2020 FORD ESCAPE Complaints

The driver's side door started making loud cracking noises when opening and closing

The primary component that failed is the turbocharger system, which has malfunctioned five times since October 2024. Additional failures include the catalytic converter, and there is now suspected motor damage. These components are currently in possession of the dealership and are available for inspection upon request. The safety of myself and my children was repeatedly put at risk. The first turbocharger failure left us stranded in early morning traffic, with no engine power and limited ability to exit the roadway safely. Subsequent failures occurred within 24 hours of service completion. These breakdowns created dangerous roadside conditions, especially during high-traffic hours and in areas without safe pull-off zones. The problem has been reproduced and confirmed multiple times by the dealership’s service department. Each turbocharger replacement has failed within days, and the vehicle is currently awaiting its fifth turbocharger in two months. The dealership has also confirmed damage to the catalytic converter and now suspects motor damage. The vehicle has been inspected repeatedly by the dealership, which is in contact with Ford Motor Company. However, Ford has not provided a permanent solution or acknowledged the root cause. No inspections have been conducted by police or insurance representatives at this time. Prior to second breakdown; the FordPass app displayed an oil life warning at 0%, which was reportedly reset by the service department, raising concerns about system accuracy. The vehicle has also triggered diagnostic codes P0420 (Catalyst System Efficiency Below Threshold) and P0234 (Turbocharger Overboost Condition), both of which are consistent with the mechanical failures observed. Additionally, Manufacturer Recall 25S76 was acknowledged, but when asked whether the fuel injectors had been inspected, the technician stated they would only be replaced if a fuel leak or smell was present. This reactive approach contradicts the intent of the recall.

Car has self started in my garage 3 times in the last two weeks, just now it did it again. This is very dangerous, could hurd someone or burn my house down. This needs to be looked into.

.After activating the cruise control on the freeway for a few minutes, the cruise control deactivated and displayed the "Adaptive Cruise Not Available" message on the dashboard, immediately lowering the speed. Additionally, the sunroof interior stopped working after opening it. The bar that helps retract the sunroof interior came loose, and Ford says the repair is not covered under the extended warranty. There was also a problem with the rear seat belts, which displayed a warning: "REAR BELT MONITOR FAULT. SERVICE REQUIRED."

EVERY TIME I TRIED TO PUT GAS IN THE CAR IT WILL NOT START AND THE STEERING WHEEL LOCKS

Powertrain control module failure causing vehicle to lose power and engine to run at 5 to 6 RPMs. and transmission not shifting properly. Vehicle is going into limp mode and will also shut down while driving but the engine stays running and the cruise does not shut off. There is not remedy for the recall that I believe is causing these issues. This has been going on for 6 month. This vehicle has been nothing but a problem.

Purchased certified vehicle from Wray Ford on 2/23/24. Car was previously leased by FMCC and still listed as a Ford Fleet Vehicle in Michigan as of 9/12/25. VIN confirms it falls under Ford safety recall 24S79, which was never performed. Vehicle experienced unintended acceleration and non-responsive braking, behaving autonomously. FordPass Connect, FMCC, and Wray Ford all confirmed it was unsafe to drive based on 38 diagnostic codes from July/August 2025. June 2025 data and other dates were blacked out. No warning lights or alerts appeared in the FordPass app prior to the crash on 8/25/25.Allstate Insurance removed the vehicle from Wray Ford without authorization, falsely claimed a $10,000 salvage offer, and altered the accident date in the online portal. Damage estimates were manipulated: initial $4,500 based on five photos, later inflated to $13,195 using the same photos. Shreve Collision’s manager confirmed no estimate was performed, contradicting Allstate’s claims. Allstate appears to be shielding Ford from liability. The vehicle is no longer in my possession, but documentation and diagnostic records are preserved. I believe Ford concealed a critical defect and suppressed diagnostic data, putting my safety and others at serious risk.I have contacted FORD and they are stalling and have misrepresented to me many things. They admitted that they can access FORDPASS CONNECT DATA remotely and their agent stated driving this vehicle is not an option. I have almost been involved in prior accidents because of hidden defect in my car. My son has audio recordings, transcripts, Ford Pass Connect Data. We believe Allstate changed the date of the accident to throw off a forensic examinator. I have proof of Allstate changing the accident date and removing documents. This is really a serious breach by Allstate and Ford. I am 80 years old, and if it was not for my son I would have never known this and my son is half owner of the car and is very concerned for my safety.

My tire sensors keep going out. I've replace them twice already. It's a concern for my especially traveling at highway speed

My car togs a lot. My tire sensors keep going out. I've smelt gas before while driving. It's very slow going up hill. I hear grinding sounds intermittently

I have a moon roof with a canopy covering it, when you open the moon roof the canopy retracts also, my canopy retracts but came apart from the tracks on each side which causes the canopy to drop down and block the rear view mirror, which is definitely a safety hazard. I contacted Ford and no recall or TSB is available . I'm not the only one with this problem, this could cause a serious accident not being able to see behind you blocking your view.Ford has a case # that I reported to them the problem # [XXX] REFERENCE THIS PROBLEM INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)