2012 FIAT 500 Complaints

THE VEHICLE'S FUEL TANK IS NO LONGER ABLE TO ACCEPT FUEL PROPERLY FROM ANY GAS STATION DUE TO A DEFECT IN THE FUEL TANK'S ROLLOVER PROTECTION VALVE. AFTER A WEEKS WORTH OF TESTING THE DEALERSHIP ADVISED ME THAT THE CORRECT COURSE OF ACTION IS TO REPLACE THE WHOLE FUEL TANK AS THE PART IS INTEGRAL TO THE TANK. FIAT ADMITS THAT THERE IS A FAULT WITH THE TANK AND THEREFORE IT SHOULD BE A RECALL DUE TO FAULTY DESIGN RATHER THAN A CONSUMER BURDEN TO REPAIR AND REPLACE. I HAVE READ THAT THIS IS A COMMON ISSUE AMONGST THE 2012-2013 YEAR MODELS WITH MULTIPLE INCIDENTS OF OWNERS HAVING TO REPLACE THE FUEL TANK FOR THE PROBLEM TO ONLY RE-OCCUR AGAIN IN A SHORT PERIOD OF TIME. THE VEHICLE IS STATIONARY WHEN THIS HAPPENS WITH THE MOTOR SHUT OFF AND FUEL CAP OPEN TO ACCEPT FUEL. ESTIMATED COST OF REPAIR IS $2,000 WHICH IS ABOUT 1/3 OF VEHICLES COST DUE TO DEPRECIATION.

TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V302000 (POWER TRAIN); HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. TONY DOMIANO AUTO (LOCATED AT 900 SCRANTON CARBONDALE HWY, EYNON, PA 18403, (570) 876-3919) WAS CONTACTED AND CONFIRMED THAT THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS ALSO MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

FRONT SEAT MECHANISM WILL NOT OPERATE, OCCUPANTS CAN NOT GET OUT OF CAR ON DRIVER'S SIDE BECAUSE THE SEAT MECHANISM DOES NOT WORK AND THE BACK OF THE SEAT DOES NOT FLIP FORWARD

I CAR WARNING LIGHTS STARTED COMING ON AND STAYING ON ALL THE TIME. I TOOK THE CAR IN FOR AN OIL CHANGE AND WAS ADVISED I NEEDED A NEW MOTOR. THE CAR IS CONSTANTLY STALLING, CUTTING OFF ALL THE TIME, BEARLY RESTARTING AND ONLY ABLE TO DRIVE LESS THAN 25 MPH. THIS IS THE PROBLEM EVERY TIME I START IT UP.

TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT ATTEMPTED TO OPEN THE TRUNK, BUT IT WAS UNABLE TO UNLATCH AUTOMATICALLY. THE CONTACT STATED THAT THE TRUNK COULD BE ACCESSED BY PULLING THE BACK SEAT DOWN; HOWEVER, WITH THE BACK SEAT LOWERED, THE CONTACT WAS UNABLE TO LOAD OR UNLOAD A SUITCASE. THE VEHICLE WAS TAKEN TO FIAT OF EDMOND (14113 BROADWAY EXTENSION HIGHWAY, EDMOND, OKLAHOMA 73013, (405)-696-0631) WHERE IT WAS DIAGNOSED THAT THE WIRING HARNESS FAILED. THE DEALER STATED THAT THE TRUNK WIRES COULD NOT BE REPLACED INDIVIDUALLY; THEREFORE, THE WIRING HARNESS NEEDED TO BE REPLACED. THE WIRING HARNESS WAS NOT REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER PROVIDED THE CONTACT WITH CASE NUMBER: 34994853. THE APPROXIMATE FAILURE MILEAGE WAS 38,000.

TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WHEN ATTEMPTING TO DRIVE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TOWED TO RON LEWIS CHRYSLER DODGE JEEP RAM FIAT CRANBERRY (21145 US-19, CRANBERRY TWP, PA 16066, (724) 452-4040) WHERE IT WAS DIAGNOSED THAT THE STARTER MOUNTING BOLT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

TRUNK / HATCH PINCHED WIRE HARNESS CAUSING SHORT. COULD NOT OPEN TRUNK, LICENSE PLATE LIGHT WOULD NOT ILLUMINATE. FIAT DOES NOT MAKE A PIG TAIL REPLACEMENT, SHOP HAD TO RE-WIRE TRUNK COUSTING 180.00 FOR NEW DECK HANDEL, AND 600.00 FOR SPLICING IN NEW HARNESS

THE FIAT HAD THE RECOMMENDED RECALL FIX FOR MAUAL TRANSMISSION PERFORMED IN 2017. WHILE DRIVING ON A CITY STREET, THE CLUTCH WOULD NOT DISENGAGE PROPERLY. GEARS COULD ONLY BE CHANGED WITH THE CAR COMPLETELY STOPPED AND THE ENGINE OFF. REPAIR IDENTIFIED THE PROBLEM "PRESSURE PLATE FINGERS HAVE FAILED BECAUSE OF S34 RECALL. THIS RUINED THE CLUTCH PLATE CAUSING SHIFITNG ISSUES."

TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT STATED THAT THE REAR HATCH AND SUN ROOF FAILED TO OPEN. THE DEALER (HARPER FIAT, 10045 PARKSIDE DR, KNOXVILLE, TN 37922, (865) 243-3220) STATED THAT THEY WERE AWARE OF THE FAILURES, BUT NO REPAIRS WERE COMPLETED. THE MANUFACTURER STATED THAT THEY DID NOT HANDLE THOSE TYPES OF COMPLAINTS AND SUGGESTED THE CONTACT CALL NHTSA. THE VEHICLE WAS NOT DIAGNOSED. THE FAILURE MILEAGE WAS 98,000.

TL* THE CONTACT OWNS A 2012 FIAT 500. WHILE ATTEMPTING TO UNLOCK THE TRUNK, IT FAILED TO OPEN. THE VEHICLE WAS TAKEN TO FIAT OF BURLINGAME (2 CALIFORNIA DR, BURLINGAME, CA 94010, (866) 413-7332) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE TRUNK WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 61,927.