2016 FORD C-MAX Complaints

The backup camera doesn't regularly function, ranging from 15% to 75% of the time. A tire man with prior experience in a Ford dealership recommended checking for an electronics update to the system. There may be a worsening functionality when the weather is wet, but that's not a clear correlation.

Was driving it to a shop to do a transmission fluid exchange and got a big Stop Safely Now warning on the dash with an AdvanceTrac warning as well. Car stopped dead on a freeway off ramp - was very fortunate to get an immediate SoCal Freeway Service tow off the ramp in Los Angeles to a safe place, and after AAA told me I might wait 4 hours for a tow to my preferred Ford dealer, I got the car restarted and got it to a another dealer a couple miles away. Inspection showed a P0B37 error code with chafing of the high voltage battery harness. The dealer originally quoted me $1200 to fix it, but when I mentioned the California 10/150 hybrid powertrain warranty, they subsequently found TSB 17-0015 which deals with this exact issue on the 2013-16 Energi, and I've now read a report of the same issue on a 2017. The TSB quotes 1.8 hours labor with chafing and installation of heat shrink tubing, tie strap, and electrical tape... where the dealer came up with $1200 is beyond me. Obviously I'm pleased with the fact Ford is covering this one, but hope it doesn't happen to you... I had about 30 seconds to get the car to a safe place before it stopped entirely, and if I'd been in heavier traffic the vehicle would have stopped dead on a very busy expressway.

I have a 2016 Ford C-Max. On Saturday, 9-16-2023 my wife and I were traveling on Highway 69 in Prescott AZ. We turned off the highway and about 50 yards from Hwy 69 a STOP SAFELY NOW flashed on the instrument pannel. The car IMMEDIATELY braked hard and stopped. I had no time to pull over. Had it been 50 yards sooner I would have abruptly stopped on Hwy 69. The Hwy was traveling at 55 MPH. You figure it out, we were going to have an accident 100%. The C-Max was towed to Sun Valley Tire, a AAA approved repair shop in Prescott Valley. They pulled up the Ford, Technical Service Bulletin - TSB 17-0015. That bulletin describes wiring that chafes and shorts out the car. Exactly what happened to us. The actual fix is simple, locate the shorted out wire and repair it. To get to it requires disassembling most of the car. Total cost $438.01. That is not the point, Ford knew that this problem existed, sent out a TSB and is allowing Ford owners like me to have a life threatening incident. WHY has Ford been allowed to continue allow these C-Max's to stay on the road without a fix! Are you doing your jobs? I want the NHTSA to do its job. I also want to be reimbursed. Who do I contact. You have my VIN # and therefore all my information.

In the course of routine maintenance, it has been brought to my attention that Stock Ford lug nuts have "Swelled" and can not be removed using normal methods, making on the road tire replacement impossible. Ford states this is a known issue with defective Ford lug nuts.

blue images on the rearview camera when trying to reverse. No accidents have happened from the blue-screen problem

2016 FORD CMAX. CONSUMER WRITES IN REGARD TO FAILURE OF REAR WHEEL HUBS. THE CONSUMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME DETERMING A REMEDY FOR THE FAILURE.

The contact owns a 2016 Ford C-Max Energi. The contact stated that while the vehicle was parked, the charging cord overheated and became inoperable. The vehicle was not diagnosed or repaired. The VIN was not included in NHTSA Campaign Number: 18V592000 (Equipment). The manufacturer was not notified of the failure. The approximate failure mileage was 70,000.

The contact's father owns a 2016 Ford C-Max Energi. The contact stated that several electrical features including the horn, hazard lights, power locks, and power windows engaged independently while driving at various speeds. The contact also stated that on multiple occasions, all four windows had been lowered upon returning to the vehicle even though the vehicle was turned off. The dealer had been notified of the failure and the contact was given an estimate for a diagnostic test. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 55,000. The VIN was not available.

Both this 2016 and my 2013 ford c-max hybrid have the backup cameras failing. Sometimes they work, and sometimes they have a black or blue screen than pops up and it says camera unavailable. I know there is a recent recall for other fords with backup camera issues, but the c-max sells much lower volumes so it is harder to get the same exact problem recalled.

I was driving slowly leaving a supermarket parking lot. There was no one else around. There was a sudden loud bang, the car lurched upward and to the right, coming to rest over a curb hanging down a ditch. The front end started to smoke and then caught fire. The car was a total loss. There had been no impact. I was able to escape down the ditch with the help of police and the fire department put out the fire. The first 2 pictures are on the scene; the remainder in the tow lot. Friends have suggested that perhaps the hybrid battery exploded.