2019 FORD ESCAPE Complaints

A fault in the engine block caused a crack allowing coolant to spill into the engine's cylinders. A powertrain fault occurred with loss of power while driving. The problem has been confirmed and inspected by the manufacturer. Misfires occurred intermittently prior to the failure.

While driving once I exited off the highway the rpm gauge was going up and down before I could exit onto a secondary highway. If I would have continued on the highway and loss acceleration I would have been in danger as well as other drivers because I no longer had control of making the car move. All of a sudden, the car started to slow down and when I pressed the accelerator, the car jerked and would not accelerate so as I pulled over. After I pulled over, I could not get the car to move again and the accelerator would not work at all. Had to call a tow truck. Towed to dealership. Dealership called 2 days later to tell us the transmission needed to be replaced.

Coolant is going into the engine. Ford will not replace since it is a known issue and not a recall. I've had to replace cylinder 3 and spark plug since car started jolting down the road and wouldn't go past 30 mph. Constantly adding coolant. It is available for inspection upon request. Safety is a big issue since I have 2 kids that are with me in that vehicle. If the engine fails while I'm driving it puts everyone on the road at risk. Local Ford dealership confirmed with me this issue was coolant intrusion. This issue has been ongoing since June 2024 until present Nov 2024. Messages for engine failure have popped up. Overheating has came about. Misfiring popped up.

Car started having Misfire code around 40,000 miles (September 2023). Spark plugs and coils were changed out twice within a few months of each other. The last technician to replace the coils said it looked like oil was on the spark plugs. Check Engine light still remains on to this day. Around 55,000 miles, noticed coolant was needing to be replaced every other day. Took to Ford Dealership 10/29/24. Video from Technician, shows coolant leaking into engine and stated this is a common problem TSB and we need a new engine ($9,088). Took to local mechanic for second opinion (11/2/24). He found the same issue. Per Ford Dealership, car is out of warranty as of March 2024 (5 year/50,000). This car was purchased used 1/2023 with 26,800 miles. The car hesitates to start. I have to try multiple times to start the car. Called Ford Motor Company 11/06/24 and they stated to file with NHTSA.

The contact owns a 2019 Ford Escape. The contact stated that while driving at approximately 30 MPH, the temperature gauge moved to Hot, and the message "Engine Overheating, Pull Over Safely" was displayed. The check engine warning light illuminated. The contact stated that upon pulling to the side of the road and parking the vehicle, the temperature decreased completely. The vehicle was taken to the dealer, where it was diagnosed that coolant intrusion into an unknown cylinder had caused the engine to fail. The vehicle was not repaired. The manufacturer was made aware of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was 53,000.

- The tire side walls blew out. There are several tears approximately 2-3 inches long. - It happened going about 55 and maintaining control of the car was difficult. My wife was broke down alone in an isolated area. - I took the tire to Twin State Ford in St Johnsbury VT where it was looked at by the service department. He commented that the sidewalls of the other tires were cracking. He confirmed there was a safety recall on the tires for the year make and model that matched my car but he said my VIN number was not included. Ford number 21S10 recall date 2021-03-09 - A few seconds before the tire blew out the low tire light came on. I called the Ford Manufacture Customer service they said my vin number was not included in the recall and gave me a case number [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

In the last six months fourteen of sixteen original equipment lug nuts have had to be replaced because they were "swollen". The dealer was able to do this work but I am concerned for the times when I was not having the vehicle serviced. What if I had had a flat tire and could not change the tire because of this issue? This would put me and the vehicle at risk to find a place of safety to replace the tire.

In some of the affected vehicles the 1.5L EcoBoost engine may exhibit a low coolant level, white exhaust smoke and/or may run in a rough condition with or without an illuminated malfunction indicator light (MIL) with only diagnostic trouble codes (DTCs) P0300, P0301-P0304, P0316, P0217, P1285 and/or P1299 stored in powertrain control module (PCM). This may be due to coolant intrusion into a cylinder bore.

The contact's son owns a 2019 Ford Escape. The contact stated that upon starting the vehicle, the vehicle made an abnormal loud sound. The contact stated that the failure persisted while driving. The vehicle was taken to several independent mechanics. An independent mechanic diagnosed that the flex plate was fractured and needed to be replaced. The vehicle was not repaired. The contact related the failure to Ford Campaign Number: SSM48725. An unknown dealer was notified of the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 87,000.

The contact owns a 2019 Ford Escape. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the engine block had failed, causing coolant intrusion into the cylinders. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The contact was advised to file a complaint with the NHTSA Hotline. The failure mileage was approximately 110,000.