1995 DODGE GRAND CARAVAN Complaints

DRIVER'S DOOR HINGE IS RIPPING OFF METAL OF FRAME, DOOR COULD POSSIBLY FALL OFF. DEALER SAID NEEDED TO EITHER SPOT WELD OR REPLACE FRAME. *AK UPON EXAMINING THE DOOR, IT WAS FOUND THAT THE DOOR HAD DROPPED SEVERAL INCHES AND WAS GADUALLY SEPARATING FROM THE BODY FRAME. THE SOLUTION WAS TO REPLACE THE FRAME WHICH COST THE CONSUMER SIGNIFICANT AMOUNT OF MONEY. THE MANUFACTURER CLAIMED IT OCCURED DUE TO AGE OF THE VEHICLE. *YH

DEFECTIVE TRANSMISSION - WHEN VEHICLE WAS IN "D" IT WOULD SLIP OPERATING IN A NETURAL POSITION WHEN DRIVING ESP WHEN STOPPED. SOMETIMES SHIFTING BACK IN TO "D" POSITION CAUSING VECHILCE TO SUDDEN MOVE FORWARD WITH LITTLE WARNING. OR IF VEHICLE WAS STOP ON AN INCLINE (HILL) THE VECHILCE WOULD ROLL BACK WHICH SOMETIMES CAME CLOSE TO HITTING THE VECHICLE BEHIND. FEELING IS THAT THE TRANMISSION IS FAULTY. COST OF REPAIR WAS $1708.25 TO REPAIR.*AK

AUOT TRANSMISSION WENT OUT AND REPLACED UNDER WARRANTY AT 49,700 MILES. TRANSMISSION HAS AGAIN GONE OUT AT 67,300 MILES. ALL SCHEDULED MAINTENANCE AND LUBRICATIONS WERE PERFORMED ON THE VEHICLE. *AK

FAILURE OF THE DOOR FRAME AT THE HINGE POINT FOR BOTH DRIVER AND PASSANGER SIDE FRONT DOORS CAUSING THEM TO SAG AND SCRAPE ON THE DOOR LOCK POST, PASSENGER SIDE DOOR ALSO RUBS ON THE FRONT FENDER. RIGHT SIDE DOOR REPAIRED AT LOCAL BODY SHOP 1 YEAR AGO BY WELDING EXTRA STRUCTURAL BACKING BEHIND THE DOOR HINGE MATING AREA AND THEN WELDING HING TO FRAME AND EXTRA BACKING (DOOR LOCKS HAD TO BE REPLACED DUE TO DOOR SAG INTERFERANCE). LEFT SIDE NOT REPAIRED TO DATE.

TENSIONER BROKE, AND CAR WAS DISABLED BECAUSE FAN BELT DOESN'T RUN. *AK BOLT/MOUNT HOLDING TENSIONER TO THE ENGINE BLOCK SHEARED OFF COMPLETELY DISABELING THE FAN BELT. *YH

BOLT THAT HELD TENSIONER PULLEY TO ENGINE BLOCK HAS SNAPPED OFF. HALF OF THE BOLT WAS STILL LEFT ON THE ENGINE BLOCK . THERE WAS NO EVIDENCE OF RUST. *AK

CONSUMERS DOOR IS CRACKING AT THE HINGE, IT'S BEGINNING TO DETERIORATE. DEALER SAID IT'S CHEAP METAL THAT'S BEING USED. *AK

INTERMITTENTLY TRANSMISSION WILL NOT SHIFT INTO GEAR OR HAVE A DELAY IN THE SHIFTING, AND WILL NOT GO INTO REVERSE. *AK LOCKS INTO LOW GEAR (LIMP MODE). *YH

THE DOORS WILL NOT SHUT DUE TO METAL FATIGUE. DEALER HAS INSPECTED VEHICLE, AND MANUFACTURER HAS BEEN NOTIFIED. *AK

PROBLEM OCCURS AFTER TWO OR MORE HOURS OF SUSTAINED FREEWAY DRIVING. CAR JERKS, SLOWS SLIGHTLY WITH ENGINE RACING AND LITTLE OR NO POWER AT GAS PEDAL. AFTER 2-3 SECONDS, ENGINE "SHIFTS BACK IN GEAR" STOPS RACING, AND POWER IS RESTORED TO GAS PEDAL. REPEATS THIS CYCLE SEVEN TO TEN TIMES IN SPACE OF TEN MINUTES. IF GAS PEDAL IS PRESSED TO FLOOR AND BURST OF FUEL SENT THROUGH SYSTEM, THE PROBLEM DOES NOT RECCUR FOR THE REMAINDER OF TRIP (UP TO SIX HOURS). ON THE NEXT LONG DRIVE, IT WILL HAPPEN AGAIN. I DO NOT WANT TO BE DRIVING WHEN THE TRANSMISSION GIVES OUT ENTIRELY (SEE ARTICLE CONSUMER REPORTS OCT '99, PP20-23). PLEASE HELP. *AK