2020 FORD ESCAPE Complaints

Driver door makes a loud popping noise. Did look into the manufacturer defect where the spot welds do not hold the door hinge

Parked my Escape in the garage on Thursday evening, December 14, 2023. Everything was ok. Opened the driver door Friday morning, December 15, 2023 and it made a funny creaking noise and felt draggy, didn't open smoothly. The noise continued each time I opened the door and seemed to get worse. On Tuesday morning, December 19th I took my vehicle to a Ford dealership to see what the problem was. They opened and looked at my door and said the hinge welds were breaking. They had seen about 5 or 6 Escapes in the last 2 weeks with the same problem. Said the door would have to be replaced - they would check into it and get back with me. My vehicle has 51,000 miles on it, so it is not covered by warranty. It is December 21st and I have not heard back from them and they have not responded to my text or phone calls. I am [XXX] and have taken good care of my vehicle. It has not been in any accidents, so I find it hard to believe that the door welds wear out after 51,000 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Nothing has yet happened, however, Ford sent a recall notice regarding premature engine failure in May 2023. The recall (NHTSA recall 23V380) stated that they anticipated a solution by October 2023, but they have no solution still. I don't know what the nature of the defect is, but I did not anticipate waiting more than 8 months for a solution on something that could cause the engine to set on fire. This vehicle is a daily driver for us, and we'd like to take it on a road trip this summer, but the combination of heat and unknown engine risk makes me not want to risk it.

The contact owns a 2020 Ford Escape. The contact stated that while the vehicle was parked, the contact opened the front driver’s side door and heard an abnormal clicking sound. The contact stated the vehicle was taken to the dealer where it was diagnosed with fractured door spot welds. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 29,500.

The contact owns a 2020 Ford Escape. The contact stated that while opening the front driver's side door, the door made an abnormally loud popping sound. Upon inspecting the door, the contact noticed that three spot welds on the check arm bracket had fractured. Additionally, the door failed to close securely. The dealer was not notified of the failure. The vehicle was not repaired. The contact related the failure to NHTSA Action Number: PE23013 (Structure). The manufacturer was notified of the failure and a case was opened. The failure mileage was 73,820.

PASSENGER FRONT DOOR CHECK HAS CRACKED & IS NOT OPERABLE THERE WAS CONSISTENT "POPPING" SOUNDS FOR SOME TIME PRIOR. HE DEALER INSPECTED AND SAW BROKEN DOOR WELDS. HE INDICATED AT LEAST 3 SAME COMPLAINTS HAS BEEN MADE .THE REPAIR ESTIMATE WAS FOR 2200.00 IF I HAD TO PAY FOR IT THE DEALER SENT A CLAIM TO FORD REQUESTING THAT THEY TAKE CARE OF THE REPAIR I AM WAITING FOR THEIR RESPONSE

Door check bracket. Door randomly started making clunking noises, and middle hinge seems wobbly and unstable.

My drivers door will only open about 6 inches. I have to crawl across the console to drive. I took it to ford dealer who said it was a ford issue but I was a few months beyond my 36 month warrenty so it wasn't covered. He also said not to roll down the window or it might shatter.

While driving the car on a busy fast-flowing road the message "Stop Safely Now" appeared on the dashboard. The car lost power and could only be driven at 20 mph and would not speed up. I pulled over and when I stopped but did not power off, the car would not start moving again. After turning the car off for five minutes it drove again properly with no issue. This is the second time this has happened in two months.

Driver's side front door: hinges are not working properly. Initially, the door made three cracking noises when I opened the door on Tuesday, December 12, 2023. I called my Ford dealer (AutonationFord, Scottsdale, AZ) on Wednesday to speak to my Ford Service Advisor Kevin Morgan. He was not at work Wednesday or Thursday but I obtained an appointment for Monday, 12/18/23 at 9:30 AM. On Saturday, 12/16, I rolled the driver's side window down, it took me 5 minutes to get it back up. Of course I had to leave my car on Monday. But my Ford dealer does not offer "loaners" or offer to pay for a rental car. So I borrowed a car from a friend. On Tuesday 12/19, I received a call from Kevin that they could not fix the hinge(s) because they were improperly welded at the factory. Furthermore, they returned my car to my home with instructions to take it to Bell Ford (Phoenix) Body Shop. On Wednesday 12/20, I drove my car to Bell Ford, and they made an appointment for me to drop it off on Wednesday 12/27. They provided me with a loaner car. I thought I would be picking my car up Friday 12/29. I received a call from Will Jones, Mgr. of the Body Shop on Thursday 12/27 that window regulators had been discontinued by Ford but they had found another one and would get it Wednesday, 1/03. So I should get my Ford Escape back on Thursday 1/04, I hope. Now the problem is Ford has not recalled this problem and it's not just my car but other 2020 and 2021 Escapes have the same problem with the driver's side door. I don't know about the window but obviously it "broke" because of the broken hinges. Help! Please get Ford to recall cars with door problems. I should not have to pay for this repair. Thank you for your help!!!! [XXX] (mileage 35,750 but 3 years was up August 2023. To me, this is not a warranty issue.) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)