2004 FORD E-350 Complaints

I WAS A PASSENGER IN A 15 PASSENGER VAN COMING TO TRANSPORT ME FROM THE AIRPORT. IT WAS A WHITE FORD CLUB WAGON (YEAR UNKNOWN). WE WERE GOING AT 70 MILES PER HOUR ON CRUISE CONTROL. THE REAR TIRE BLEW OUT AND WE BEGAN TO SWERVE AND THEN STARTED TO DO 360 DEGREE TURNS AND THEN HIT A GUARDRAIL AND FLIPPED 1.5 TIMES. ONE PERSON WAS KILLED AND SEVERAL MORE WERE INJURED SEVERELY. THE FRONT PASSENGER HAD TO HAVE THE JAWS OF LIFE TO REMOVE HER FROM THE VEHICLE. *TR

GAS FILL LINE CLOSES AND CAN ONLY FILL AT A RIDICULOUSLY SLOW RATE OR NOT AT ALL WITH SOME OF THE FASTER GAS PUMPS. *TR

2004 E-350 FORD DIESEL VAN ..IN 06 FUEL TANK DELAMINATION FORD REPLACED TANK..08 FUEL TANK DELAMINATION AGAIN @ 14000 MI. COST TO ME 2200.00. DEALER SAID FORD WILL NOT ADMIT TO A TANK PROBLEM AND COULD NOT ASSURE ME THE DELAMINATION PROBLEM HAS BEEN CORRECTED TO DATE..I CAN'T AFFORD 2,200.00 EVERY 14000 MI. I USE ONLY HESS DIESEL FUEL. I KNOW I AM NOT ALONE WITH THIS PROBLEM, THE DEALERSHIP SAID THEY DO AT LEAST TWO A MONTH. THIS IS A DANGEROUS CONDITION..THE TRUCK LOSES POWER AND STALLS. *TR

VEHICLE LOST POWER 3 DIFFERENT TIMES, ONCE ON INTERSTATE, TWICE IN HIGHWAY TRAFFIC, AND IN ONE CASE THE ENGINE DIED. TURNS OUT CAUSE WAS FAILURE OF TANK LINING CLOGGING UP THE FUEL SYSTEM. EACH OF THE 3 TIMES I REPLACE FUEL FILTERS BEFORE FINALLY CLEANING OUT THE TANK AND DETERMINING ACTUAL PROBLEM. FORD KNOWS THERE IS A PROBLEM WITH THE TANK LINING, AS SHOWN ON FORD TECHNICAL SERVICE BULLETINS 19728, BUT HAS DONE AND WILL DO NOTHING ABOUT THE PROBLEM EXCEPT TELL ME TO REPLACE MY TANK AT ALMOST $600 + LABOR. *TR

AUTOMATIC TRANSMISSION WILL SLIP OUT OF GEAR WITHOUT WARNING DURING ON-ROAD OPERATION. *TR

TL*- THE CONTACT STATED THAT AT EACH TIME HE SPRAYED THE WASHER ON THE WINDOWS FROM THE 2005 FORD E350 WITH 100 FAILURE MILEAGE THE WASHER WENT ONTO THE ROOF OF THE VEHICLE. THE VEHICLE HAS BEEN TAKEN TO THE DEALER TWICE, AND THE DEALER REPLACED A TRIPLE PANEL TWICE, BUT THE PROBLEM STILL EXISTED. THE CURRENT MILEAGE WAS 17,000.*AK

TL*- THE CONTACT STATED THAT THE PASSENGER SIDE SEAT BELT LATCH ON THE 2004 FORD E350 WILL NOT STAY LATCHED. THE FAILURE MILEAGE WAS 60000. THE SEAT BELT LATCH WOULD POP OUT OF THE BUCKLE WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO THE DEALERSHIP, AND THEY INFORMED HIM HE SHOULD REPLACE THE SEAT BELT LATCH ASSEMBLY. THE VEHICLE CURRENTLY HAD 82000 MILES. *AK UPDATED 03/30/07. *JB

DT*: THE CONTACT STATED WHILE DRIVING 25 MPH, THE ENGINE STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED AFTER 20 MINUTES, AND WAS TAKEN TO A SERVICE DEALER WHERE THE PROBLEM WAS UNABLE TO BE DETERMINED. THERE WAS A NHTSA RECALL # 05V270000, WHICH PERTAINS TO THE WIRING. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

2004 FORD E-450 AMBULANCE 5/31/06 CREW STATED THE ENGINE WAS SURGING, EGR VALVE REPLACED BY DEALERSHIP. 5/31/06 CREW STATED A/C QUIT BLOWING AND GRINDING NOISE HEARD LARGER FUSE INSTALLED BY DEALERSHIP. DEALERSHIP STATED ALL OTHER A/C TEST CHECKED OUT OK. DEALERSHIP ADDED BOOSTER REPLACED TO DIESEL FUEL ALSO REPLACED FILTER, DRAINED WATER SEPARATOR. 9/1/06 ENGINE OIL LEAKING, CREW ALSO HAD A/C CONCERNS AGAIN DEALERSHIP REPLACED GEO ROTOR OIL PUMP COVER GASKET AND SEAL WEAR SLEEVE AND REASSEMBLE POST ROAD. DEALERSHIP FOUND COMPRESSOR SHAFT BROKE REPLACED A/C COMPRESSOR AND CLUTCH ASSEMBLE ACCUMULATOR AND FRONT ORIFICE TUBE. DEALERSHIP ALSO REPLACED FUEL INJECTOR CONTROL MODULE HARNESS, AND EXHAUST PRESSURE SENSOR SECONDARY TO RECALL. 10/12/05 CREW COMPLAINS THAT ENGINE SOUND LIKE IT IS "SUCKING AIR" DEALERSHIP STATED NOTHING WRONG, LATER THAT WEEK CREW MEMBERS FOUND AIR LEAK AT TURBO BRACKET CONTACTED DEALERSHIP THEY ADVISED THAT NOTHING WAS WRONG AND THAT WAS THE WAY IT SHOULD SOUND. WE STILL HAVE THIS EXTREME SURGING SOUND IN THE CAB ON ACCELERATION, THE SOUND IS SO LOUD THAT WE CAN NOT HEAR THE COMMUNICATION RADIO. THIS TRUCK IS A 2004 AMBULANCE WITH ONLY 24,964 MILES ON IT AND IS HOUSED INSIDE A CLIMATE CONTROLLED STATION. WE ARE AGAIN MAKING AN APPOINTMENT TO HAVE TURBO CHECK BECAUSE OF AIR LEAK. *NM

VEHICLE WAS PURCHASED ON OR AROUND SEPTEMBER 2003. ON MAY OF 2005 WE BEGAN TO HAVE MULTIPLE PROBLEMS CONCERNING THIS VEHICLE. THE MOST SIGNIFICANT OF THESE PROBLEMS IS AIR CONDITIONING COMPRESSORS LOCKING UP AND BREAKING THE DRIVE BELT. THIS VEHICLE IS AN AMBULANCE SO A FAILURE COULD CONTRIBUTE TO THE DEATH OF A PATIENT. WE HAVE TRIED VARIOUS REPAIRS TO THIS VEHICLE AS IT HAS FALLEN OUT OF WARRANTY AT THIS TIME. FIRST WE REPLACED THE COMPRESSOR, ACCUMULATOR AND ORIFICE TUBE AND THE BELTS THEN FLUSHED THE SYSTEM. THE 2ND OCCURRENCE WE REPLACED THE COMPRESSOR, ACCUMULATOR AND ORIFICE TUBE THEN FLUSHED THE SYSTEM, THE 3RD OCCURRENCE WE REPLACED THE COMPRESSOR,CONDENSER, ACCUMULATOR AND ORIFICE TUBE THEN FLUSHED THE SYSTEM. AT THIS TIME WE TRIED PLACING EXTERNAL FANS TO HELP LOWER THE HEAD PRESSURES THEN REPLACED THE FAN CLUTCH WITH A SNOW PLOW FAN CLUTCH AS DIRECTED BY OUR FORD DEALER. THE 4TH INCIDENT WE REPLACED THE COMPRESSOR THEN EXTENDED THE EVACUATION PERIOD FOR FEAR OF A POSSIBLE OIL OVERCHARGE. THE 5TH OCCURANCE ON 10/25/2006 WE REPLACED THE COMPRESSOR,CONDENSER, ACCUMULATOR AND ORIFICE TUBE THEN FLUSHED THE SYSTEM. WE ARE NOW IN THE PROCESS OF TRYING A BETTER GRADE REFRIGERATION OIL IN PLACE OF THE USUAL PAG OIL. WE HAVE BEEN TRYING EVERYTHING WE CAN THINK OF TO COMBAT THIS PROBLEM WITH NO SUCCESS. *NM