2004 FORD E-150 Complaints

The contact owns a 2004 Ford F-150. The contact stated that while parked when the vehicle suddenly rolled backwards downhill the contact's son attempted to get into the vehicle to make it stop. The trailer's jackknife stopped the vehicle from going onto the road. The contact manually moved the vehicle back into their garage. The contact stated their son did receive injuries to their head, left or right leg (the contact was unsure of the exact leg), and their left or right arm (the contact was unsure of the exact arm). Medical attention was needed. The dealer was not contacted. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to file a safety complaint. The failure mileage was 74,000.

VIBERATION IN REAR AND CLUNKING NOISR IN REAR WHEN STOPPING AT LIGHT THEN TAKING OF WHILE MAKING A RIGHT TURN

2004 FORD 4.6L ENGINE: #2 SPARK PLUG EJECTED FROM CYLINDER HEAD. ~$700 TO REPAIR!!!

THERE ARE TONS OF DRIVERS ON PUBLIC ROADS USING OFF ROAD LED LIGHT BARS AND USING AMPLIFIED HID HEADLIGHTS. THEY ARE SO BRIGHT I HAVE TO BLOCK THE LIGHT WITH MY HANDS WHEN THEY DRIVE BY. I KNOW THIS IS ILLEGAL. IT IS TERRIBLY UNSAFE. WHY ARE THERE NOT LAWS BEING ENFORCED TO PREVENT THEIR USE ON THE STREET?

AT THE POINT I REACH 40 MPH TRUCK SHIFTS TO NEUTRAL, HAVE TO PULL OVER SAFELY AND TAKE TRUCK OUT OF OVERDRIVE TO GET HOME. VERY DANGEROUS WHEN TRAVELING AT THAT RATE OF SPEED. DID SOME OF MY OWN INVESTIGATING AND FOUND MANY WEBSITE HAVE ANGRY PEOPLE WHO ALSO OWN SAME VEHICLES WITH VERY LOW MILEAGE. I SAW THE RANGE OF MILES BETWEEN 44,000 MILES TO 150,000 MILES. PLEASE REFER TO WWW.CARCOMPLAINTS.COM JUST TO START WITH, THERE ARE MANY OTHER WEBSITES FOR THIS MODEL YOU CAN SEE. PLEASE HELP. *TR

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE LOWER BALL JOINTS WERE CAUSING PREMATURE WEARING OF THE TIRES. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FRONT END SPRINGS WERE COMPLETELY FRACTURED. THE DEALER AND MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE MANUFACTURER STATED THAT THERE WERE NO ACTIVE RECALLS REGARDING THE FAILURE AND DECLINED TO PROVIDE A REMEDY TO RESOLVE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 93,000. UPDATED 05/05/14*JB

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THE FRONT PASSENGER'S SIDE WINDOW INDEPENDENTLY OPENED. THE FAILURE RECURRED SEVERAL MONTHS LATER ON THE REAR PASSENGER WINDOW. THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT BOTH WINDOW REGULATOR ASSEMBLIES WOULD NEED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURE WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

TL* THE CONTACT OWNS A 2004 FORD E-150. THE CONTACT STATED THAT A PRIVATE MECHANIC ATTEMPTED TO REMOVE THE SPARK PLUGS BUT THEY WERE FUSED TO THE ENGINE. THE VEHICLE WAS EVENTUALLY REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 118,000. THE VIN WAS UNAVAILABLE.

TODAY WAS DRIVING NORMALLY ON THE SIDE ROAD NOT TOWING & IN OVERDRIVE WHEN AROUND 40MPH THE OVERDRIVE DISENGAGED & STARTS REVVING LIKE IT'S IN NEUTRAL. I PULL OVER & PUT IT INTO PARK & THEN BACK INTO OVERDRIVE & START DRIVING ONCE AGAIN & SAME THING HAPPENED THREE TIMES. LUCKILY THERE WAS A SERVICE SHOP CLOSE. I TOOK THE TRUCK IN & THEY SAID TAKE IT TO A TRANSMISSION SHOP. HE ALSO SAID IT WAS FINE TO TAKE IT OUT OF OVERDRIVE & THAT WOULDN'T CAUSE IT TO DO THAT. SO, I TOOK IT OUT OF OVERDRIVE & IT DIDN'T MISS A BEAT. AFTER READING THE REVIEWS IT SEEMS TO BE AN ISSUE WITH THE OVERDRIVE SERVO RETAINING CLIP BREAKING. THIS IS BY FAR A MAJOR PROBLEM FORD NEEDS TO LOOK INTO THAT COULD POTENTIALLY PUT LIVES AT RISK. IF IT'S A BAD PART WHY NOT FIX THE PROBLEM IF THERE ARE HUNDREDS OF REPORTS ON THIS SAME EXACT ISSUE? I'VE BEEN A FORD OWNER ALL MY LIFE & AM TRULY SADDENED THAT THIS COULD POSSIBLY BE MY LAST FORD I EVER BUY AGAIN. I'M HOLDING FORD ACCOUNTABLE ON THIS & EVERYONE ELSE THAT HAS THE SAME ISSUE SHOULD DO THE SAME. IT'S A $2.50 PART, THAT'S ALL. & WHEN YOU BRING IT INTO FORD OR ANY OTHER TRANSMISSION SHOP THEY WANT TO DO A WHOLE REBUILD WHICH WILL COST THOUSANDS. WE GO BY THE SAYING BUILT IN AMERICA FOR A REASON & THAT'S NOT USING CRAP PARTS. BUILD IT RIGHT THE FIRST TIME & HAVE NO PROBLEMS. IF YOU START THROWING PARTS & BUBBLE GUMMING IT TO DEATH, THIS IS WHAT HAPPENS. FIX IT FORD! THERE ARE ENOUGH COMPLAINTS ON THIS ALREADY. *TR

DURING THE WINTER MONTHS OUR 2004, FORD, E150, VAN HAS HAD OCCASIONAL YET COMPLETE BRAKE FAILURE SEVERAL TIMES. TYPICALLY, IT HAS HAPPENED WHEN IT WAS VERY COLD -10F AND TYPICALLY SLOWER SPEEDS 10-15MPH BUT TODAY IT WAS 30 F AND SPEEDS WERE 45-50 MPH AS WE WERE COMING DOWN A MOUNTAIN PASS IN COLORADO. WE ALMOST REAR ENDED A SEMI AND ALMOST TOOK ANOTHER CAR HEAD ON BUT THEY HAD MOVED INTO THE FAR LANE. BEFORE REACHING THE BRAKE FAILURE RUN OFF WE WERE ABLE TO DOWN SHIFT AND EVENTUALLY THE BRAKES CAME BACK TO COMPLETE WORKING ORDER. THE VAN HAS BEEN BROUGHT IN SEVERAL TIMES TO FORD DEALERSHIP AND EACH TIME SAME ANSWER, WE CAN'T REPRODUCE THE PROBLEM SO THEY HAVEN'T DONE ANYTHING. *TR