2020 FORD ESCAPE Complaints

The contact owns a 2020 Ford Escape. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly stalled with several unknown warning lights illuminated. The vehicle was restarted. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 69,000.

I have had 22 recalls to date on this vehicle and received 1 recall notice. Engine light comes on alot, makes noises and then goes away after a couple days. Windshield washer stopped working on front windshield, now back stopped working. Tire pressure monitor & sensor default stays on (previous recall) Window on driver side stopped working, back passenger door on drivers side don't shut correctly like the weld come loose. Back brakes make a crazy noise when backing up. Back up camera warning comes up. I've only had this vehicle since 09-2023 and purchased from Ford as a Ford Blue Certified and have nothing but issues. Most of these recalls risk is a fire. If I'm involved and live through a fire I will make sure FORD is held accountable. The open recall with risk of fire currently has been open since July 2025 and no repair yet. This is totally unacceptable if they want me to keep paying for it. Thank you

Turbo failed due to oil lines clogged. Failed again after repair two weeks later on highway almost causing a collision.

Premature failure of the moonroof shade dropping down or sagging from the track it is seated in, causing driver visibility issues and noise issues.

The transmission shifting got increasingly rough over time, and then suddenly refused to shift into gear/reverse. The Ford shop told us it was the reverse solenoid, but it ended up requiring a full transmission rebuild. Safety of the car refusing to shift gears led to loss of power several times, unable to accelerate in traffic, until total failure occurred. Problem was inspected by Ford dealership, then repaired by independent service center due to cost. Not inspected by insurance, as it did not result in a collision. Warning lamps did not turn on until total failure occurred. Then lights on gear shift dial blinked, refused to allow us to put the car in gear. Dash lights also indicated "check engine" at that time, but no earlier.

UNKNOWN December 25th, 2025, my vehicle started to shift poorly, breaking very harshly, giving a clonking sound when putting the vehicle into any gear, and when putting it into reverse, the car rocked roughly and threw a wrench light onto the dash. That wrench light gave a torque converter/transmission code. I took it to a dealership to get it diagnosed and they told me nothing was wrong with it and that it is driving as it should. I took it to a different shop for a second opinion and as soon as my vehicle was in the air, the Mechanic found that ALL of my mounts were bad, I had a transmission leak and might possibly have a bad torque converter. My safety as well as my [XXX] daughters was put at risk from the dealership not doing a thorough diagnostic on my vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); and the vehicle was taken to the dealer, where the engine control software was updated as an interim repair. The contact became aware of a strong fuel odor. There was no warning light illuminated. The dealer was notified of the issue, but the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 47,000.

The welds on the Driver's and passenger door hinges broke and now the broken hinge prevents the windows from rolling down. The welds on the muffler are also broken.

Summary of Problem: Following the mandatory software update for NHTSA Recall 22V859 (Ford 22S73) on my 2020 Ford Escape 1.5L, the vehicle experienced a catastrophic electrical failure. The vehicle is now subject to the expanded NHTSA Recall 25V467 (Ford 25S76) with a status of 'Remedy Not Available'. Safety Failures: Continuous Overcharging: A multimeter test confirms the alternator is overcharging at 15.5V or higher, posing a severe risk of battery explosion or vehicle fire. Safety System Collapse: The overvoltage has forced multiple safety modules into 'fail-safe' mode, disabling the Anti-Lock Braking System (ABS), Traction Control, and AWD Powertrain. Network Communication Failure: Diagnostic reports confirm a U3000 critical control module fault and 'Lost Communication' with the Battery Energy Control Module, indicating a software-induced network collapse. Undriveable Status: The vehicle has been unusable for over 30 days and cannot pass NY State Inspection due to persistent EVAP and module communication codes triggered by the recall update. Dealer Negligence: [XXX] (Dealer #XXX) confirmed that all physical communication lines are functional but refused a free recall-related diagnosis, demanding a $600 fee instead of honoring the federal safety recall mandate. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Shuddering transmission, vehicle struggles to change gears smoothly resulting in loss of acceleration. Rough gear changes from 1-3 gears Transmission fluid changed. Same issues. Issues go in hand with the current class action lawsuit of Ford Escape and Ford Focus over transmission issues. Failure of transmission and exorbitant repair cost over a safety critical issue should automatically require a NHTSA investigation.