2017 FORD EXPEDITION Complaints

Transmission unable to shift out of park periodically, transmission downshifting at highway speeds and engine shutting down. Speedometer and RPM guage going crazy then no longer working.

The contact owns a 2017 Ford Expedition. The contact stated that during cold starts, there was a loud rattling sound coming from the engine compartment. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was provided. The local dealer was not contacted. The failure mileage was 132,000.

Electrical wiring for the blower motor replaced as a result of Safety Recall 22S56.

The contact owns a 2017 Ford Expedition. The contact stated while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact used the parking brake to stop the vehicle. The contact stated that the brake fluid level was checked, and the brake fluid level was low but there were no signs of a brake fluid leak. The vehicle was taken to the dealer however, the cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was informed that the repair was not covered under NHTSA Campaign Number: 22V150000 (Service Brakes, Hydraulic). The failure mileage was approximately 115,000.

The contact owns a 2017 Ford Expedition. The contact stated while the tires were being rotated, the tire technician was unable to remove the lug nuts because the lug nuts had swollen. The contact was informed that all four wheels had the same failure. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 68,000.

We were out of town driving to a baseball tournament going 80 miles an hour when the car completely lost power and a wrench came up. My husband barely coasted us to a shoulder. The car would not reset or restart unless it was in park. Happens twice. Took it for code read they said it is a throttle body issue but that instead of check engine light it shuts the whole car down until reset. Very scary on the interstate. Could have easily been in a bad collision.

The contact owns a 2017 Ford Expedition. The contact stated that while driving on several occasions at various speeds, there was a burning odor inside the cabin of the vehicle, and the air condition failed to operate as intended. The vehicle was taken to a dealer where it was diagnosed that the wiring harness to the blower motor had melted and the pigtail on the wiring harness needed to be replaced. The vehicle was repaired but the failure recurred. The contact believed that the failure was associated with Manufacturer Recall: 22SF6. The manufacturer was notified of the failure. The failure mileage was 83,000.

In 2022, around mileage of 67000, our SUV was climbing a steep road when it suddenly made a pop sound & went into limp mode with the wrench light showing and the engine sounding rough. It felt like no fuel was getting to the engine & the gas pedal was non-responsive. The RPMs didn't change when the gas pedal was pressed. The grade was so steep, we barely made it to the side of the road without rolling backwards into traffic behind us. After turning the engine off and sitting about 10 mins, we tried starting the engine again. The car seemed to have reset itself! It ran fine; the wrench light turned off, and the gas pedal was responsive again. (At the time, we were on vacation at the coast and had traveled from our home at about elevation 3500'. We had also recently had to buy gas from a small no name gas station, so we feared we may have gotten bad fuel). From there, we returned home without re-occurrence, and we used fuel cleaning additive to our Chevron fuel for the next 2 fill ups. Then, approximately 600 miles later on a flat grade, it happened again without the pop sound. We immediately went to our Ford dealer who found no error code but found our purge valve stuck open. They recommended we replace it, which we did, and we operated the vehicle for 2 years without re-occurrence and using only Chevron gas. Recently, it happened again! Luckily, we weren't on a steep grade this time or on the freeway, but if a car would have been behind us, we would have likely been rear ended, especially had we been on the freeway. Once again, we shut the engine off, and it reset with the wrench light disappearing, so no diagnostic code got thrown AGAIN! Based on many complaints, this appears to be a common problem. It's very dangerous as the car immediately losses power to a crawl no matter what speed you are traveling at the time. It seems to be the electronic throttle body in instances where the SUV can stay running, so a code can be obtained before it resets.

Blower motor shorted out and melted the wiring harness going to the blower motor and started smoking and almost caught on fire. Took the vehicle in for repair and there is a recall to replace the blower motor. The dealership stated they will replace the blower motor per the recall but I am responsible for the melted wiring.

The contact owns a 2017 Ford Expedition. The contact stated while reversing at an undisclosed speed, the back over prevention camera failed to function as intended. The contact stated that the back over prevention camera displayed colorful lines but not the proper image. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was 36,830.