2016 FORD C-MAX Complaints

The contact owns a 2016 Ford C-Max Hybrid. The contact received notification of NHTSA Campaign Number: 25V695000 (BACK OVER PREVENTION); however, the part to do the recall repair was not yet available. The contact stated that the rear-view camera displayed a black screen while the vehicle was in reverse(R). The contact stated that the failure obstructed the driver's visibility, preventing the driver from safely operating the vehicle. The message "Rear-view Camera not Available" was displayed on the screen. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 40,000.

See attached document for complaint. RE: NHTSA SAFETY RECALL 25V695 To whom it may concern, In August 2025 we took our 2016 CMAX into the Ford Dealer we purchased it from to have the check out the back-up camera that was not working and have a service done. They charges us $225.00 to check it out and then wanted to service it for several hundred dollars more. There was no mention at that time about a recall, and after re-reading the bulletin you sent out, that did not come until October. The online status was that any repairs were not to begin until June 2026. Both of us are seniors and being concerned of the safety issues with the camera, we looked for the best price to repair/replace the camera and found a company, G&O Body in Placerville that did the repair for $618.25 In November.. So, at this point, we are out of pocket $843.25 to fix an issue that was put under free repair thru the recall. I would like to know how to apply for reimbursement for this camera replacement cost.

The contact owns a 2016 Ford C-Max Energi. The contact received notification of NHTSA Campaign Number: 25V695000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated that while in reverse(R), the rearview camera failed to display an image as intended on the center digital screen. No warning light was illuminated. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 54,000.

The contact owns a 2016 Ford C-Max Hybrid. The contact stated that while in reverse(R), the rearview camera image appeared upside down. The vehicle was taken to an independent mechanic but was not diagnosed or repaired. The contact was referred to the dealer for assistance. The vehicle was taken to the dealer, but was not diagnosed or repaired. The contact was referred to the NHTSA Hotline for assistance. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

The contact owns a 2016 Ford C-Max Energi. The contact stated that while charging the hybrid battery, the battery stopped charging after 15-16 minutes. The contact stated that the battery could only be charged for 15-16 minutes at a time. The contact stated that there was a red triangle warning light illuminated on the charger but there was no warning light illuminated on the vehicle. Additionally, the contact stated that the mileage range of the vehicle per charge was decreasing continuously. The vehicle was taken to dealer several times to be diagnosed; however, the cause of the failure could not be determined. The vehicle was taken to another dealer, Gator Ford (11780 Tampa Gateway Blvd, Seffner, FL 33584), where it was diagnosed that the hybrid battery had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 50,000.

The contact owned a 2016 Ford C-Max. The contact stated that while coming to a stop in a parking lot attempting to obtain mail from a mailbox; the vehicle independently accelerated and it was unknown what gear the vehicle was stationed in. In addition, it was unknown if the brake pedal was depressed or the gear the vehicle was in at the time of the failure. The vehicle had struck and knocked 3 mailboxes down and crashed into the front passenger side corner panel of a Mail Van coming to a stop as it was revving. The vehicle traveled 26 feet from its original stationed position. The vehicle was deemed a total loss. Both front wheels were severely bent outwards after the crash. The air bags did not deploy. The mail delivery employee sought medical attention for cuts and bruises. The contact did not seek medical attention or sustained any injuries. A police report was filed. The vehicle was towed to a tow lot by AAA where it was later taken by the insurance provider for further investigation. The local dealer was not contacted. The manufacturer was made aware of the failure. The failure mileage was approximately 44,530.

The contact owns a 2016 Ford C-Max Energi. The contact stated that while operating the vehicle, the message "Service Power Steering" was displayed, and the steering wheel suddenly became difficult to turn in either direction. The vehicle was taken to the local dealer who diagnosed that the steering rack was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer has not yet contacted. The failure mileage was 37,200.

The contact owns a 2016 Ford C-Max. The contact stated that while driving at an undisclosed speed, she heard an abnormal sound emanating from the engine compartment, prompting her to discontinue driving the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission would need to be replaced. The vehicle was not repaired. The contact stated that the transmission had previously been replaced 3 years prior. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 49,000.

The contact owns a 2016 Ford C-Max Energi. The contact stated while driving 25 MPH, the contact attempted to honk at another vehicle, but the horn failed to respond while depressed. The contact stated that the horn occasionally responded while depressed. The vehicle was taken to an independent mechanic where it was repaired temporarily with electrical gel on a fuse. The contact attempted to check the fuse, but the fuse box cover was difficult to remove. The failure reoccurred after several months but the electrical gel failed to repair the vehicle. In addition, the horn failed to respond while depressed. The local dealer was contacted but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 92,000.

The contact owns a 2016 Ford C-Max Energi. The contact stated while in reverse (R) and backing up at 3 MPH the back-over prevention camera failed and displayed a black screen. The contact stated that when the back-over prevention camera failed to operate, the radio and the GPS became inoperable. The contact stated that the back over prevention screen occasionally turned blue or showed a distorted image. The contact stated no warning light was illuminated. The contact stated that the failure was intermittent but occurred several times. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that a software update was needed. The vehicle was repaired. The contact stated that she was advised by the dealer that the software update was not a certain remedy. The contact stated that the failure had reoccurred and that the back-over prevention camera became inoperable. The manufacturer was informed of the failure. The failure mileage was 127,295.