SAW AND FELT LIQUID FUEL ON FUEL TANK IN VICINITY WHERE FUEL PUMP GOES INTO GAS TANK. LEAK OCCURS WHEN IGNITION IS IN THE ON (RUNNING) POSITION. DID ONLINE RESEARCH AND FOUND THAT OTHERS HAVE HAD SAME PROBLEM WITH FATIGUE CRACKS IN PLASTIC TOP OF FUEL PUMP, WHERE FUEL HOSE ATTACHES. WHEN KEY TURNED ON AND FUEL PUMP IS PRESSURIZED, FUEL BEGINS TO LEAK THROUGH THE HAIRLINE CRACK. DANGEROUS, AS MUFFLER AND EXHAUST PIPE ARE LOCATED LESS THAN ONE FOOT FROM THE SOURCE OF THE LEAK!! TOOK VEHICLE TO REPAIR FACILITY, WHO DETERMINED FUEL PUMP MODULE WAS LEAKING AS DESCRIBED ABOVE. COST OVER $500 TO HAVE NEW PUMP INSTALLED, EVEN THOUGH THE OLD FUEL PUMP WAS STILL WORKING, THOUGH LEAKING.

EVERY TIME I FILL UP THE VEHICLE WITH GAS, IT STALLS EVERY TIME WITHIN THE FIRST FEW MINUTES, LAST WEEK DAUGHTER WAS MERGING INTO TRAFFIC WHEN IT HAPPENED AND ALMOST GOT REAR-ENDED. THIS HAS BEEN HAPPENING FOR A WHILE NOW. LAST WINTER I WASN'T ABLE TO FILL THE VEHICLE, THE PUMP KEPT SHUTTING DOWN BUT THAT WENT AWAY AFTER THE WEATHER WARMED UP.

THERE IS A DOCUMENTED DEFECT IN THE FRONT AIRBAG SENSORS THAT RESULTED IN A CHRYSLER "SAFETY IMPROVEMENT" CAMPAIGN LIMITED TO MAINLY NORTHERN STATES. MY CAR HAS THIS PROBLEM BUT HAS BEEN IN FLORIDA FOR ITS WHOLE LIFE. CLEARLY THEY RECOGNIZE THAT THERE IS A DEFECT IN THIS PART BUT WILL NOT ISSUE A RECALL FOR FLORIDA-BASED CARS. CAN YOU MAKE THEM EXPAND THIS RECALL TO ALL 2005 DODGE CARAVANS SINCE IT IS A CLEAR DANGER THAT THEY ARE NOT FULLY RESPONDING TO.ATTACHED IS WHAT I FOUND ON THE INTERNET. CHRYSLER REFERRED ME TO A LOCAL DEALER WHO WILL CHARGE ME FOR THE REPAIR IF CHRYSLER DOESN'T PAY FOR IT AND THEY HAVE MADE NO COMMITMENT TO PAY IF THE DEFECT TURNS OUT TO BE WHAT THEY HAVE RECALLED OTHER VEHICLES OF THE SAME YEAR AND MODEL FOR. THE CHRYSLER CASE NUMBER IS 29905594 GIVEN THE SIGNIFICANT SAFETY RISK OF THIS DEFECTIVE PART CAN YOU EXPAND THIS FROM A SAFETY CAMPAIGN TO A FULL RECALL FOR ALL CARS OF THIS MODEL YEAR.

VAN STALLS AFTER FUELING. EVERY TIME YOU FILL UP THE VAN, THE VAN WILL STALL FOR NO REASON. IT WILL RESTART WITHIN A MINUTE OR 2. IT WILL THEN HAVE NO PROBLEMS UNTIL THE NEXT FILL UP. READING REPORTS ON THE WEB, THIS IS HAPPENING ON ALL DODGE AND CHRYSLER VEHICLES EVEN CAUSING SOME TO STALL ON TRAIN TRACKS. NEVER HAD A PROBLEM WITH THE VAN UNTIL I HIT AROUND 100K MILES. ALL OTHER REPORTS ON THE WEB ARE IDENTICAL. CHRYSLER DODGE SHOULD RECALL BEFORE SOMEONE DIES