2020 FORD ESCAPE Complaints

My car says that collision assist, All wheel drive is unavailable and is locked to front wheel drive only.

Dashboard light with wrench icon and message AWD Fault Service Required appeared, along with multiple other alerts including Service AdvanceTrac, Pre-Collision Assist Disabled, Hill Start Assist Not Available. Could feel handling of vehicle had changed, no other indications of issue. Upon inspection at dealership, it was determined AWD Control Module needed to be replaced. Dealership noted this had been an issue with multiple other 2020 Ford Escapes. Repair not covered under Powertrain Warranty, despite the fact that malfunction of this module can cause loss of power distribution to the wheels. While there had been a Customer Satisfaction Program notice issued for select 2020 Ford Escapes (21B19, issued April 9, 2021 and expiring April 2022), my VIN was not included.

The contact owns a 2020 Ford Escape. The contact stated while driving 65 MPH on the highway, the vehicle decelerated unintendedly. Several unknown warning lights were illuminated. The contact stated that after driving a short distance and depressing the accelerator pedal, the vehicle responded as needed. The vehicle was driven to the intended destination. The contact stated that the incident was significantly frightening. An unknown dealer was made aware of the failure. The vehicle was not diagnosed or repaired. The contact referenced recall NHTSA Campaign Number: 23V380000(Engine); however, the VIN was not associated with the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 37,400.

A 2020 Ford Escape that was purchased in new condition in September of 2020. The vehicle has had numerous issues with transmission failure as well as the failure of other engine/transmission components causing drivability and safety issues such as hard shifting, not shifting, and not accelerating properly. I was not informed of Ford's buyback program until August 28, 2024, when a friend who had previously experienced similar issues with a Ford vehicle alerted me to its existence. She assisted me in contacting Ford Consumer Affairs and initiating a buyback request (case #[XXX]). On October 20, 2024 we called Ford Motor Corp Consumer Affairs to follow up on the case and they advised the application for buyback was denied since it had not been submitted within the 30 month period as outlined in Texas Lemon Law. We were advised that the only way I could seek remedy was via BBB complaint. I need assistance to advocate for my consumer rights related to Lemon Law and Magnuson-Moss Warranty Act. It is my belief that Ford Motor Corp has repeatedly failed to perform their due diligence with regard to the transmission, engine, and other components installed in my vehicle. June 3, 2022 - Vehicle taken to Bob Tomes Ford service department. Diagnosed transmission failure and the transmission was replaced at 14,158 miles. I received the vehicle back on July 2, 2022. August 2, 2022 - Vehicle taken to Bob Tomes Ford service department for shifting/drivability issues and failed communications of OBD system. Vehicle had 14,557 miles and I received it back on August 29, 2022. April 21, 2023 - Vehicle taken to Bob Tomes Ford service department for check engine light at 18,554 miles. I received the vehicle back on May 22, 2023. August 6, 2024 - Vehicle taken to Bob Tomes Ford service department for hard shifting and drivability issues at 20,281 miles and as of November 4, 2024 the vehicle is still in the service department. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

All Wheel Drive (AWD) triggered a fault and stopped functioning while drive, resulting in loss of traction and wheel slippage in slippery conditions. Ford dealership diagnosed a faulty AWD module and admitted this is a very common problem with all 2020 Ford Escapes but that it is NOT covered under warranty. Ford is well aware of these issues with their AWD modules but has so far refused to initiate a recall of their know-faulty AWD modules.

Ford Escape Titanium 2020 purchased 8/2020. Transmission issues began 5/21/21. Car slowed on highway with gas pedal pushed to the ground then surged and lunged. Several warning lights and I had it towed to a dealership. BCE module reprogram. car continued lunging, surging as well as shuddering. Stopped in several times to be told nothing wrong, no recalls, couldn't replicate. 4/19/2023 car still surging , esp at speeds of 30-50mph or less. Dealership found no issue. 6/20/238/2023 wrench light along with surging at or below 50mph. Couldn't replicate. 8/23/2023 insisted Mechanic drive with me. Issue noted immediately! Had car 2 months. dealer contacted Ford - no recall but engineers getting similar reports. Replaced spark plugs and transfer case control. Did not fix issue.12/5/23 post inspection told rear shocks wearing out (36,000 miles). 2/5/24 surging 20-40 mph and Check Engine light on. Dealer replaced/purge vapor management valve and cannister purge valves. Continued to express safety concerns. 2/23/24 car speed slowed from 70 to 10 mph on highway and was surging going up ramps. Insisted transmission techs and manager ride with me and immediately registered issues. Asked them to check Driver side door due to problems reported online. told no recall. Complete transmission overhaul (NOT REPLACED) and returned 3/25/24. On 4/11 driver door started making noises. Scheduled 4/19 service on 4/16 was unable to shut car door and had towed to dealership. Door recall that day. Dealer had car from 4/16 through 7/11 to replace doors and rear shocks. Service department initiated buyback. Ford denied and will not provide written reason. I Called Ford customer service and with permission recorded call with rep and then her manager who would not forward my call to another department and told me my only recourse was to file a complaint with the BBB. Car still shuddering and surging. So was loaner car- dealer and mechanic insinuated it may be "characteristic" of model!!!!

Front drivers side door makes loud popping sound when opening or closing. Now it doesn't shut completely. One of the spot welds near the door check has torn through the metal frame, and is causing the window to not roll up or down. When driving over any small bump or uneven road, door cracks loudly, and twice has popped open in transit, then would not close until I pulled over, stopped, and manhandled the door to a close.

The engine failed and the symptoms were all the coolant was gone, hot indicator, large amounts amounts of smoke coming out of exhaust and a burning smell. Once coolant added, ck engine light came on with codes P300 and P301 (I think). The vehicle was under warranty and has been fixed with a new engine by dealer. The warranty company did inspect car before being fixed. Initially the only problem that was noticed was hesitation when increasing speed. Once on the highway the overheating light came on and was able to exit off highway before it stalled out. Was able to restart car and drive to gas station where I added 2 gal of coolant and slowly drove a short way to home. The dealership would not tell me the exact problem but just said all the fluids went into the engine and the engine needed to be replaced. Other mechanic friends said it was a cracked head gasket.

The shade retraction on the moonroof is malfunctioning, causing the fabric to not retract completely, the sagging fabric is causing visibility obstruction. My Ford dealership have inspected the issue and have quoted me an approximate price of $1700 to fix the issue, which is currently cost prohibitive for me ($400 for the replacement part + approx 6 hours of labor), unfortunately this will not be covered by my warranty. There were no warning messages prior to failure, I pressed the button to open my moonroof one day and this happened, if I was driving this would have caused an accident because my visibility of rear view is blocked, luckily I was parked when I discovered this issue. This issue first appeared in June 2024. I went to the dealership in July 2024, because it was cost prohibitive to fix I have not used the moonroof since then because it affects visibility.

The contact owns a 2020 Ford Escape. The contact stated while driving at an undisclosed speed, the AWD (All Wheel Drive) fault warning light and several unknown warning lights illuminated. The vehicle was taken to the dealer where it was diagnosed with a failed AWD module. The contact was informed that the AWD module needed to be replaced. The vehicle was currently being repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 57,000.