2005 DODGE GRAND CARAVAN Complaints

MY 2005 DODGE GRAND CARAVAN DASH IS CRACKING. IT WILL BE A MATTER OF TIME THE FRONT WINDSHIELD DEFROSTER WILL START TO MALFUNCTION.

THE VEHICLE STALL IMMEDIATELY AFTER 1ST STARTUP FILL UP OF THE GAS TANK. THE STEERING LOCKS AND CAR ENGINE HESITATES AND DIES. AFTER WAITING COUPLE OF MINUTES, THE CAR WILL START UP AND NOT HAVE THE PROBLEM UNTIL NEXT REFILL OF THE GAS TANK. I NEVER OVERFILL THE GAS TANK. THE PROBLEM IS SIMILAR TO AN EXISTING RECALL ON 19 GALLON GAS TANKS ON DODGE CHARGERS.

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE ENTIRE DOOR LATCHING SYSTEM FAILED AND THE STEERING WHEEL EMITTED A LOUD WHINING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED THE DOOR LATCHES NEEDED TO BE REPROGRAMMED AND THE POWER STEERING FLUID NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 124,000. UPDATED 6/24/15*CN UPDATED 10/12/2017*CN

AFTER I FILL UP THE GAS TANK THE VAN STALLS WITHIN A COUPLE OF MINUTES. THIS HAS HAPPENED NUMEROUS TIMES AND HAS ALMOST CAUSED SEVERAL ACCIDENTS. *TR

VEHICLE STALLED OUT AT THE STOPLIGHT AFTER I HAD FILLED UP THE GAS TANK. I TOOK THE VAN INTO THE DODGE DEALERSHIP AND WAS TOLD THAT I NEEDED TO REPLACE THE WHOLE GAS TANK. *TR

POWER DOOR LOCKS WERE INOPERABLE EITHER BY THE KEY FOB OR THE INTERIOR DOOR LOCK SWITCHES. RETURNED VEHICLE TO DEALER ON 10/07/2014 FOR REPAIR. IN THAT I HAD EXTENDED COVERAGE I HAD TO PAY THE $100.00 CO-PAY. *TR

AFTER REFUELING VAN, STARTED VEHICLE AND PULLED AWAY FROM PUMP DRIVING ONTO THE ROAD APPLIED THROTTLE AND ENGINE DIED WITHOUT NOTICE JUST SHUT OFF. I AM A TECHNICIAN HAVE BEEN FOR A LONG TIME AND HAVE SEEN THIS PROBLEM ON MANY DIFFERENT MAKES AND MODELS THE ISSUE IS THE VENT VALVE ON MY DODGE GRAND CARAVAN ITS BUILT INTO THE FUEL TANK. UNLIKE MY DODGE OTHER BRANDS LIKE NISSAN HONDA ETC.. ACTUALLY TAKE CARE OF THEIR CUSTOMER. HAD TRAFFIC BEEN BUSY WE COULD HAVE BEEN SERIOUSLY INJURED IF NOT KILLED.I'VE READ SO MANY COMPLAINTS FOR THIS ISSUE ALL BLAMING VENT VALVE AND I AGREE. SOMETHING NEEDS TO BE DONE AND THE MANUFACTURER HELD LIABLE. DODGE ALREADY HAD THIS SAME ISSUE ON CHRYSLER 300 AND A FEW OTHER CARS AND THEY MADE A LIFETIME WARRANTY FOR THOSE FUEL TANKS ITS TIME THEY DO THE SAME FOR THE VANS. *TR

WHILE ATTEMPTING TO OPERATE THE ELECTRIC SLIDING SIDE DOOR, A LARGE SPARK AND SMALL DEBRIS FIRE WAS SEEN IN THE BOTTOM DOOR RAIL. UPON INSPECTION, A BREAK IN THE WIRE HARNESS HAD ALOUD WIRES TO BE SEVERED THAT CONTROLS THE DOOR AND LOCKING SYSTEM. THE AUTOMATIC DOOR LOCKS ON BOTH SIDE DOORS NO LONGER WORKED AND THE PASSENGER SIDE DOOR WOULD NO LONGER OPEN ELECTRICALLY. I REMOVED THE WIRING HARNESS AND WIRES AND DISCARDED THEM TO AVOID ANY MORE PROBLEMS (SPARKING AND/OR FIRES). THIS COULD CAUSE A MAJOR FIRE HAZARD IN THE RIGHT ENVIRONMENT. *TR

WHILE SLOWING DOWN MOTOR WILL TRY AND SHUT OFF. IF YOU COME TO A STOP IT WILL SHUT OFF. SEAT BELTS DO NOT LOCK IN PLACE. REAR WINDSHIELD WIPER WILL NOT MOVE. PASSENGER SIDE CARGO DOOR WILL NOT UNLOCK. SOME SETTINGS FOR HEAT AND AC WILL NOT WORK. LEFT TURN SIGNAL WON'T SHUT OFF AFTER TURNING. *TR

THE ENGINE STALLS WHILE DRIVING WITHIN FIVE OR SIX MINUTES AFTER FILLING THE GAS TANK. THIS HAS HAPPENED MULTIPLE TIMES. *TR