2004 FORD E-350 Complaints

AT 68,450 MILES, SEVERAL ISSUES OCCURRED: 1) OIL PRESSURE SWITCH BLEW OUT OF THE HOUSING, 2) OIL WAS VISIBLE IN COOLANT, 3) OIL WAS LEAKING FROM ENGINE, 4) IDLE VACILLATED UP AND DOWN W/O ANY ACTION ON PART OF THE USER. TOOK VAN TO DEALER, WHO CLAIMED TO HAVE REPAIRED THESE ITEMS. INSPECTION OF THE "REPAIRED VEHICLE" REVEALED OIL STILL DRIPPING OFF ENGINE ONTO GROUND. WAS TOLD THAT THIS WAS "NORMAL" AND WOULD DISAPPEAR. HOWEVER, THIS DID NOT HAPPEN. ENGINE HAS CONTINUED TO LEAK AND OIL CONTINUES TO MIX WITH COOLANT FLUID, EVEN AFTER FLUSHING SYSTEM TWICE SINCE REPAIR. DESPITE NUMEROUS CALLS TO DEALER, PROBLEM HAS NOT BEEN FIXED. ENGINE HAS LESS THAN 13K ADDITIONAL MILES ON IT SINCE "REPAIR" AND OIL IS STILL LEAKING. LEAK CONTINUES TO GET WORSE WITH TIME. I BELIEVE THIS IS A MANUFACTURER'S DEFECT AND SINCE THE ENGINE HAS FAR LESS THAN 100K MILES ON IT, SHOULD BE REPAIRED AS A WARRANTY ITEM. MIXING OF OIL AND COOLANT IS A SAFETY HAZARD AND NEEDS TO BE PROGRAMMATICALLY ADDRESSED BY FORD.

ALL GAUGES STOP WORKING WHEN IT RAINS BUT STARTS AND RUNS OK. POWER WINDOWS DO NOT WORK WHEN IT RAINS BUT STARTS AND RUNS OK.

TL* THE CONTACT OWNS A 2004 FORD E-350. WHILE DRIVING APPROXIMATELY 25 MPH, THE FRONT AIR BAGS DEPLOYED WITHOUT WARNING. THE CONTACT SUSTAINED BURNS ON BOTH FOREARMS, BUT DID NOT RECEIVE MEDICAL ATTENTION. THERE WAS NO POLICE REPORT FILED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 177,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2004 FORD E-350. WHILE DRIVING 70 MPH, THE VEHICLE STALLED AND WAS TOWED TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE FUEL INJECTOR, FUEL TANK, FUEL PUMP, AND THE ENGINE NEEDED TO BE REPLACED. THE TECHNICIAN ALSO STATED THAT THE SILVER COATING IN THE FUEL TANK WAS FROM ONE OF THE DAMAGED PARTS. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 52,000. UPDATED 04/07/15*LJ UPDATED 11/3/15*JS

TL* THE CONTACT OWNS A 2004 FORD E-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, HE NOTICED SMOKE COMING FROM THE EXHAUST PIPE. THE VEHICLE WAS TAKEN TO THE DEALER AND TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. BOTH TECHNICIANS ADVISED THE CONTACT THAT THE EGR COOLER AND THE HEAD GASKET WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

SIDEWALL SEPARATED COMPLETELY ON ONE TIRE AND THE TREAD IS SEPARATING FROM THE BODY IF ANOTHER TIRE. BOTH TIRES ARE THE SAME MAKE AND MODEL. DEAN MUD TERRAIN SXT M+S LT245/75-R16 DOT ON TIRE WITH SIDEWALL SEPARATION UP11-DNW-0108 DOT ON TIRE WITH TREAD LUG SEPARATION UP11-DNW-0108 FAILURES OCCURRED AT THE SAME TIME ON A 2004 FORD E350 ECONOLINE. DURING FREEWAY OPERATION, OPERATOR FELT A RUMBLE AND SLOWED AND PULLED OVER TO THEN NOTICE THE SIDEWALL HAD SEPARATED. HE THEN ALSO NOTICED THE REAR. CHANGED TIRES TO A DIFFERENT BRAND AND CONTACTED COOPER THE PARENT COMPANY OF DEAN TO SEE IF THERE WAS A RECALL. NO RECALL WAS STATED UNDER THEIR COMPANY. FOUR OF THE TIRES ON THE VAN ARE UNDER WARRANTY AND THEY DIRECTED ME TO CONTACT A LOCAL DISTRIBUTOR TO CHANGE THEM. STILL HAVE THE TIRES AND HAVE YET TO CHANGE THEM OUT. *TR

TL* THE CONTACT OWNS A 2004 FORD E350. EQUIPPED WITH BF GOODRICH T/A A/S TIRES, SIZE: LT245/75R16. THE CONTACT STATED THAT RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 12T019000 (TIRES: TREAD/BELT) WAS RECEIVED JULY OF TWO THOUSAND TWELVE. THE CONTACT BELIEVED THAT THE WAIT FOR THE REPAIRS HAD EXCEEDED A REASONABLE AMOUNT OF TIME. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE DOT NUMBER AND VIN WERE NOT AVAILABLE.

TL* THE CONTACT OWNS A 2004 FORD E-350. THE CONTACT STATED THAT THE VEHICLE WOULD STALL WITHOUT WARNING. THE VEHICLE WOULD STUTTER AND THEN STALL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE FUEL INJECTION CONTROL PRESSURE SENSOR FAILED. THE CONTACT REFERENCED NHTSA RECALL CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM: WIRING) BUT WAS ADVISED THAT THE VEHICLE WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 93,000.

TL* THE CONTACT OWNS A 2004 FORD E-350. THE CONTACT STATED THAT THE VEHICLE WOULD LOSE POWER WHEN ACCELERATING AND THEN STALL. THE CONTACT WOULD HAVE TO WAIT THIRTY MINUTES BEFORE THE VEHICLE WAS ABLE TO BE RESTARTED. THE CONTACT STATED THE FAILURE WOULD OCCUR WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES, BUT THERE WAS NO SOLUTION TO THE PROBLEM. THE CONTACT DID RESEARCH AND FEELS THE PROBLEM IS CAUSED BY THE FUEL TANK DELAMINATING. THE FAILURE MILEAGE WAS 50,800 AND THE CURRENT MILEAGE WAS 120,000.

I AM THE ORIGINAL OWNER OF A 2004 FORD E 350 DIESEL,IT HAS BEEN IN THE SHOP MANY OF TIMES FOR THE SAME PROBLEM TRUCK STOPS RUNNING IN MIDDLE OF INTERSECTIONS, HIGHWAYS ETC DOES NOT START AND NEEDS TO BE TOWED.FORD DEALERSHIP HAS NO IDEA WHAT IS WRONG WITH TRUCK, I GET TRUCK BACK SAME THING HAPPENS. REPEATEDLY. NOW THAT THE TRUCK IS OUT OF WARRANTY SAME THING HAPPENS RESULT: DELAMINATING FUEL TANK, LITTLE SLIVERS OF PAINT CLOGGING FUEL LINES, PUMPS AND INJECTORS. *TR