2018 FORD ECOSPORT Complaints

While having oil changed at the Ford dealership, I was told there was a small oil leak. I made an appt for a diagnostic test for the following week. I was told the diagnostic test showed a cracked valve cover. I had it repaired while they had the vehicle.

I have had issues in the past with the transmission of this car for the past few months, it initially started to give me issues around 49k miles in this car, so I got it flushed out by a mechanic and it ran fine for a few months. Just a few days ago, I was headed home and my transmission went completely out as I was about to enter a state highway and I had to pull over into a neighborhood to get it towed. I had to send it over to my mechanic again, and he said the transmission is completely done for. My car could've almost went out on me completely if I kept pushing it, but I knew it was a hazard. I've heard from multiple other sources as I checked online to see if this was an issue with other Ecosports as well, and it seems like there's multiple complaints of this issue. I had no idea this car had an issue, at there was no warning light or anything indicating there was something wrong with it, until I noticed the acceleration wasn't quite right.

1.0L EcoBoost suffered a repeat failure following Recall 23S64, Metro Ford of OKC confirmed in writing that prior dealer workmanship caused the failure, and Ford Corporate (Case # CXH-08846832) is completely unresponsive, leaving the vehicle inoperable and unsafe.

I had a Purge valve put in about a year ago and was told that that was the problem for my gas gauge going completely to empty while driving and losing power while driving

The contact owns a 2018 Ford EcoSport. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the failure occurred a year after the recall repair was performed. The contact stated that while her daughter was driving at an undisclosed speed, the vehicle lost motive power. There was no warning light illuminated. The vehicle was towed to the residence and then to the dealer, where it was determined that the engine and turbocharger needed to be replaced due to internal bearing failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 71,000.

On XXX, my 2018 Ford EcoSport experienced a sudden loss of engine oil pressure and loss of power while driving on [XXX], consistent with the failure mode described in Ford Safety Recall 23S64 / NHTSA Recall 23V905 (engine oil pump drive belt tensioner arm fracture and/or oil pump drive belt degradation). The vehicle lost motive power on a public highway and had to be towed to Olathe Ford Lincoln, Olathe, KS for repair. The dealer has confirmed the failure is covered under this recall, but has stated repair parts are backordered with an estimated repair time of 2–3 months. I am filing this complaint to document that the defect described in this recall has actually manifested in my vehicle — a loss of engine power on a highway — which per Ford's own notice also results in loss of the mechanical vacuum pump required for power brake assist, creating a serious crash risk. I am requesting NHTSA log this incident against Recall 23V905 and evaluate whether a 2–3 month repair timeline meets the "reasonable time" remedy standard under 49 U.S.C. § 30120. I also did not receive and notice of the recall before the event occured, so that I could be proactive with the repair before the dangerous situation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford EcoSport. The contact stated that while driving 55 MPH, there was an abnormal knocking sound coming from the engine, and the vehicle lost automotive power. The contact stated that while slowing down, the RPM became extremely elevated, and the low oil pressure warning light remained illuminated. The vehicle failed to accelerate, and the contact pulled over into a nearby parking lot and parked the vehicle. The local dealer was contacted; however, the vehicle was not diagnosed. The contact was informed that the VIN was not under recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 106,000.

There was a recall on these cars do to timing chain issues but mine was not in the recall with the others but ones not in recall are having same issues. Car is a ticking time bomb I want fixed under the recall.

What component or system failed or malfunctioned, and is it available for inspection upon request? The braking system failed, preventing the vehicle from stopping properly. The vehicle is currently at a tow yard and is available for inspection upon request. How was your safety or the safety of others put at risk? Because the brakes failed, I was unable to stop at a traffic light. The vehicle entered oncoming traffic and was involved in a collision, placing my safety and the safety of other motorists at risk. Has the problem been reproduced or confirmed by a dealer or independent service center? No. I previously took the vehicle to the dealership several times for misfire and powertrain-related issues. The dealership was unable to identify the underlying problem and advised that the spark plugs were not tightened properly. Similar issues have occurred multiple times over the past few years. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle is currently at a tow yard and is awaiting inspection by the insurance company. Additional inspections may be conducted as part of the claim investigation. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? Yes. Warning lights appeared earlier this week, and I brought the vehicle to the dealership for diagnosis. The dealership was unable to determine the cause of the warnings. I picked up the vehicle on June 11, 2026. On June 12, 2026, the brakes failed, resulting in the accident.

Safety defect involves an extreme structural hazard caused by the improper execution and assembly of components under open Federal Safety Recall Campaign 23V905 (Ford Recall 23S64) on a 2018 Ford EcoSport.The vehicle previously underwent the authorized interim engine replacement mandated by Safety Recall 23S64. Following a recent diagnosis by certified technicians to investigate severe vehicle noise, it was discovered that all but one of the main front engine subframe (cradle) bolts are completely missing from the vehicle.The front subframe must be completely dropped and reinstalled to execute this specific recall's interim repair. The missing hardware is a direct result of critical structural fasteners being left loose or entirely uninstalled during the official recall service.As a direct consequence of the detached subframe shifting dynamically while driving, the vehicle has suffered severe structural and tire damage and tracking misalignment. The vehicle has been officially deemed entirely unroadworthy and unsafe to drive due to an imminent risk of structural collapse or catastrophic steering and control failure.The consumer is currently facing a refusal of accountability regarding this safety failure. The manufacturer's customer service division is classifying this severe hazard as a localized dealership workmanship dispute rather than a critical failure of federal safety recall integrity, leaving an unsafe, recalled vehicle unaddressed and grounding the consumer.