2007 DODGE GRAND CARAVAN Complaints

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. IMMEDIATELY AFTER ADDING FUEL TO THE VEHICLE AND RESTARTING THE ENGINE, THE VEHICLE STALLED WITHOUT WARNING. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 90,000. UPDATED 8/21/15*CN THE CONSUMER STATED THE VEHICLE STALLS INTERMITTENTLY, NOT ON EVERY FILL UP. USUALLY, THE STALL WOULD OCCUR AFTER FILL UP AND A FEW MINUTES AFTER LEAVING THE PUMP. UPDATED 10/14/2015*JS

THE ENGINE STALLED TWICE WITHIN 5 MINUTES OF REFUELING. THE VEHICLE WAS FILLED WITH UNLEADED 87 OCTANE GAS TO FULL. THE GAS PUMP AUTO STOPPED WHEN FULL, AND THE TANK WAS NOT TOPPED OFF. THE FIRST STALL HAPPENED WHILE THE VEHICLE WAS IDLING AT A STOP SIGN APPROXIMATELY 1 MINUTE AFTER FUELING. THE ENGINE RESTARTED, BUT STALLED AGAIN APPROXIMATELY 2 MINUTES LATER. THE SECOND STALL OCCURRED WHILE THE VEHICLE WAS IN MOTION AT APPROXIMATELY 15-20 MPH AND TURNING LEFT. THE STALL LEFT THE VEHICLE WITHOUT POWER STEERING, AND THE VEHICLE COASTED INTO A DRIVEWAY. THERE WAS NO ACCIDENT BECAUSE OF LIGHT TRAFFIC. UNDER DIFFERENT CIRCUMSTANCES OR TRAFFIC PATTERNS, A STALLED ENGINE LEAVING A MOVING VEHICLE POWERLESS LIKELY WOULD CAUSE AN ACCIDENT RESULTING IN POSSIBLE INJURY OR DEATH. THIS SAME PROBLEM HAS OCCURRED APPROXIMATELY 5-6 TIMES IN THE LAST 2 YEARS, HOWEVER I CAN NOT BE SPECIFIC ON DATES. IT WAS ONLY WHEN MY WIFE AND I WERE TOGETHER THIS LAST TIME THAT WE BOTH COMMENTED ON THE PROBLEM, AND FOUND THAT IT HAS HAPPENED TO EACH OF US SEVERAL TIMES. I BELIEVE ANY MANUFACTURER DEFECT WHICH CAUSES A MOVING VEHICLE TO LOSE POWER AND BECOME UNCONTROLLABLE WHILE IN MOTION IS AN EXTREMELY SERIOUS AND POTENTIALLY DEADLY PROBLEM. *TR

THE VEHICLE STALLS AFTER RE-FUELING. WE RE-FUEL AT DIFFERENT GAS STATIONS (BRANDS) AND THE ISSUE REMAINS. EVERY TIME WE FILL THE TANK AND PULL OUT OF THE GAS STATION INTO TRAFFIC, THE ENGINE SPUTTERS AFTER DRIVING APPROXIMATELY TWO BLOCKS, AS IF IT IS NOT RECEIVING ENOUGH FUEL. THE ENGINE THEN STALLS. THE ENGINE CAN BE RESTARTED AND WILL NOT SPUTTER OR STALL UNTIL THE NEXT TIME WE RE-FUEL IT. WE ENCOUNTER THIS ISSUE WEEKLY, AFTER EVERY FILL UP. IT IS A POTENTIALLY DANGEROUS ISSUE BECAUSE THE VEHICLE STALLS IN TRAFFIC AND COULD CAUSE A TRAFFIC ACCIDENT. *TR

TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT AFTER REFUELING, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 30 MPH, THE VEHICLE STALLED. THE CONTACT STATED THAT THE FAILURE WAS PROGRESSING BUT THE VEHICLE WAS ABLE TO BE RESTARTED EACH TIME THE FAILURE RECURRED. THE VEHICLE WAS NOT INSPECTED OR DIAGNOSED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V139000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,433.

AFTER FILLING GAS TANK, ENGINE HESITATED AND KILLED. AFTER RESEARCHING, DETERMINED THIS IS A FUEL TANK VALVE ISSUE COMMON TO MINIVANS. NOT COVERED UNDER WARRANTY, OBVIOUS MANUFACTURE DEFECT. VALVE ALLOWS LIQUID GAS INTO VAPOR SYSTEM. ISSUE STILL EXISTS, TEMPORARY FIX IS TO NOT FILL TANK COMPLETELY WHEN REFUELING. EXPENSIVE REPAIR.

NUMEROUS TIMES RIGHT AFTER I FUEL UP, THE VAN SPUTTERS, SHAKES, AND THE ENGINE QUITS. EVEN IF I HOLD THE GAS PEDAL STEADY, IT JERKS AS IF I WAS PRESSING THE PEDAL QUICKLY THEN LETTING GO. WHEN I STOP AT A LIGHT, THE ENGINE DIES COMPLETELY. THIS HAPPENS ALMOST EVERY TIME I FUEL UP. IT HAS NEVER HAPPENED BEYOND 1 DAY AFTER I FUEL UP. IT DOES NOT MATTER WHICH GAS STATION I FILL UP AT, NOR THE QUALITY OF THE FUEL I BUY, THE PROBLEM STILL HAPPENS. ONE TIME THE ENGINE EVEN QUIT WHILE I WAS DRIVING! (USUALLY IT QUITS WHEN I STOP AT A LIGHT OR STOP SIGN.) IT TAKES 2-3 TRIES AND THEN THE ENGINE STARTS AGAIN AND THE VAN SHAKES, JERKS, AND SPUTTERS ONCE AGAIN AS IF IT IS NOT GETTING ENOUGH FUEL.

VEHICLE RUNS FINE UNTIL YOU REFUEL AND GET BACK ON THE ROAD THEN IT'S STARTS SPITTING AND SPUTTERING YOU HAVE TO COMPLETELY LET OFF THE GAS TO KEEP FROM STALLING IT OUT. ALSO IT DIES WHEN SITTING ON A HILL WITH LESS THAN A HALF A TANK OF GAS AND WON'T CRANK BACK UNTIL IT'S ON FLAT GROUND. *TR

AFTER REFUELING, VEHICLE STALLED WHEN ACCELERATING FROM STOP LIGHT. WAS ABLE TO IMMEDIATELY RESTART. THIS HAPPENS APPROXIMATELY 50% AFTER REFUELING AND SEEMS TO BE MORE COMMON/PRONOUNCED WHEN MAKING TURNS AT INTERSECTIONS SOON AFTER REFUELING. SEEMS TO BE LESS FREQUENT IF I REMAIN STOPPED, WITH ENGINE OFF, AT THE GAS STATION (E.G. GO INSIDE FOR PURCHASE). VERY AGGRAVATING AND CONCERNED FOR SAFETY IF STALL OCCURS IN HIGH TRAFFIC AREA. *TR

APPROXIMATELY THREE MONTHS AGO, MY 2007 DODGE GRAND CARAVAN STALLED AS I CAME TO A STOP SIGN IN A PARKING LOT. I WAS ABLE TO START RIGHT BACK UP AFTER PUTTING MY VAN IN PARK. BEING UNSURE WHY THIS HAPPENED, I DROVE AROUND THE PARKING LOT A FEW MINUTES BEFORE GETTING ON THE ROAD. IT STALLED ONE MORE TIME, BUT THEN I HAD NO OTHER PROBLEMS AND DROVE HOME. THIS OCCURRED IMMEDIATELY AFTER FILLING MY VAN WITH GAS, BUT I DID NOT ASSOCIATE THE PROBLEM WITH FUELING AT THE TIME. SINCE THAT INCIDENT, THIS HAS BECOME A RECURRING ISSUE OF THE ENGINE STALLING ONLY AFTER FILLING MY TANK. WHEN REFUELING NOW, I DRIVE AROUND NEAR THE GAS STATION TO INSURE THE VAN IS GOING TO RUN. AFTER GETTING GAS, WHEN I SLOW TO COME TO A STOP OR I HAVE STOPPED, THE CAR MAY STALL OUT. I HAVE BEEN ABLE TO RESTART MY VAN BY PUTTING IT IN PARK, STARTING AND PUMPING THE GAS PEDDLE FOR A FEW SECONDS BEFORE PROCEEDING. FORTUNATELY, WHEN MY VAN HAS STALLED, I HAVE NOT BEEN TRYING TO CROSS TRAFFIC OR TRAVELING AT A HIGH RATE OF SPEED; HOWEVER, THE POTENTIAL FOR SERIOUS INJURY DOES EXIST. BEFORE TAKING MY CAR TO A DEALERSHIP, I DECIDED TO LOOK ONLINE TO SEE IF ANYONE ELSE HAS ENCOUNTERED THE SAME ISSUE. MY SEARCH FOUND THIS TO BE A COMMON ENOUGH PROBLEM THAT A DEFECT PETITION DP14-002 WAS FILED IN SEPTEMBER 2014 WITH DOI. ACCORDING TO ONLINE RESOURCES, THE REMEDY IS TO REPLACE THE ENTIRE TANK. THE PROBLEM IS THE VAPOR/LIQUID SEPARATOR VALVE LOCATED AT THE TOP OF THE FUEL TANK AND THE VALVE IS NOT SOLD SEPARATELY. THIS APPEARS TO BE A DESIGN FLAW AND I WONDER WHY A RECALL HAS NOT BEEN ISSUED. *TR