1997 FLEETWOOD DISCOVERY Complaints

TL* THE CONTACT OWNS A 1997 FLEETWOOD DISCOVERY. THE CONTACT STATED THAT THERE WAS A BURNING ODOR COMING FROM THE FRONT END OF THE VEHICLE. HE THEN DISCOVERED THAT THE HEADLIGHT WIRES WERE MELTED. THE CONTACT REPAIRED THE FAILURE AND BOTH THE DEALER AND MANUFACTURER WERE NOTIFIED. THE FAILURE MILEAGE WAS 105,200 AND THE CURRENT MILEAGE WAS 105,663.

DURING A RECENT TRIP THE MOTORHOME EXPERIENCED THREE BLOWOUTS, THE TIRES HAD 33000 MILES ON IT (MICHELIN SIZE 235/80R/22.5 XTRV TIRES).

ON THE DATE INDICATED, WHILE THE MOTORHOME WAS PLUGGED INTO 115V 30 AMP A/C POWER, WITH ONE ROOF AIR CONDITIONER OPERATING, AN ELECTRICAL FIRE OCCURRED IN THE JUNCTION BOX. THE FIRE, APPARENTLY CAUSED BY A SHORT CIRCUIT, CONSUMED A CONSIDERABLE AMOUNT OF WIRING INSULATION. FORTUNATELY, THE FIRE DID NOT SPREAD TO OTHER MATERIAL. DAMAGE REQUIRED REPLACEMENT OF THE POWERTEK BREAKER BOX AND REPAIR OF THE WIRING. THIS WAS THE SECOND TIME THAT THIS HAD OCCURRED IN THIS MOTORHOME. A VERY SIMILAR ELECTRICAL SHORT AND FIRE OCCURRED IN JULY 2000. DAMAGE WAS NOT AS EXTENSIVE AND ONLY THE WIRING NEEDED TO BE REPAIRED. THESE INCIDENTS ARE BEING REPORTED TO NHTSA AS A SAFETY HAZARD. OTHER OWNERS OF THE DISCOVERY MOTORHOME HAVE REPORTED SIMILAR INCIDENTS. FLEETWOOD HAS REFUSED TO PROVIDE ME WITH ANY FINANCIAL ASSISTANCE TO CORRECT THE DAMAGE RESULTING FROM THE MOST RECENT INCIDENT. TO THE BEST OF MY KNOWLEDGE, FLEETWOOD HAS NEVER ACKNOWLEDGED THE PROBLEM. NO RECALL HAS EVER BEEN ISSUED. THERE ARE NO SPECIAL PERIODIC MAINTENANCE PROCEDURES IN THE OWNER'S MANUAL NOR HAVE ANY BEEN SENT TO OWNERS. *AK

WHEN HEADLIGHTS WERE TURNED ON ELECTRICAL WIRING AND HEADLIGHT SWITCH STARTED MELTING, THERE WAS SMOKE UNDER DASH. CONSUMER COULD ONLY DRIVE DURING DAY TIME.*AK *JB

WHILE VEHICLE WAS PARKED IN CONSUMER'S DRIVEWAY IT CAUGHT ON FIRE, AND WAS COMPLETELY DESTROYED. AN ALLSTATE INSURANCE INSPECTOR STATED THAT CIRCUIT BOARD IN FRONT HEATING VENT WAS FAULTY AND FAILED. THIS RESULTED IN FAN COMING ON AND REMAINING ON .*AK *JB

INSURANCE INVESTAGATER SAID FIRE DUE TO FAULTY HEATER CIRCUT BOARD, THIS CAUSED FAN TO COME ON BLOWING FIRE THROUGH MOTORHOME, OTHER OWNERS OF THIS TYPE OF MOTORHOME SHOULD BE INFORMED TO THE POSIBLITY OF FIRES, IF WE WERE IN THE MOTORHOME WE COULD HAVE BEEN SERIOUSLY INJURED OR KILLED. FLEETWOOD SAID NO RESPONSEABILITY WOULD BE TAKEN ON THEIR PART, FLEETWOOD DID TAKE AN ACCIDENT REPORT.

WHILE OPERATING MOTORHOME AT HIGHWAY SPEED, ITS FUEL LINE RUPTURED, RESULTING IN DIESEL FUEL SEEPAGE THROUGHOUT MOTORHOME.*AK

MAGIC CHEF RANGE: TOP FORWARD VALVE STICKS IN ON POSITION AND CAN'T BE TURNED OFF. TURNED ALL THE PROPANE OFF, AND STILL IT WAS ON. CONTACTED DEALER, AND REPLACED THE FORWARD VALVE. HOWEVER, IT HAPPENED AGAIN. SERIAL# TO THE RANGE 10885756SH AND MODEL#85TB3BK. *AK *ML

THE LARGE BURNER CONTROL VALVE STARTED TO STICK IN THE ON POSITION DUE TO EXCESSIVE HEAT TO THE POINT THAT IT PARTIALLY MELTED THE PLASTIC KNOB, THIS IS POSSIBLY A DESIGN FLAW AND POTENTIALLY A SAFETY HAZARD. NLM

LEFT SIDE DRIVERS MIRROR IS MOUNTED SO DRIVER IS LOOKING YHROUGH THE SIDE TINTED WINDOW AND REFLECTS CURBSIDE TRAFFIC INTO THE LEFT SIDE MIRROR.