2020 FORD ESCAPE Complaints

White foggy smoke from exhaust. Backing sensor or driving sensor are off when sensing environment. Car suspension not fully stable sorta drift to left or right.

I am submitting a safety complaint regarding my 2020 Ford Escape, which currently has an unrepaired safety recall involving the fuel injectors. Recall Information: Manufacturer Recall Number: 25S76 NHTSA Recall Number: 25V467 Recall Date: July 16, 2025 According to the recall notice, a fuel injector may crack and cause fuel to accumulate on top of the engine. The notice states that liquid fuel and/or fuel vapor near hot engine or exhaust components could ignite and cause an under-hood fire. I am very concerned because this recall has remained unrepaired since 2025, and as of September 2026, the remedy is still listed as unavailable. I am also currently experiencing a problem with my vehicle. Whenever I put gas in the vehicle, it has a difficult time starting afterward. The engine struggles to start after refueling, which is concerning to me because there is already an open recall involving the vehicle's fuel system. I understand that I cannot personally determine whether the starting problem is directly related to the recalled fuel injector issue. However, because the vehicle has an open fuel-system safety recall involving a potential fuel leak and fire risk, I believe these symptoms should be documented and investigated. I am concerned about continuing to operate this vehicle while the recall remains unrepaired, especially since the recall warns of the possibility of fuel or fuel vapor accumulating near hot engine components. I am requesting that NHTSA document and investigate my complaint and provide any available guidance regarding this unresolved recall and the symptoms I am experiencing. I would also like my concerns documented regarding the length of time this safety recall has remained without an available permanent repair.

I consistently get an AWD failure warning and then it turns off multiple different safety features of the car, traction control, hill assist, AWD, collision detection etc. I have seen a lot of people complain about the same thing. This is dangerous and ford needs to provide a solution to the bad ground of the AWD module.

The contact owns a 2020 Ford Escape. The contact stated while driving at an undisclosed speed, the message that the door was unlocked was displayed. The vehicle was taken to a dealer, and the contact was informed of an unrepaired recall associated with the VIN. The contact was informed that an unknown device was installed, and the vehicle was repaired; however, the failure reoccurred. The contact stated that the front driver's and passenger's side doors failed to unlock. The contact stated that the family crawled into the vehicle through the trunk. The vehicle was taken back to the dealer. The contact was informed that the driver’s and passenger’s side front doors needed to be replaced. The vehicle was taken to an auto body shop as per the dealer. The driver’s and passenger's side front doors were replaced but the failure reoccurred. In addition, the transmission shift to park warning light was illuminated. The vehicle was taken back to the dealer. The contact was informed that the auto body shop had clipped the wiring harness from an unknown sensor. The contact was informed that the wiring harness needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the dealer where it was diagnosed with battery failure. The battery was replaced, and the vehicle was repaired. The failure reoccurred. The contact stated that the front driver's and passenger's side doors failed to unlatch occasionally. The doors unlatched and the transmission shift to park error messages were displayed. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that the dealer was an independent dealer. The failure mileage was approximately 58,986.

My passenger headlight assembly seal has failed. Since the seal failed, the light has water buildup that caused the entire assembly to short out and stop working. There are not cracked in the headlight at all. My car only has 46,407 miles on it. My car has been to the service department at Town N Country Ford in [XXX]. Since we purchased the extended warranty, Town N Country submitted my claim to the warranty department, but they are refusing to pay because, they say it's a moisture problem. The moisture in the headlight is only there because the seal failed. Ford knows this is a problem, but yet they refuse to pay of the headlight replacement or make a recall for this problem. This is a major flaw and needs to be corrected by Ford, the consumer should not have to bear the brunt of this burden when it is clearly a defect with the headlight assembly itself. Please make Ford take responsibility for this issue immediately. Town N Country Ford said the cost to replace this headlight assembly will be $1,962.34 whenever they can receive the part. If these parts are on back order, clearly Ford has an issue and should be held accountable to replace these headlights free of charge by making a RECALL. I've requested the warranty denial report from Town N Country Ford, but I have not received anything as of this being filing XXX. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The thin metal gear shift dial has peeled extensively beginning in 2022 leaving RAZOR SHARP edges that cause constant skin lacerations as it's impossible to change gears and not to touch the sharp edges. I understand this is a very common problem with 2020 Ford models. Ford has now corrected the problem with newer models and the gear shift does not peel on newer models. However, that is STILL no help for current owners with the defective gear shifts. This is a serious defect causing unavoidable injury and needs to be addressed. This is the same problem that the defective window controls had and they were corrected by recall. This is NOT a cosmetic problem. Cosmetic problems do not cause injury. Why is the NHTSA and Ford not taking this seriously?

The contact owns a 2020 Ford Escape. The contact received notification for NHTSA Campaign Number: 26V117000 (Visibility); however, the part to perform the recall repair was not yet available. The dealer was notified of the issue and confirmed that the part was not yet available. The contact stated that upon starting the vehicle, the windshield wipers failed to operate as intended. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure; however, no assistance was provided. The failure mileage was approximately 85,000.

The rear cross traffic sensors are not detecting cross traffic when in reverse every time. It will work sometimes, but it failed to work at all for weeks. I have video showing it not working properly. I brought this to the dealership and was told that this is something that I will be required to fix out of my own pocket. This safety feature should be fixed or replaced at no cost the me because I was not involved in it no longer functioning. It is not clear why safety features that malfunction should be repaired at cost to the vehicle owner. If they stop functioning they should be fixed by the manufacturer.

Wipers will swipe a couple times then stop half way and not descend all the way. Then begin to “flutter” have to shut off for them to descend and turn on again, over and over.

I had complete brake failure while driving my vehicle yesterday I had new brakes installed on XXX by Mr tire auto service centersStore Number: #XXX ([XXX]) ?Invoice Number: XXX ?Guest ID: XXX ?Vehicle details: 2020 Ford Escape Titanium. They have deemed that PARTS were defective ( calipers and pads) . This situation ended up okay however if I was on open road I could have killed myself or others. The manufacturer of these parts needs to be flagged. We have requested a detailed list of the parts that were used to do this job and have also reached out to Monro who is their corporate affiliate. We have not heard back from them yet. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)