2001 FORD EXPEDITION Complaints

TL* THE CONTACT OWNS A 2001 FORD EXPEDITION EQUIPPED WITH CONTINENTAL CONTRI TRAC AW TIRES, LINE SIZE P275/60/R17. THE CONTACT WAS DRIVING 60 MPH WHEN THE TREAD OF THE REAR PASSENGER TIRE SEPARATED. THE CONTACT INSTALLED THE SPARE TIRE. HE STATED THAT HE HAD NOT NOTICED ANY PRIOR ISSUES WITH THE TIRE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE DOT NUMBER WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 85,230 AND THE CURRENT MILEAGE WAS 85,239.

THE SPARK PLUG (PASSENGER SIDE, SECOND BACK FROM FRONT OF ENGINE) EJECTED FROM THE ENGINE HEAD WHILE PARKED. WE HAD DRIVEN FOR 20 MINUTES, STOPPED AT A RESTAURANT, TURNED OFF THE ENGINE, BUT RESTARTED IT WITHIN ABOUT 60 SECONDS. THE SPARK PLUG EJECTED IMMEDIATELY AFTER THE ENGINE WAS RESTARTED, WITHIN 1 SECOND. THERE WERE NO INJURIES, AND THE VEHICLE WAS NOT IN MOTION AT THE TIME. MY ENTIRE FAMILY WAS IN THE VEHICLE AT THE TIME. THE SOUND OF THE EJECTION WAS SUFFICIENTLY LOUD THAT IT RESEMBLED A GUNSHOT, TO WHICH AN OFF-DUTY OFFICER REACTED. THE COIL PACK WAS DAMAGED BEYOND USE, THE SPARK PLUG INSULATOR SHATTERED. THE PLUGS APPEARED TO BE ORIGINAL MOTORCRAFT PLUGS, ALTHOUGH AT 130K MILES, THEY WOULD BE VERY OLD. THEY HAD SUFFICIENT CARBON AND WEAR THAT THEY COULD BE ORIGINAL PLUGS OR PLUGS FROM THE FIRST SCHEDULED REPLACEMENT (IF IT WAS DONE). REPAIRS HAVE NOT YET BEEN PERFORMED. *TR

WHILE STARTING THE VEHICLE I HEARD A LOUD POP FROM THE ENGINE... WHEN I TOOK THE VEHICLE TO THE MECHANIC #8 SPARKPLUG BLEW OUT, DAMAGED THE HEAD AND PISTON....LOOKING AROUND $1200.00 IN REPAIRS PLUS CAR RENTAL. SPARKPLUGS GOT WATER IN THEM 3 DIFFERENT TIMES BEFORE THEY NEED TO INVESTIGATE THIS PROBLEM. *TR

FORD 2001 EXPEDITION 5.4L V8 SPARKPLUG BLOWS OUT OF THE CYLINDER HEAD. VAPORS, SMOKE , LOUD NOISE EXTREME HAZARD TO MY WIFE WHILE SHE WAS ON THE HIGHWAY. THIS ENGINE SHOULD BE RECALLED AND FORD SHOULD EFFECT THE REPAIR. MANY PEOPLE ARE AT DANGER DUE TO THIS OBVIOUS DESIGN FLAW. *TR

TL* THE CONTACT OWNS A 2001 FORD EXPEDITION. WHILE DRIVING 15 MPH, THERE WAS A LOUD, UNUSUAL POP HEARD FROM THE HOOD AREA. THE CONTACT MOVED OFF THE ROADWAY AND DISCOVERED THAT THE SPARK PLUGS HAD FRACTURED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE CONTACT'S PLACE OF RESIDENCE. THE DEALER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 114,000.

TL* THE CONTACT OWNS A 2001 FORD EXPEDITION. THE VEHICLE WAS PARKED IN FRONT OF THE CONTACT'S HOME WHEN IT CAUGHT ON FIRE. THERE WERE FLAMES SHOOTING FROM UNDER THE HOOD OF THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE. A FIRE REPORT WAS AVAILABLE. THERE WERE NO PRIOR WARNINGS INDICATING THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED FOR THE CAUSE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS 95,000.

I WAS DRIVING MY FAMILY HOME FROM YELLOWSTONE ON I25, WHEN OUR 2001 FORD EXPEDITION BLEW A SPARK PLUG. WE WERE MILES FROM ANYWHERE WITH A TOW TRUCK, AND IT TOOK OVER 2 HOURS BEFORE A TOW TRUCK OPERATOR GOT US. AT THE SAME TIME, AN ESCAPED MURDERER WAS HITCHHIKING DOWN A DIFFERENT ROUTE HOME. (WHAT IF WE HAD CHOSEN THAT ROUTE?) I RENTED A CAR TO DRIVE HOME, AND IT LOOKS LIKE WE WERE WAY OVERCHARGED FOR THE REPAIR. ($3500). *TR

TL* THE CONTACT OWNS A 2001 FORD EXPEDITION. THE CONTACT STATED THE VEHICLE WAS REPAIRED UNDER NHTSA RECALL CAMPAIGN ID NUMBER: 05V388000 (VEHICLE SPEED CONTROL). SINCE REPAIRS, THE CONTACT STATED THE ENGINE WOULD EXHIBIT AN UNUSUALLY HIGH INCREASE IN RPMS WHEN UTILIZING THE CRUISE CONTROL. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR REPAIRS OR A DIAGNOSTIC OF THE FAILURE. THE FAILURE MILEAGE WAS 138,000 AND THE CURRENT MILEAGE WAS 147,349.

FORD TRUCK FIRES.. FORD EXPEDITION FIRE DUE TO DEFECTIVE CRUISE CONTROL SWITCH. *TR

2001 FORD EXPEDITION BLOWS SPARK PLUGS, PIECES BREAK OFF FALL INTO CYLINDER AND DAMAGE ENGINE. FUEL GASES FROM OPEN CHAMBER HAVE POTENTIAL FOR FIRE. *TR