FLEETWOOD Complaints

ON 7/11/2011 AROUND 12:35 PM MY 1999 FLEETWOOD JAMBOREE 29L MOTORHOME ON A FORD E450 CHASSIS WAS BEING DRIVEN ON THE HIGHWAY FROM EAR FALLS ONTARIO CANADA TO VERMILLION BAY ONTARIO CANADA. THE MOTORHOME WAS BEING DRIVEN AT 50MPH ON A GOOD ROAD SURFACE. HEARD A LOUD POP LIKE A .22 CALIBER PISTOL SHOT AND THEN VIBRATIONS FROM THE PASSENGER REAR OF THE MOTOR HOME. SLOWED DOWN AND STOPPED AT A PULP CHECK AREA WITHIN A 100YDS OF THE EXPLOSION. FOUND THE INNER REAR PASSENGER SIDE TIRE HAD SEPARATED TREAD WHILE THE REST OF THE TIRE WAS STILL INTACT BUT FLAT. THE MILEAGE ON THE MOTORHOME IS 14,000 AND IS OTHERWISE IN GOOD CONDITION. THE TIRE WAS SHOWING ONLY MINOR TREAD WEAR AFTER ONLY 14,000 MILES. CHANGED THE SPARE AND PUMPED BOTH TIRES TO 90PSI. THE SPARE THAT WAS PUT IN IS A FIRESTONE STEELTEX RADIAL R4S LT225/75R16 LOAD RANGE E. AM ASSUMING THAT THIS IS THE SAME AS THE ONE THAT BLEW UP. *TR

2004 FLEETWOOD REVOLUTION VISIBILITY PROBLEM WITH ALL WINDOWS AND THE FRONT DOOR. ALL, AS WITH OTHER FLEETWOOD OWNERS HAVE FOGGED UP BETWEEN THE GLASS. THIS IS AN ABSOLUTE SAFETY PROBLEM AND OUR NEXT STEP IS TO FILE SUIT AGAINST FLEETWOOD. THE WINDOWS NEED TO BE REPLACED, FLEETWOOD KNOWS OF THE PROBLEM AND IS RESPONSIBLE. IF ANYONE CAN ASSIST PLEASE CALL. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE WINDOWS ON MY CLASS A MOTOR HOME ARE FOGGING TO THE POINT WHERE I AM NOT ABLE TO CLEARLY SEE MY OUTSIDE MIRROR ON THE DRIVERS SIDE. THE MOTOR HOME IS A 2006 FLEETWOOD DISCOVERY. FROM THE RESEARCH I HAVE DONE THIS APPEARS TO BE A BIG PROBLEM FOR FLEETWOOD. THEY ARE NOT WILLING TO REPLACE THESE WINDOWS AT THEIR COST. THIS IS A VERY SERIOUS SAFETY ISSUE. *TR

I PURCHASED A FLEETWOOD RV IN AUGUST 2009. IT CAME WITH A FULL 25 GAL PROPANE TANK. DUE TO THE LIMITED USE OF THIS TYPE OF VEHICLE, FILLING WAS NOT OFTEN. I WENT TO FILL THE TANK IN DECEMBER 2010 AND WAS UNABLE TO, DUE TO THE MOUNTING OF THE TANK BY THE MANUFACTURER. THE TANK IS SLIGHTLY TOO HIGH AND NO STANDARD APPROVED FILL NOZZLE WILL FIT THE TANK. THE ONLY WAS TO FILL IS TO MODIFY A FILL NOZZLE, WHICH I FEEL IS UNSAFE. I PROVIDED INFORMATION TO A DEALER ON HOW TO FIX THE PROBLEM, BY SIMPLY REMOVING THE TANK AND INSTALLING FOUR NUTS TO DROP THE TANK 1/4" AND THEN RE-INSTALL THE TANK. THEY ARE REFUSING REPAIRS, SINCE IT IS OUT OF WARRANTY. I BELIEVE THIS IS A MANUFACTURING INSTALLATION DEFECT AND CREATES AN UNSAFE CONDITION, REQUIRING A MODIFIED NOZZLE TO FILL. THAT CREATES THE POSSIBILITY OF A LEAK DURING FILL AND THE RESULTING EXPLOSION. EVEN THE REPAIR I RECOMMENDED, AFTER FURTHER THOUGHT, WOULD ALLOW FOR THE TANK TO LOOSEN AND FALL OUT WHILE DRIVING. THE RESULT WOULD BE AN EXPLOSION ON THE HIGHWAY. I UNDERSTAND THAT EACH RV IS SOMEWHAT UNIQUE, BUT I WOULD THINK THAT THIS TYPE OF INSTALLATION, A 25 GALLON PROPANE TANK, WOULD BE DONE TO AN APPROVED STANDARD DUE TO THE HAZARD IT PRESENTS. DUE TO THE HIGH NUMBER OF MANUFACTURING ISSUES WITH THIS UNIT, I AM PLANNING ON A FLORIDA LEMON LAW RETURN, BUT OTHERS MAY BE FACING THE SAME ISSUE AND ATTEMPTING TO RECTIFY THE PROBLEM BY ALTERING PROPANE FILL EQUIPMENT TO MEET THEIR NEED. THOSE ALTERATIONS COULD GENERATE A SERIOUS SAFETY HAZARD FOR THEM, THE FILL OPERATOR AND THE GENERAL PUBLIC SHOULD A LEAK AND THE RESULTANT EXPLOSION OCCUR. THESE RV'S CARRY 25 GALLONS OF PROPANE AND 75 GALLONS OF GASOLINE. AN EXPLOSION WOULD BE CATASTROPHIC. *TR

TL* THE CONTACT OWNS A 1997 FLEETWOOD DISCOVERY. THE CONTACT STATED THAT THERE WAS A BURNING ODOR COMING FROM THE FRONT END OF THE VEHICLE. HE THEN DISCOVERED THAT THE HEADLIGHT WIRES WERE MELTED. THE CONTACT REPAIRED THE FAILURE AND BOTH THE DEALER AND MANUFACTURER WERE NOTIFIED. THE FAILURE MILEAGE WAS 105,200 AND THE CURRENT MILEAGE WAS 105,663.

TL* THE CONTACT OWNS A 2005 FLEETWOOD ORBIT FIFTH WHEEL TRAILER WITH A DOMETIC REFRIGERATOR, MODEL NUMBER RM2652. THE CONTACT STATED THAT REFRIGERATOR WAS REPLACED TWICE WITHIN TWO YEARS DUE TO AMMONIA LEAKING FROM THE UNIT. THE MANUFACTURER WAS CONTACTED WHO REPLACED THE UNIT AT THEIR EXPENSE BUT THE FAILURE PERSISTED. THE CONTACT WAS CONCERNED WITH THE POSSIBILITY OF THE UNIT CATCHING FIRE. THE FAILURE AND CURRENT MILEAGES WERE UNAVAILABLE.

2004 FLEETWOOD AMERICAN TRADITION COACH. CONSUMER WRITES IN REGARDS TO RECALL ISSUES *TGW THE CONSUMER WAS INFORMED HIS REFRIGERATOR UNIT WAS NOT INCLUDED IN THE RECALL. (NORCOLD MODEL# 1200LRIM). *JB

AFTER NUMEROUS TIMES COMPLAINING, I WAS TOLD TO SPRAY THE JACKS WITH WD-40. I STILL HAVE TO DO THIS SEVERAL TIMES A TRIP. IF I FORGET TO, THE JACKS DON'T COME UP AND DRAG ON THE GROUND

A NORCOLD 1200 LRIM REFRIGERATOR INSTALLED AS ORIGINAL EQUIPMENT IN A 2003 FLEETWOOD BOUNDER 39L MOTORHOME MALFUNCTIONED, CAUGHT FIRE, AND DESTROYED THE RV, CAUSED SUBSTANTIAL DAMAGE TO THE OWNER'S HOME, AND SERIOUS PERSONAL INJURIES (BURNS) TO THE OWNER. AT THE TIME OF THE FIRE, THE RV WAS PARKED AND THE REFRIGERATOR WAS OPERATING ON SHORE POWER (AC CURRENT). *TR

DRIVER'S SIDE WINDOW FOGGED UP BECAUSE SEAL TO THERMAL PANE FAILED CAUSING REDUCED VISION TO LEFT SIDE MIRROR ON THE COACH. THIS CREATES A SAFETY HAZARD BECAUSE ONE IS UNABLE TO SEE TRAFFIC OUT LEFT MIRROR ESPECIALLY WHEN SUN IS SHINING JUST RIGHT THAT CREATES A GLARE IN THE MIRROR.