2001 FORD ECONOLINE Complaints

NAR 02/10/2003. OHIO POLICE REPORT. TIRE BLEW OUT. VEHICLE SKIDDED OFF THE ROAD STRUCK A GUARDRAIL. THE REAR TIRE AND RIM WAS MISSING AND THE STUDS HAD BROKE OFF. TIRE BRAND, SIZE AND DOT # UNKNOWN. *TT *JB

CONSUMER WAS INVOLVED IN A FRONTAL COLLISION WITH AN ELECTRICAL POLE AND THE RIGHT FRONT WHELL CAME COMPLETELY OFF. CONSUMER STATED THE ENTIRE WHEEL ASSEMBLY CRACKED. NLM

ALTHOUGH NO ONE WAS HURT AND THE DEALER FIXED THE PROBLEM AT NO COST I WISH TO REPORT THIS INCIDENT AS A "NEAR MISS". THE PART IN QUESTION ,EXHAUST DAMPNER ASSY IS A BALANCER [7 TO10 POUND ROUND WEIGHT] ATTACHED TO THE EXHAUST SYSTEM UNDER THE VEHICLE . THE WEIGHT IS WELDED TO A BRACKET WHICH IS ATTACHED TO THE EXHAUST SYSTEM. THE PART FELL OFF WHEN THE BRACKET BROKE FOR NO APPEARENT REASON.LUCKILY THE VEHICLE HAPPENED TO BE GOING SLOWLY AT THE TIME.SHOULD THE VEHICLE HAVE BEEN TRAVELING AT 65MPH THE PART IN QUESTION WOULD HAVE SURELY BECOME A DEADLY PROJECTILE .THE DEALER DID REPAIR THE VEHICLE BUT DID NOT SEEM OVERLY CONCERNED ABOUT THE SAFETY ISSUE, AS I HAVE 5 MORE OF THESE VEHICLES AT THIS LOCATION, I AM VERY CONCERNED ABOUT THIS AND I AM THEREFOR REPORTING IT TO YOUR ORGINIZATION FOR FURTHER REVIEW .......PLEASE ACKNOWLEDGE RECEIPT OF THIS MESSAGE,THANK YOU RICHARD B. ANDRIEN, VEHICLE SUPERVISOR AND SYSTEM SAFETY SUPERVISOR FOR COMCAST CABLEVISION OF NEW JERSEY LLC. *AK

REAR COIL SPRINGS ARE COMPRESSED TOO CLOSE TO VEHICLE. WHEN VEHICLE IS BEING DRIVEN IT IS HIGH ENOUGH FOR CONSUMER TO RETRO FIT VEHICLE FOR HANDICAP USE. CONTACTED DEALER, AND THE DEALER WAS NOT WILLING TO DO ANYTHING.*AK

TIRE WAS OUTER ON DUAL REAR WHEELS - THE INSIDE OF THIS TIRE BLEW OUT COMPLETELY. FORTUNATELY I WAS ABLE TO CONTROL TRUCK AND QUICKLY ACCESS THE SHOULDER, BUT IN HEAVY EVENING TRAFFIC. *AK (TIRESIZE: LT225/75RX)

WHILE VEHICLE WAS PARKED IN DRIVEWAY AND WITHOUT ANY INDICATION VEHICLE CAUGHT ON FIRE AROUND RADIO AREA, AND SPREAD TO ROOF/ BACK OF VEHICLE. FIRE DEPARTMENT WAS CALLED, AND PUT OUT FIRE. PLEASE PROVIDE FURTHER INFORMATION.*AK

SIDEWALL SPLIT AND BLEW OUT ON NEW VEHICLE W\ 190 MILES. FORD DEALER REPLACED TIRE. WE HAVE 6 OTHER VANS PRODUCED AT THE SAME TIME WITH RAZOR THIN CRACKS IN THE SIDEWALLS THAT RUN BEAD TO TREAD ON ALL STEELTEX TIRES.*AK (DOT NUMBER: 8X1L 1X1 TIRESIZE: LT22575R16)