2020 FORD ESCAPE Complaints

The contact’s daughter owns a 2020 Ford Escape. The contact stated that while her daughter was driving on several occasions at various speeds, she observed abnormal sounds coming from the engine compartment before the vehicle lost power. The vehicle was taken to a dealer where it a diagnosed that the turbo was inoperable and needed to be replaced. The vehicle was repaired, but the check engine warning light illuminated approximately 10 days later. The vehicle was taken back to the same dealer, where it was diagnosed and determined that a gasket needed to be replaced. The vehicle was repaired, but a week later, the check engine warning light illuminated. The manufacturer was notified of the failure. The failure mileage was 90,181.

The contact owns a 2020 Ford Escape. The contact stated that while driving at various speeds, the "All Wheel Drive fault - Service Required", "Hill start not available", and "Pre-Collision assist not available" messages were displayed. The vehicle was taken to a local dealer, where it was diagnosed and determined that an undisclosed module needed to be updated and the battery replaced. The vehicle was repaired out-of-pocket; however, the "All Wheel Drive fault - Service Required" message was displayed again. Upon further investigation, the contact related the failure to an unidentified recall; however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 72,000.

From the day I purchased the car, it has not been able to connect to the Commonwealth of MA's inspection computer system. Ford and the inspection garages i've taken this to said it was a known problem and waived the inspection until Ford remedied their software to make it work. Ford now has a fix, applied via a software update, that remedies the problem but says my car is not part of the list of covered vehicles even though they acknowledge it suffers from the same problem. Ford sent a letter out on Dec 12, 2023 entitled "Customer Satisfaction Program 22N15" which states that they will repair the problem at no cost to the original, or subsequent owners of the car. I've asked Ford to acknowledge that my car should have been included in that program and they refuse to do so, instead, asking me to contact the NTSB. The only way I can have my car inspected now is to use a 'hack' recommended to me by a sympathetic Ford dealership which is to have them turn my car off for an hour after I arrive and then do the inspection. This is clearly a workaround and I want Ford to apply the software fix to my car.

The vehicle has 27,500 miles on it. Based on what the dealership repair group mentioned, there is an issue with Pa. Purge valve. The part # is #FO LX6Z-9D289-SH TUBE ASY - FUEL VAPO. Since the car has such a low mileage, this repair should be covered under the warrantee.

I was driving to work like normal this morning when an error message popped up that stated my All Wheel Drive had been turned off. It then gave another error message stating my hill parking assist had been turned off, and my cruise control is no longer functioning. Due to this I feel unsafe driving. This has happened to many other friends and family members that have owned this vehicle.

The contact owns a 2020 Ford Escape. The contact stated that while driving at various speeds, there was an abnormal knocking sound coming from underneath the rear of the vehicle. No warning light was illuminated. The vehicle was taken to a local Pep Boys; however, the cause of the failure was not identified. The contact stated that after the attempted diagnostic test, while driving at undisclosed speeds, the vehicle independently swerved in various directions and hesitated while accelerating with the accelerator pedal depressed. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 78,000.

Lugnuts are swollen and a flat had occurred and I couldn't remove the wheel was almost hit by on coming traffic finally gave up replenished air into tire and drove Home . Took car into Ford dealership they said all of the Lugnuts swell on newer models not just mine I asked for a replacement quote it's 300 for new Lugnuts and then labor too and hopefully they won't break a wheel removing them I said if I agreed would they replace them with the same defective Lugnuts that swell and his answer was yes .Please do something about thease dangerous swelling Lugnuts before someone's life is taken. I told the dealership not to do the replacement and done some research I can get a replacement set for entire car for 40 bucks at Autozone and called my local mechanic and they said 50 bucks to replace all of them and autozone told me thease are standard non swelling steel Lugnuts .My faith in Ford has definitely changed to zero.

My drivers door started 2days ago, April 11, 2025 to make loud cracking noise when opening and closing out of no where. Then on April 12 while out running errands the door became detached. After several attempts to close I was able to close it but I'm having to get in and out from passenger side.

Ford had issued a customer satisfaction program recall on 2020 and 2021 Escape doors. On my 2020 escape se the driver side spot welds on the door attachment point are failing. The door no longer opens all the way and causing a loud popping sound when in use. My driver window no longer goes up or down as a result of the loose arm inside the door. My dealership ordered the door replacement back in January and no doors have been shipped by ford and no response is being given to the dealers as to an estimated time of delivery or notice there is a shortage. I contacted Ford Customer Service and was told my case has been escalated for faster resolution at the start of March and to expect a phone call about the case. I have heard nothing from Ford since and my dealer is at a loss of what to do because they have multiple customers in the same situation. I’m paying $550 a month for this vehicle and I’m struggling to get into it.

When outdoor temperatures are above 85 degrees, the interior of the vehicle becomes warm enough that the vehicle may not shift out of Park. Our most recent experience was while on vacation in Florida last week. The outdoor temperature was around 90 degrees, though likely warmer in the parking lot. The vehicle was parked on a flat surface facing the sun, wheels facing forward, no reflector in the windshield, windows closed. When starting the engine, vehicle started normally, all functions appeared normal, but could not shift out of Park. Tried rocking the vehicle back and forth, turning the wheel, brake lights functioned, no movement of the shifter- as though the round shifter of the vehicle was electronically locked. This does not seem like a safety issue, but my wife is [XXX] and could have happened in a location where she would not have help available. Forums on the Intrnet have multiple complaints. Ford told me that they do not know of an "issue" but did find that my car was misbuilt - the cable coming off of this switch is a two part cable, at least two different cable sets were used in the manufacture of the 2020 Escape. My vehicle used the A part of one set and the B part of a different set. Ford gave replacement parts for free, I paid $600 for diagnostics and labor. Latest incident happened after the correct cable set was installed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)