2019 FORD ESCAPE Complaints

rough run condition when cold. coolant reservoir almost empty. Block test failed for hydrocarbons in the cooling system indicating a failed cylinder head to block gasket ror cracked head.P0302 misfire for cylinder 2 Issues have been addressed in Customer Satisfaction Program 21N12 happened about a week ago in Jan 2025 then the check engine light came on within the week. vehicle odometer is at 82700

The contact owns a 2019 Ford Escape. The stated that upon starting the vehicle, the vehicle made an abnormally loud sound. The contact stated that the failure had increased significantly. The check engine warning light was illuminated. The vehicle was taken to Auto Zone, where it was diagnosed and determined that there was a misfire in cylinder #2. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the engine was making an abnormally loud knocking sound due to coolant intrusion into the engine. The mechanic determined that the engine needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure and informed the contact that a fee would be charged for diagnostic testing. The dealer referred the contact to the NHTSA Hotline for assistance. The manufacturer was notified of the failure. The failure mileage was approximately 126,000.

flex plate cracked/ broke at 65K miles. common problem with this engine. Ford not covering this repair and there is a Campaign #22N12 that covers this repair on several other vehicles with the same engine but the escape not included?

Ford 2.0L Turbo Ecoboost engine coolant infusion issue. The problem is a known issue (TSB 22-2229 for 2.0L). Vehicle is now at the dealership where is was diagnosed after taking in the vehicle for a Check Engine light.

The contact owns a 2019 Ford Escape. The contact stated that while attempting to accelerate from being stopped at a stop sign, the engine revved; however, the vehicle failed to accelerate as intended. There were no warning lights illuminated. The vehicle was towed to the dealer and was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that the repair was not covered under recall or warranty. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 107,972.

Vehicle is my wife’s car. Vehicle lost acceleration during rapid acceleration attempts (freeway on-ramps, etc.). Threw engine light with P0087 code (Low fuel rail pressure). Brought to local dealer to diagnose and was told the diverter valve failed, which caused the water pump to leak and then caused transmission to overheat. The total quote for repairs was over $8,900. None of this made sense. Did a static pressure test for over 45 minutes on coolant system and never lost pressure. That told me the water pump wasn’t leaking. Decided to replace high pressure fuel pump and upon replacing found that the spring on the pump had wore down and punched a hole in the tappet that goes to the camshaft. Replaced high pressure pump, tappet, and fuel manifold from the pump. Pump ($245), fuel manifold ($20), tappet ($10). When purchasing the tappet from the local ford dealer parts store, the employee stated that “they have people come in all the time for these tappets”. After replacing the components, the car runs fine with no issues. I returned to dealer with components and they failed to acknowledge the mid diagnoses of the vehicle and asked that I bring it back in to verify the problem was fixed before refunding the diagnostic fee ($195). Initially I agreed, but after careful consideration I decided not to due to concerns from the initial diagnoses. See attached pictures. Pictures are of new components and old components.

Dashboard message "power steering assist failure - service required" appeared when vehicle was started. It worked fine the day before. We drove it to a local car repair place which advised they did not know what caused the problem and recommended we take it to Ford dealer. We drove it about 30 miles to the Ford dealer, with difficulty since there was no power steering. The dealer says it needs new steering gear (rack and pinion). The cost is about $3000.

TIRE SIZE: 235/50 R18 I was driving on the highway at approx 65 miles per hour in the far left lane when I heard a loud POP and then my car started driving weird. No warning lights came on in my vehicle prior to. I pulled over as soon as I safely could and when I stopped and got out. I realized it was my passenger rear tire that exploded. I called AAA and they put on my spare. The next day I was able to get my vehicle to an NTB. The associate there told me that my front passenger wheel also had side wall damage and that’s likely what caused my passenger tire to pop. He commented that my tread was really good on all my tires so it wasn’t the cause. Because it was two tires that needed changing I was recommended to change all four tires for safety reasons.

I haven't had an issue YET but my mother has the same exact vehicle and Ford's well known issue with the coolant leaking and destroying the engine has happened to her. She is now out $8500 for an issue that they KNOW about and should be recalling and fixing. I am submitting a complaint because I am sure I am next.

The contact owns a 2019 Ford Escape. The contact stated while driving 55 MPH, the check engine warning light illuminated. The vehicle was taken a dealer where it was diagnosed that coolant was leaking into cylinder #2, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and the contact was referred to the NHTSA Hotline for assistance. The contact related the failure to the Customer Satisfaction Program: 21N12 (GTDI Engine – Short Block Replacement After Coolant Intrusion). The failure mileage was 124,000.