1998 DODGE GRAND CARAVAN Complaints

1) DEFECT DISCOVERED ON VEHICLE SAFETY INSPECTION 2) CORROSION ON DRIVERS SIDE STRUT TOWER 3) VEHICLE OPERATION IS UNSAFE, CORROSION COULD LEAD TO SEPARATION OF STRUT FROM STRUT TOWER CAUSING LOSS OF CONTROL, POTENTIAL COLLISION, VEHICLE DAMAGE AND INJURY TO OCCUPANTS. REPAIR TO STRUT TOWER IS REQUIRED. *TR

VEHICLE ONLY HAS PARK INTERMITTENTLY, MUST USE PARKING BRAKE TO INSURE VEHICLE DOES NOT MOVE. *TR

1998 DODGE GRAND CARAVAN - CORROSION IN DRIVER SIDE STRUT TOWER RESULTED IN A CRACKED STRUT TOWER AND INSECURE STRUT MOUNT. *JB

MY CAR FAILED ITS STATE INSPECTION DUE TO EXCESSIVE CORROSION ON THE STRUT TOWERS. WHEN INFORMED I ASKED THE SHOP IF THEY KNEW OF THIS PROBLEM. THEY REFERRED ME TO A TECHNICAL SERVICE BULLETIN TSB 23-044-02 ISSUED IN OCT OF 2002 WHICH AFFECTED MY MINIVAN WHICH I WAS NEVER INFORMED OF STATING THAT MINVANS BUILT BETWEEN 1996-2000 HAVE THIS PROBLEM AND NEED TO BE IMMEDIATELY CORRECTED. I WENT TO A CHRYSLER DEALER WHO INFORMED ME THAT THE REPAIR WOULD BE IN EXCESS OF 1300 DOLLARS AND THAT SINCE NO RECALL HAD EVER BEEN ISSUED THAT THEY WOULDN'T COVER THE REPAIR EVEN THOUGH THEY HAD ISSUED THE BULLETIN. IF THE REPAIR ISN'T MADE THE CAR WILL NOT BE ABLE TO PASS THE PA STATE INSPECTION AS THE INSPECTOR HAS DEEMED THE CAR UNSAFE TO DRIVE IN ITS CURRENT CONDITION. I HAVE LOOKED AT YOUR DATA BASE AND SEEN MULTIPLE EXAMPLES OF THIS COMPLAINT REGISTERED AS WELL AS ON MULTIPLE CAR BOARDS DISCUSSING THIS AND NHTSA'S REFUSAL TO ISSUE A RECALL. THIS IS A DANGEROUS SITUATION THAT COULD RESULT IN PHYSICAL INJURY AND IN MY CASE HAS LEAD TO AN UNSAFE CAR THAT CANT BE DRIVEN IN PA. I AM PART OF THE SAE CORROSION COUNCIL LOOKING INTO CORROSION PRACTICES IN THE HEAVY TRUCKING INDUSTRY AND I KNOW THAT IF THIS HAPPENED IN THE HEAVY TRUCKING INDUSTRY THERE WOULD BE AN IMMEDIATE SAFETY RECALL. WHY HASN'T THIS HAPPENED HERE WHEN THERE IS AN OBVIOUS PROBLEM THAT THE MANUFACTURER KNOWS ABOUT THAT AFFECTS HUNDREDS OF THOUSANDS OF VEHICLES? *TR *UPDATED 12/12/07 *BF UPDATED *JB

WHILE DRIVING IN HEAVY RAIN MY SERPENTINE BELT CAME OFF THE PULLEYS AND RESULTED IN A DANGEROUS SITUATION WHEN I LOST MY STEERING WHILE DRIVING IN TRAFFIC. I UNDERSTAND THAT THIS IS A COMMON AND DANGEROUS PROBLEM ON THE EARLIER (1997 THROUGH THE EARLY 2000S MODELS) DODGE CARAVAN 3.0, 3.3, AND 3.8 ENGINES. THERE ARE MANY POSTINGS ON THE INTERNET WITH PEOPLE HAVING THE SAME THING HAPPENING DURING RAIN STORMS. I AM THE ORIGINAL OWNER OF THIS 1998 DODGE CARAVAN. THE VAN ONLY HAS 61,686 MILES ON IT. AT 43,000 MILES I HAD TO REPLACE THE BELT, TENSIONER, AND PULLEY IDLER. I ALSO HAVE HEARD THAT DODGE DID A RECALL ON THIS PROBLEM IN AT LEAST ONE OTHER COUNTRY. CHRYSLER SHOULD BE MANDATED TO OFFER A FIX FOR THIS HERE IN THE USA. I TEMPORARILY FIXED MY PROBLEM BY PUTTING THE OLD SERPENTINE BELT BACK ON THE PULLEYS. THIS IS NOT AN EASY TASK AND TRYING TO DO IT ALONG THE ROAD IS HAZARDOUS. BUT FOR MOST PEOPLE THIS WOULD BE IMPOSSIBLE TO DO. *JB

SERPENTINE BELT CAME OFF FOUR TIMES WHILE DRIVING IN THE RAIN. AFTER THE FOURTH TIME THE GARAGE ORDERED A CONVERSION KIT FROM THE GATES CORPORATION THAT REPLACED THE IDLER PLUS THE TENSIONER. THE KIT ALSO INCLUDED A NEW DOUBLE SIDED RIBBED BELT. THEIR PART NUMBER IS 38,342 K. IT CAN ALSO BE ORDERED THROUGH CAR QUEST AUTO PARTS STORES. THEIR PART NUMBER IS THE SAME. I HAVE NOT HAD A PROBLEM SINCE. *TR

1. NORMAL DRIVING 2. RUSTING DRIVER SIDE STRUT TOWER 3. HAS NOT BEEN FIXED YET, BUT HAVE BEEN QUOTED $600 - $1000 *JB

TL*THE CONTACT OWNS A 1998 DODGE GRAND CARAVAN. THE VEHICLE HAS MICHELIN X RADIAL TIRES. WHILE DRIVING 45 MPH, THE CONTACT HEARD A NOISE COMING FROM THE REAR OF THE VEHICLE. SHE NOTICED THAT THE REAR PASSENGER SIDE TIRE WAS FLAT. THE TIRE SHOP STATED THAT THERE WAS A CRACK IN THE VALVE STEM AND THEY MADE THE REPAIR. APPROXIMATELY SIX MONTHS LATER, THE FAILURE RECURRED ON THE FRONT PASSENGER SIDE TIRE. THE TIRE SHOP STATED THAT THE VALVE STEM WAS CRACKED AND THEY MADE THE REPLACEMENT. THERE HAVE NOT BEEN ANY OTHER FAILURES SINCE THAT TIME. THE CURRENT MILEAGE IS 130,000 AND FAILURE MILEAGE WAS 129,000.

TL*THE CONTACT OWNS A 1998 DODGE GRAND CARAVAN. THE VEHICLE WAS INVOLVED IN A REAR END COLLISION AND CRASHED INTO THE VEHICLE IN FRONT OF HER AT 5 MPH. THE AIR BAG FAILED TO DEPLOY AND THE SEAT CAME OFF TRACK DURING THE CRASH. DUE TO THE SEAT POSITION, THE CONTACT COULD NOT DEPRESS THE BRAKE PEDAL OR CONTROL THE STEERING. THE CURRENT AND FAILURE MILEAGES WERE 124,000.

TL* - THE CONTACT OWNS A 1998 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE SERPENTINE BELT SLIPPED OFF IN WET WEATHER, AND IT MADE STEERING EXTREMELY DIFFICULT. WHEN THIS HAPPENED THERE WAS NO LONGER POWER STEERING. THIS HAS HAPPENED AT LEAST 4 TIMES. THE FAILURE MILEAGE WAS 70,000, AND THE CURRENT MILEAGE WAS 107,000. *AK CONSUMER STATES DEALER MADE ADDITIONAL INSTALLATION OF THE BELT 6 MONTHS PRIOR TO THE INCIDENT. UPDATE *4/23/07 **TR