2001 FORD EXPEDITION Complaints

2001 FORD EXPEDITION 5.4L ENGINE WITH 75,000 MILES. THERE WAS A SLIGHT TICKING IN ENGINE ON DRIVERS SIDE, HAD MECHANIC CHECK, NO OBVIOUS PROBLEM. WHILE DRIVING, LOUD POPPING NOISE, ENGINE BECAME VERY LOUD (TRACTOR LIKE SOUND) AND ENGINE FAILURE. HAD VEHICLE TOWED TO MECHANIC. SPARK PLUG WAS BLOWN OUT CAUSING DAMAGE TO IGNITION COIL. HAD 3 CYLINDERS (1,3, & 5) RETHREADED, IGNITION COILS REPLACED AND ALL SPARK PLUGS REPLACED. *TR

WINDSHIELD LEAKING DUE TO FAULTY SEALANT. HAVE ALL KINDS OF SAFETY ISSUE WITH THE VEHICLE NOW. WATER LEAKS DIRECTLY INTO GEM MODULE WHICH IS RESPONSIBLE FOR TURNING ON AND OFF ALL FUNCTIONS OF MY FORD EXPEDITION. THINGS JUST RANDOMLY START AND STOP WORKING BY THEMSELVES, INCLUDING CRUISE CONTROL, FOUR WHEEL DRIVE, WIPERS, AND HEATER BLOWER. SOME STAY ON EVEN AFTER KEY IS REMOVED LEAVING YOU STRANDED. THE ONLY THING YOU CAN DO IS FIND SOMEONE FOR A JUMP START. *TR

WAS CLOSING REAR LIFT GATE ON OUR 2001 FORD EXPEDITION THE STRAP ATTACHING MECHANISM BROKE CAUSING ME TO FALL BACKWARDS ON THE TO PAVEMENT STRIKING THE BACK OF MY HEAD AND SCRAPING MY ELBOW. THIS CAUSED ME TO BE TRANSPORTED TO THE LOCAL EMERGENCY ROOM FOR TREATMENT. *TR

I HAVE A 2001 FORD EXPEDITION WITH APPROXIMATELY 130K MILES. THE SPARK PLUG IN CYLINDER 4 BLEW OUT YESTERDAY WHILE MY WIFE WAS DRIVING DOWN THE HIGHWAY. WE DISCOVERED THE CYLINDER HEAD THREADS HAVE BEEN BLOWN OUT ALSO. I AM UNABLE TO REPLACE THE SPARK PLUG WITHOUT REPAIR TO THE HEAD. *TR

IN THE LAST 6 MONTHS, I HAVE NOTICED THAT WHEN IT RAINS, MY BLOWER MOTOR WILL RUN ON HIGH-SPEED AND MY LIGHTS WILL FLICKER AFTER I TURN THE VEHICLE OFF. AT FIRST IT WOULD STOP AFTER A FEW SECONDS, HOWEVER THIS LAST TIME, IT RAN FOR ABOUT 10 MINUTES AND FINALLY SHUT OFF. I CALLED FORD MOTOR CO TO INQUIRE ABOUT A RECALL. THEY HAVE NO RECORD NOR KEEP ANY DATA ON ANYTHING . SO I CALLED THE LOCAL DEALER AND THEY WERE 'FAMILIAR' WITH MY PROBLEM AND HAD A 'FEW' FIXED. WELL, AFTER DOING SOME RESEARCH ON THE INTERNET, IT TURNS OUT THERE'S MORE THAN JUST A 'FEW' INCIDENTS.. THERE ARE SEVERAL!!! THE PROBLEM APPEARS TOO START WITH A WATER LEAK IN THE WINDSHIELD, GOING TO THE FUSE BOX AND GEMODULE WHICH IN TURN SENDS ELECTRICAL CURRENTS TO THE ABS MODULE WHICH CAUSE ALL SORTS OF PROBLEMS. THIS IS A FORD MANUFACTURERS DEFECT. *TR

SPARK PLUG EJECTED FROM THE ENGINE OF MY 2001 FORD EXPEDITION. THE ENGINE IS A TRITON 5.4L V8. *TR

TL*THE CONTACT OWNS A 2001 FORD EXPEDITION. THE CONTACT STATED THAT SHE WAS INFORMED THAT THE VEHICLE HAD SUDDENLY CAUGHT FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE; THE HOOD WAS BURNED AND THE WINDSHIELD BLEW OUT AS A RESULT OF THE FAILURE. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 166,000.

TL* THE CONTACT OWNS A 2001 FORD EXPEDITION. THE CONTACT STATED THAT THE ELECTRICAL SYSTEM MALFUNCTIONED, THE INSTRUMENT PANEL WOULD ILLUMINATE SUDDENLY WITHOUT WARRANT, THE RADIO WOULD ENGAGE INDEPENDENTLY, AND THE WINDSHIELD WIPERS WOULD ACTIVATE WITHOUT THE KEYS BEING IN THE IGNITION. IN ADDITION, THE CONTACT STATED THAT THE WINDSHIELD WIPERS WOULD NOT ENGAGE WHILE THE VEHICLE WAS TURNED ON. THE VEHICLE WAS INSPECTED BY AN AUTHORIZED DEALER WHO ADVISED THE CONTACT THAT WATER WAS LEAKING INTO THE VEHICLE THROUGH THE WINDSHIELD AND THE WINDSHIELD WOULD NEED REPLACING. THE WINDSHIELD WAS REPLACED YET THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN BACK TO THE DEALER BUT THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE OR DIAGNOSE WHERE THE LEAK WAS COMING FROM. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ADVISED THE CONTACT THAT THEY COULD OFFER NO ASSISTANCE WITHOUT AN ACCURATE DIAGNOSIS. THE FAILURE MILEAGE WAS APPROXIMATELY 98,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 121,000.

TL*THE CONTACT OWNS A 2001 FORD EXPEDITION EDDIE BAUER EDITION. WHILE THE VEHICLE WAS PARKED, THE CONTACT WAS INFORMED THAT THE VEHICLE WAS ON FIRE WHICH ORIGINATED FROM UNDER THE HOOD. THE CONTACTS FAMILY WAS ABLE TO EXTINGUISH THE FIRE. A POLICE REPORT WAS FILED. THE VEHICEL WAS DESTROYED. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000.

FORD 2001 EXPEDITION HAS A BLOWN SPARK PLUG. THE ENGINE COULD HAVE CAUGHT ON FIRE WHILE I DROVE THE TRUCK WITH THE VAPORS POURING OUT OF THE PLUG SPOT (WHICH FLEW OUT OF THE ENGINE ON TO THE ROAD SOME WHERE BEHIND ME). FORD KNOWS THIS IS AN ENGINE DEFECT. WHY ARE WE NOT HAVING A RECALL FOR THIS PROBLEM. *TR