2020 FORD ESCAPE Complaints

All the TPMS sensors have had to be replaced on the Escape with under 51K miles on them. The Ford Dealer admitted this is a serious Safety issue and have had numerous complaints.

The contact owns a 2020 Ford Escape. The contact stated that the driver’s side front door made a popping sound whenever the door was left in certain positions while open. The vehicle was taken to a certified mechanic, who diagnosed a possible issue with the welding. The vehicle was taken to a body shop, which inspected the door and diagnosed that the spot welds had fractured on the door check hinge. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 70,000.

The contact owns a 2020 Ford Escape. The contact stated that since owning the vehicle, the front driver’s side door was replaced by the dealer after the door failed to open. Additionally, the contact stated that while driving 25 MPH and attempting to make a left turn, the vehicle failed to respond as intended, continued driving straightforward and nearly drove off the road into a wooded area. The vehicle was taken back to the dealer, where a wheel alignment was performed. Additionally, the contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the check engine warning light was illuminated and related the warning light to the recall. The vehicle was taken to the dealer, where it was diagnosed that the purge valve had failed, and the purge valve was replaced. The contact was also informed that the fuel injectors were in good condition, and that the vehicle was safe to drive. The recall repair was not performed. The manufacturer was notified of the failure, but no assistance was offered. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was 69,527.

A module is causing communication issues in the car between its and the key fob causing the car not to be able to start at all. It has been at the Ford dealer [XXX] for over a month now and they are unable to remedy the situation. They claim they can’t update the software or can’t find out what’s wrong with the car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2020 Ford Escape Hybrid experiences complete electrical failure - battery saving mode followed by total power loss. Ford has published Technical Service Bulletins SSM 49990 (NHTSA ID: MC-10199655-0001) and SSM 49574 (NHTSA ID: MC-10187983-0001) addressing this exact issue through ABS module programming. However, both my local Ford dealership and Ford Customer Service claim these documented TSBs do not exist in their systems. This appears to be systematic denial of safety-related warranty repairs for a known defect. According to my research, some of Ford owners could receive a 8 year Hybrid component warranty through these TSBs. It seems to be a typical pattern for Ford to avoid warranty procedures by denying TSBs. I have records of the calls. I cannnot upload it from this page

The contact owns a 2020 Ford Escape. The contact stated that while driving at an undisclosed speed and opening the sunroof, the interior sunshade was opened, but the sunshade failed to close as intended and remained stuck open. The vehicle was diagnosed by a Ford mechanic, who informed the contact that the sunshade sealant had deteriorated. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 24,000.

obd communication with emissions and state safety inspection. Ford knows -- will not fix under recall

All kinds of warning lights come in and stay on, which a lot of people are having the same issue which is due to a faulty sensor module.. I almost hit a truck who pulled out of a parking lot once I was on top of him ( was trucks fault) and no warning lights were functioning properly. There's also a recall for a fuel injector issue that ford is taking their sweet time to remedy, but technically I'm driving a time bomb that st any moment this fuel injection issue could crack and leak and cause a fire. And I'm not about to lose my life because of it. I've contacted ford for a lemon law buyback and they are taking their sweet time in that. No warning lights are functioning properly causing a danger for me to drive it. But I have to have a reliable care to get to dr appts and to shop for groceries. Something has got to be done about this. And further more when I purchased this car used I questioned the salesperson at the used car lot about this recall paper that was in the glove compartment about the recall on the fuel injection. He told me it was nothing. Bull!!! Why have that paper in the car if there wasn't a recall for the fuel injection when I bought it back in July 2023. No dealership should have the right to sell any car with a recall already in place. I want to sue the used car dealership for selling me this lemon. The car dealership was key auto of Somersworth nh but now they have a new place in Rochester nh...they should be held accountable for selling me the vehicle with a recall already in place. Ford said recall didn't go into effect till 2025, but why have a document in the car about it when I purchased car in 2023. Makes no sense.

AWD FAULT, PRE-COLLISION ASSIST AND HILL START ASSIST WARNINGS DISPLAYING IN CLUSTER.

Driving from Michigan to Missouri [XXX] and the wipers stopped working once we got to Missouri. Called Ford dealership in Springfield and they could not fit us in their schedule, so we took it to a Goodyear certified service center and they said it was the wiper motor. we fixed and eventually drove back to Michigan. About1 week later, the windshield wipers again, stopped working, I called the shop in Springfield and they told me to take it to a shop in Westland Michigan (Redford Auto/Goodyear Certified) because the part was under warranty. I did that, they replaced the part (motor). Now a year later and my wipers are not working again. They stop midstream and get stuck. They are inoperable again. Never in my lifetime of driving (I am [XXX] ) have I ever repaired a wiper motor, let alone 2 x and the problem is still not fixed. I do believe this is faulty by manufacturer and needs to be looked into. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)