2001 FORD EXCURSION Complaints

FACTORY PAINT PEELING. STARTED ON HOOD AND DOOR JAMBS, NOW ON ROOF. I CANNOT BELIEVE A GOVERNMENT AGENCY WOULD ALLOW PAINT TO PEEL AND CONTAMINATE IN THE ENVIRONMENT. *TR

TL* THE CONTACT OWNS A 2001 FORD EXCURSION. WHILE DRIVING AT AN UNKNOWN SPEED, THE EXTERIOR LIGHTS FAILED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V352000 (EXTERIOR LIGHTING). THE FAILURE MILEAGE WAS 198,000.

THE SPARK PLUG BLEW OUT OF THE ENGINE. THIS CAUSES DAMAGE TO THE HEAD AND BLOW THE IGNITION COIL TO BITS. AFTER LOOKING ONLINE THIS APPEARS TO BE A VERY COMMON PROBLEM. *TR

ON SEPT. 29,2014I APPROACHED STOP LIGHT AND APPLIED BRAKES, ENGINE RPM INCREASED VERY HIGH AND BRAKES WOULD NOT HOLD VEHICLE - HAD TO PUT IT IN NEUTRAL AND ENGINE RPM CONTINUE TO GO HIGHER - THIS LASTED FOR ABOUT 10 SECONDS BEFORE ENGINE WENT BACK TO IDLE SPEED THEN WE PROCEEDED HOME WITH NO MORE PROBLEMS. THIS HAS DONE THIS SEVERAL TIMES BEFORE AND EACH TIME BRAKES WOULD NOT HOLD VEHICLE BACK. I TOOK IT TO FORD IN 2013 AND EXPLAINED IT TO THEM AND THEY SAID TO PUT GAS STABILIZER IN TANK AS THE GAS IN TANK WAS CONDENSING AND CAUSING THE COMPUTER TO MALFUNCTION. I PUT THE GAS STABILIZER IN THINKING THIS WOULD TAKE CARE OF IT BUT THIS TIME , SEPT. 29,2014 AND THE TIME BEFORE, JUNE 2014 - IT REV UP SLIGHTLY , IT COULD NOT BE THE CASE THESE LAST TWO TIMES AS I HAD JUST PUT FRESH GAS IN IT. IT IS VERY SCARY IT COULD HAVE CAUSED A BAD ACCIDENT. NOW I AM AFRAID TO DRIVE IT. I AM GOING TO CALL FORD AND SEE WHAT THEY HAVE TO SAY THIS TIME. *TR

TL* THE CONTACT OWNS A 2001 FORD EXCURSION. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, IT ROLLED AWAY INDEPENDENTLY WITHOUT THE ENGINE STARTED. THE VEHICLE CRASHED INTO A RESIDENTIAL MAILBOX AND A MOBILE TRAILER. THE CONTACT'S RIGHT LEG AND LEFT ANKLE WERE INJURED WHILE ATTEMPTING TO STOP THE VEHICLE, AND MEDICAL ATTENTION WAS RECEIVED. A POLICE REPORT WAS FILED. AN INDEPENDENT MECHANIC STATED THAT THE REAR DRIVER SIDE PANEL AND ROOF NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 150,000.

DRIVER SEAT BELT UNLATCHES ON OCCASION AFTER BEING FULLY ENGAGED. SIMILAR TO THE SITUATION THAT RESULTED IN A RECALL IN 2001. WE DID TAKE THE VEHICLE AT THAT TIME FOR THE RECALL. *TR

TL* THE CONTACT OWNS A 2001 FORD EXCURSION. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE HEATED SEAT WARMER OVERHEATED WITHOUT WARNING. THE CONTACT MENTIONED THAT THE WIRES BURNED THROUGH THE SEAT CUSHION, EMITTING SMOKE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE HEATED SEAT ELEMENT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 140,000.

THE APPROXIMATE DATE ABOVE IS THE FIRST TIME MY EXCURSION BLEW OUT A SPARK PLUG WHILE ON A FAMILY TRIP IN PA. SINCE THEN, IT HAS BLOWN 2 MORE IN SEPARATE INSTANCES, THE MOST RECENT BEING ON THE HIGHWAY THIS PAST SUNDAY. THE FIRST INCIDENT I WAS TOWING AND PUTTING MORE STRAIN ON THE ENGINE, BUT THE 2ND AND 3RD INCIDENTS NO TOWING WAS INVOLVED. I HAVE READ ABOUT AND SEVERAL MECHANICS HAVE ALSO TOLD ME THE FORD TRITON ENGINES ARE KNOWN FOR THIS PROBLEM. IT SEEMS FORD SHOULD DO THE RIGHT THING AND FIX THE PROBLEM. *TR

SPARK PLUG BLEW OUT OF ENGINE. POSSIBLE DEFECT IN CASTING..?? WAS TOLD THIS IS NOT UNCOMMON BUT FORD REFUSED TO COVER THEIR KNOWN DEFECT. COST ME OVER $6,000 TO REPLACE ENGINE. *TR

THE WINDSHIELD ON MY EXCURSION CRACKED ALONG THE BOTTOM FROM THE HEAT AND COLD ABOUT 3'' UP ALONG THE WHOLE LENGTH OF THE WINDSHIELD. THIS HAPPENED TO MY SONS 2001 F250 SAME WAY. THERE WAS NO REASON AS NOTHING HIT THE WINDOW. *TR