2020 FORD ESCAPE Complaints

Door stop on both the driver side as well as the passenger side have broke off making it hard to actually open and close the door. As of 11/16/2023 the window is also stuck due to the door stop damaging the motor. After searching the Internet this is a very widespread issue when I took it to the dealership they said since it was out of warranty it wouldn't be covered. I don't believe this is anything but bad workmanship because the weld apparently breaks as low as 8000 miles. Well within the warranty period.

My driver door started making a loud cranking sound out of the blue when opening and closing the door. After several days, it became clear that the door hinge/catch was no longer secured and was loose. This was not the result of a gist of wind forcefully blowing the door open or something like that; it just broke on its own. Now the door swings wildly when opening and the window won’t roll all the way down. My vehicle was just a few months out of warranty so Ford won’t offer any assistance for fixing the problem. I have not yet repaired it because they say the whole door needs to be replaced and, at this time, I can’t afford the expense.

The left driver's door was making a popping noise. On closer inspection found that the door support bracket was broken. I took it to my local Ford dealer, and they confirmed the bracket was broken. When they replaced the part, the noise was still there. An inspection by the dealer's collision center showed a defect in the door and they stated the entire door had to be replaced. When asked if this was a known issue they replied it was an issue with the 2020 Ford Escape. I asked if my door would fall of their reply was "MAYBE". I was instructed not to push the door to hard when opening and closing the door. I phoned Ford and asked about this issue and the told me that they do not issue safety recalls on their vehicles and suggested I contact your agency. If there is a possibility that the vehicle door may fall off and it is a known issue I believe some safety recall should be issued.

There is an issue with the instrument gauge cluster upon ignition start-up. The digital gauge cluster screen suddenly turns off and restarts after a full minute of turning on the car's ignition. After an automatic software restart of the gauge cluster and driving on the highway through Northbound Mopac Loop 1 in Austin, the cluster shows a frozen black background with the blue normal drive mode. The gauge cluster works fine but intermittently goes blank after starting the car.

Drivers door check arm broken at spot welds rendering it ineffective and making drivers door window inoperable.

When opened front driver’s side door, heard creaking, rattling, and pop. Now door will not close as well as problems with the window not working in that door! The frame on car is also loose due to bad door pulling on the frame. I’m concerned door may open when driving. Ford dealership will not pay due to the fact warranty expired April 2023 with only 33,000 miles on vehicle. An inspection by an independent service center confirms the issue and estimates a $2,400.00 cost of repairs. Inspector indicates poor spot welding and rivets in check arm defective. Insurance will not cover any expenses since it is not a result of a collision!! There was no warning messages indicating any issue. Door noises were heard on a Saturday (11/11/2023) and on Sunday (11/12/2023) door popped and couldn’t be closed’

Driver side door will not close tight. Will sometime open while driving on highway

The drivers front door began making a popping sound as the door opened and closed. By the next day the door began to have trouble closing fully. I noticed the weld points had broken where the door check/limiter attached to the door. It sounds like the same issue as the NHTSA investigation PE23013. In order to fully close the door the door had to be disabled and the broken part removed.

The Check Arm Attachment on the driver side door for my 2020 broke off because of poor welding, I have read it is a common issue with the 2020 ford escape

Front side driver’s door starting making popping noises on Saturday. By Sunday of the same week only a day later the door made a crunching and breaking noise when opening, now the door has to be forced closed and the window will only go down about 4 inches.