2020 FORD ESCAPE Complaints

Initially driver side door began sluggishly opening proceeding to a grinding open which and finally incomplete opening. Power window has also become inoperable. Dealer charged $400 to look at what is obviously a known problem and said needed a brand new door and quoted $3,000+ (10% of a new car!) Refused service and a mechanic explained the situation regarding the welding failure and said he "opted" to not attempt to re-install the door check, meaning the door now will fly wide open if not perfectly controlled (which will obviously result in damage to hinge system. We found our car with several hilarious flyers printed (attached below) showing the full awareness of the issue.Our escape is a fully loaded Titanium model and issue began developing at about 49,000 miles. Car has never been in a crash of any kind and has 50,000 miles the VAST majority being 300 mile round trips on the highway for work.

The driver door is trying to fall off. When I open it, it makes a loud creaking noise and then comes loose. When I try to shut it, it’s not lined up and won’t shut correctly and completely. This issue started almost immediately after purchasing it in July 2023. I brought it to the Ford dealership and it sat there for over a month before they looked at it. They never did give me an official diagnosis or estimate although I asked several times. I have been driving around like this for months.

The driver's side door has been making creaking and popping sounds for over a year and most recently the driver's side door window only goes down half way. Took the vehicle to the Ford dealership where the car was purchased and informed them of the problem and the SSM 50150 for 2020-2021 Escapes. After inspecting the interior of the door, they found that the check arm had detached and that what was causing the noise and the window to not be able to lower. The vehicle has 29,347 and was purchased in May 2020. They said the vehicle is out of warranty on the date (not mileage) and would not be covered although it's apparent the failure was occurring over several months.

The contact owns a 2020 Ford Escape. The contact stated that the passenger’s side door check spot welds had failed, and the door would not properly open or close. The vehicle was taken to the local dealer who determined that the door needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 28,000.

I OWN A 2020 FORD ESCAPE. The Driver's Front Door started making a loud popping sound when opened and then it wouldn't close all of the way. It was hard to close but finally did. It kept making the popping noise louder every time it was opened and shut. Then, the Driver's Front Window failed to go down more than an inch and a half to two inches. It wouldn't roll up every time it was rolled down the couple of inches either. I took it to Mike White Ford Dealership in Coeur d'Alene, ID where I was informed that the welds on the control arm of the Driver's Door had failed and broken so the car needed to go to a body shop to be repaired. The dealership said that none of this is covered by my warranties.

The contact owns a 2022 Ford Escape. The contact stated that the driver's side door spot weld was fractured. The contact stated that the door was difficult to close. The driver's side window also failed to open as needed. There were no warning lights illuminated. The local dealer was contacted, and the vehicle was diagnosed, and it was determined that the hinge and door weld had failed. The mechanic recommended replacing the door. The manufacturer was contacted, and the contact was informed that the warranty had expired. No assistance was provided. The failure mileage was approximately 33,000.

The passenger door start making a creaking/popping sound. Within the last week, it started to get louder and louder because the spot weld around the door check arm had completely broken. I took it to the dealership I purchased it from and ford denied assistance with my issue. They recommended I pay a body shop to fix it.

Ford Escape’s Door Hinges are Defective: Our 2020 Ford Escape driver door hinges had to be repaired by a non-Ford dealer body shop as the car was out of warranty. The Columbus, Georgia Ford dealer diagnosed the problem as being defective door hinges but they do not do body work. The door's rivets popped out and the hinges made grinding and popping sounds when opened or closed. There were no warning lamps or messages about the failure before it occurred. We would appreciate it if the NHTSA would issue a formal recall for this defect so we could be reimbursed for what we paid. Thank you very much.

my driver side door hinge randomly began making snapping noises and then the door no longer functioned properly. There are times when I cannot close my door fully so I must drive with the door partially opened. The issue also affects the window. I cannot roll my window down.

Like many others, the spot welds gave way on my drivers door. It affects window operation and the door sounds terrible when opening and closing. I called ford and they told me to have the concern verified at my next service visit. They need to issue a recall for this ASAP.