2015 FORD EDGE Complaints

I own a 2015 Ford Edge 4 door SEL with 76k miles which I purchased in 2017 as the second owner. The dealership sold me 5 new lug nuts due to swollen original lug nuts. One lug nut cap were damaged during routine removal to replace an 8 yr old failing tire pressure sensor. I was told the lugs were swollen and had to be replaced. This seemed OBSURD. I researched this to find out that the OBSURDITY was that Ford Motor Company had been sued about this and it is a known defect of Ford vehicles. Quietly known. I am submitting this complaint because of the defective lug nuts that are a known issue, and could have been replaced at the dealership from the very first oil change or routine maintenance appointment. These defective parts routinely strand motorists or cause unnecessary excess costs to the owners when the actual fix is far less than $1 for each. when the entire vehicle uses only 20, this is negligence on the part of Ford Motor company. As a consumer on a fixed income, who purchased the bumper to bumper warranty from Ford, the neglected $20 fix of MY vehicle has cost me over $75 so far, and if the dealership (an extension of Ford Motor Company) has their way, they are happy to charge me that for my 3 remaining tires. A total consumer burden of $300 (per the dealership pricing) for a $20 fix by the manufacturer. All becuase the know problem causes a financial burden and not enough consumers have actually had physical or catestrophic accidents,... yet. A RECALL is REQUIRED. If not, there should be a required reimbursement to ALL consumers who are forced to replace the defective parts. The reimbursement should be that the dealerships seek reimbursement, and that the consumers receive the replacements free of charge.

The contact owns a 2015 Ford Edge. The contact stated while driving approximately 65 MPH, there was an abnormal rattling sound coming from underneath the floorboard. The contact stated that the vehicle stalled. The contact pulled off the roadway. The contact stated that no warning light was illuminated. The contact had the vehicle towed to a dealer, where it was diagnosed and determined that the transmission flex plate had fractured and needed to be replaced. The vehicle had been repaired. The manufacturer had been informed of the failure. The contact later took the vehicle to the local dealer and was notified of Customer Satisfaction Program: 22N12 - Rattle Noise at the Transmission Bellhousing Area – Flex plate Cracks, associated to his VIN; however, the vehicle was no longer covered under the warranty or mileage extensions. The failure mileage was approximately 129,000.

The contact owns a 2015 Ford Edge. The contact stated that while driving at an undisclosed speed and attempting to accelerate, the vehicle hesitated, and lost motive power. No warning lights were illuminated. The vehicle was taken to the dealer, who determined that coolant intrusion had caused damage to cylinder #1. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related it to Customer Satisfaction Program: 21N12, but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 139,000.

I have had to replace three tire pressure sensors in the past six months. Mileage is about 130,000 and do not understand why the sensors are all failing about the same time. $80 to replace peach sensor.

Faulty water pump leak which is extremely expensive to repair due to manufacturer encasing it inside the timing belt chain. I cannot afford a $5K repair for something that should be extremely more affordable due to Ford’s scheme to acquire more money to repair. Standard mechanics cannot complete tasks due to the severity of the job as well as specialized tools required including lifting the car. These water pump, according to what I was informed was designed to last at least 150K miles.

The contact owns a 2015 Ford Edge. The contact stated while driving 40 MPH, the engine power was reduced, and the vehicle failed to accelerate as needed. The engine power reduced, and lower engine temperature messages were displayed. The vehicle was towed to the dealer. The vehicle was diagnosed by the dealer and confirmed that coolant had leaked into the cylinder. The manufacturer was made aware of the failure and confirmed that the vehicle was not included in a recall. The failure mileage was approximately 65,000. The contact is asking, if we choose to get a loan to replace our engine for approximately $6600, would we be reimbursed if there is a recall?

The contact owns a 2015 Ford Edge. The contact stated that the check engine warning light illuminated at vehicle start-up. The contact took the vehicle to an independent mechanic and the mechanic diagnosed a misfire in cylinder #4 due to coolant intrusion into the engine. The contact was informed that the engine needed to be replaced. The manufacturer was notified of the failure and the contact was informed that there were no recalls on the VIN. The vehicle was not repaired. The failure mileage was approximately 67,500.

The contact owns a 2015 Ford Edge. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, who informed the contact that there was coolant intrusion into a cylinder and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 138,000.

Engine has been shaking/misfiring and white smoke coming from Exhaust. Took it to ford and they said it was a coolant intrusion problem on the first cylinder. Learned there is a design flaw in Fords eco boost engines. There is currently a class action lawsuit with Ford. Was told by Ford that a new engine is needed. Approximately $9,000 for repair

The contact owns a 2015 Ford Edge. The contact stated while driving 6 MPH, the contact heard an abnormal sound, and the vehicle started jerking while attempting to accelerate. The contact stated that the failure seemed like the brake pedal was being depressed while accelerating. The vehicle was towed back to the residence. The vehicle was then taken to an independent mechanic and was diagnosed with transmission failure. The vehicle was repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 100,000.