2015 FORD EXPEDITION Complaints

WHEN PULLING OUT INTO HEAVY TRAFFIC ON A DIVIDED FOUR LANE ROAD, THE VEHICLE SUDDENLY LOST POWER AND WENT INTO LIMP MODE ALMOST CAUSING A SERIOUS ACCIDENT. THE CHECK ENGINE LIGHT CAME ON AND THE CODE WAS LATER TO BE DETERMINED P2112 THROTTLE ACTUATOR A CONTROL SYSTEM STUCK CLOSED. AFTER RESEARCHING THE ISSUE IT WAS APPARENT THAT THE FORD 3.5 ECOBOOST MOTOR HAS QUITE A HISTORY OF THESE TYPE FAILURES. OFTEN DRIVER SAFETY IS COMPROMISED AS THE VEHICLE SUDDENLY AND WITHOUT WARNING WILL LOSE POWER JUST WHEN YOU NEED IT. THE FIX IS TO INSTALL A NEW THROTTLE BODY WITH ELECTRONIC ACTUATOR.

2015 EXPEDITION 3.5 ECOBOOST STALLS OUT WHILE DRIVING DUE TO DEFECTIVE THROTTLE BODY (CODE P2112). THIS SHOULD BE A SAFETY RECALL.

CAR IN MOTION, HESITATES AND SOMETIME GOES TO LOW POWER MODE WHERE YOU HAVE TO PULL OVER, TURN CAR OFF WAIT AND RESTART TO BE ABLE TO CONTINUE THIS HAS HAPPENED 3 TIMES IN 2 YEARS, DEALERSHIP DECODES AND REPLACE THE THROTTLE BODY, CHARGING EACH TIME TO FIX THE ISSUE

OUR VEHICLE EXPERIENCED TOTAL FAILURE OF THE BREAK MASTER CYLINDER AND BREAK BOOSTER. THIS WAS DUE TO BREAK FLUID LEAKING INTO THE BRAKE BOOSTER FROM THE MASTER CYLINDER, DEPLETING THE BREAK FLUID RESERVOIR RENDERING THE BREAK SYSTEM COMPLETELY INOPERABLE. THERE WERE NO WARNINGS BEFORE THIS TOOK PLACE. THE VEHICLE WAS IN MOTION WHEN THE FAILURE TOOK PLACE. THERE IS A SIMILAR RECALL ON THE FORD F-150 WHICH USES THE SAME PARTS AS THE EXPEDITION. RECALL # 20S31. WE HAVE ATTACHED ALL DOCUMENTATION OF THE REPAIR.

VEHICLE ENGINE SHUTS DOWN WHLIE DRIVEING AT ANY GIVEN TIME, GEAR AND SPEEDS. ALL ELECTRICAL PARTS REMAINS WORKING. STOP AND RESTART THE CAR AND IT'S WORKING AGAIN FOR A FEW MINUTES AND THE ENGINE SHUTS DOWN AGAIN.WHILE IN MOTION. HOWEVER IT SEAMS TO HAPPEN WHEN YOU ACCELERATE, AND IF YOU KEEP A CONSTANT RPM THE CAR LASTS LONGER BEFORE THE ENGINE SHUTS DOWN. NO ENGINE CHECK LIGHT CAME ON AT FIRST ONLY AFTER FEW SHUTDOWN. WHEN CHECKING THE ERROR CODE ITS P2112

THREE TIMES THE VEHICLE HAS GONE INTO "LIMP MODE" WITH THE WRENCH LIGHT BEING DISPLAYED ON THE DASH. I HAVE GONE TO THE DEALERSHIP EACH TIME AND NO FAILURE CODE IS COMING UP. THEY WILL NOT FIX THE VEHICLE WITHOUT THE FAILURE CODE BEING DISPLAYED AND RECOMMENDED TOWING THE VEHICLE NEXT TIME IT HAPPENS. I HAVE FEAR OF DRIVING THIS VEHICLE ON THE HIGHWAY.

SAME MASTER CYLINDER FAILURE ON MY EXPEDITION THAT WAS ISSUED A RECALL FOR THE F150.

MY CAR WAS LEFT IN PARK WITH THE ENGINE RUNNING AND AC ON FOR 30 MIN DUE TO HAVING GROCERIES IN THE CAR. MY CAR CAUGHT FIRE AND COMPLETELY BURNED UP. THERE WAS NOTHING FLAMMABLE IN MY CAR OTHER THAN THE 1/4 TANK OF GAS I HAD LEFT. FIRE CHIEF SAID THE FIRE APPEARED TO START IN THE ENGINE. THE VEHICLE WAS PARKED IN A DRIVEWAY. *TR

IN 2015 WHILE LIVING IN NORTH DAKOTA I PURCHASED A 2015 FORD EXPEDITION EL. IN 2018 I MOVED TO FLORIDA AND HAD NEW TIRES INSTALLED IN 2019. NOW, 5,000 MILES LATER I AM TOLD THE LUG NUTS ARE SWOLLEN AND MY TIRES CANNOT BE ROTATED, I NEED TO BUY NEW LUG NUTS. I WAS SHOCKED AND NEVER HEARD OF THIS, I STOPPED IN THE LOCAL FORD DEALER AND WAS TOLD THIS IS TRUE, FORD DECIDED TO PUT THESE TWO PIECE LUG NUTS ON NEW VEHICLES, "WE HAVE SEEN THIS A LOT". I ASK IF THERE WAS A RECALL AND WAS TOLD "I WISH". THE DEALERSHIP SUGGESTED I SHOP AT AN AUTO PARTS STORE BECAUSE "OURS ARE PRETTY PRICEY AT $8 A PIECE, IT WILL BE COSTLY IF YOU NEED TO REPLACE LUG NUTS ON ALL 4 WHEELS". I CALLED FORD CORPORATE IN DETROIT AND WAS TRANSFERRED TO A CALL CENTER IN THE PHILIPPINES WERE THE FEMALE COULD ONLY READ FROM A SCRIPT STATING "THIS PROBLEM IS NOT COVERED BY THE MANUFACTURES WARRANTY."

THE DAY AFTER WE BOUGHT THIS VEHICLE USED HAD 78,000 MILES ON IT WE WERE DRIVING ON A 4 LANE ROAD ABOUT 60MPH WHEN THE CHECK ENGINE LIGHT CAME ON AND IT PUT ITSELF INTO NEUTRAL. THE GAS PEDDLE WOULD NOT ENGAGE. AFTER WE TURN IT OFF AND ON A COUPLE TIMES WE WERE ABLE TO DRIVE IT AGAIN. THIS HAS HAPPENED AT LEAST THREE TIMES SINCE WE HAVE OWNED IT. WE BOUGHT IT 4 MONTHS AGO. ON THREE OTHER OCCASIONS THE CHECK ENGINE LIGHT CAME ON WHILE RETURNING HOME FROM A 3 HOUR DRIVE ON A HIGHWAY GOING 60MPH DOWN A HILL AND IT WAS UNDER POWERED BUT STILL DRIVABLE. WE HAD ONE TURBO REPLACED HOWEVER THE LIGHT HAS COME ON AGAIN BUT THE DEALER COULDN'T FIX IT BECAUSE THE CHECK ENGINE LIGHT CLEARED AND THEY CAN'T FIND ANYTHING WRONG WITH IT. LAST WEEK WE WERE DRIVING IN TOWN THANKFULLY UNDER 30MPH AND THE BREAK PEDDLE GOT HARD AND COULDN'T BE PRESSED DOWN. A LIGHT CAME ON THAT SAID BREAK FAILURE WE HAD TO ENGAGE THE EMERGENCY BREAK TO STOP. WE HAD IT TOWED NO LIGHTS WERE ON WHEN IT GOT TO THE DEALERSHIP THEY PUT 30 MILES ON IT TRYING TO RECREATE THE PROBLEM AND COULDN'T GET IT TO DO IT AGAIN. THIS VEHICLE IS VERY UNSAFE IT'S A MATTER OF TIME BEFORE IT EITHER SHUTS DOWN IN THE MIDDLE OF A BUSY HIGHWAY OR THE BREAKS WON'T WORK AND CRASHES INTO SOMETHING OR SOMEONE. WE HAVE A VEHICLE NOW THAT WE CANNOT DRIVE AND CANNOT FIX AND IF WE TRADE IT IN WE WILL BE OUT A LOT OF MONEY AND THIS UNSAFE VEHICLE WILL BE PUT BACK ON THE LOT.