2020 FORD EXPEDITION Complaints

My check engine lights comes on and off reading that it is a failure with the catalytic converter. Check engine light had been on for 2 weeks I had already called Ford to set up appt. The evening before taking truck in check engine light went off. I called Ford 5/13/25 that light had gone off do I still take truck in. Since I received letter for recall, I took truck in for service . They say they only need to reprogram the PCM but now they are saying that the Catalytic Converter is bad and needs to be replaced costing $5000. What is Ford thinking this truck has been nothing but problems. I told tech that truck has been running accelerated for a few weeks when driving. Problem with check engine light could not be reproduced since it turned off the day before I had appt set. Rep told me that they just needed to see if they could read that it was the recall issue and they would just reprogram it.

The contact owns a 2020 Ford Expedition. The contact stated the transmission was slipping while driving at an undisclosed speed. The contact stated that on one occasion, while her daughter was driving 60 MPH, the transmission started slipping and the vehicle failed to accelerate above 60 MPH. There were no warning lights illuminated. The contact stated that the failure was related to TSB: 23-2120. The vehicle was taken to the local dealer, who was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The dealer informed the contact that the vehicle needed to be test-driven. The manufacturer was contacted and opened a case. The failure mileage was approximately 85,000.

At highway speed 70mph, I accelerated and the vehicle downshifted to 1st, followed by loss of gear with a loud clunk. Then alarming for transmission. After coasting to about 30mph the teansmission clunked again and powere cane back. Happened while passing a semi truck. This was reproduced multiple times, on demand and I have video documentation. Dealer eventually rehauled the transmission. But now its starting to miss gears / have hard shifts. This transmission is a Huge safety risk.

This suv has 10 speed transmission that has faulty harsh shifting hesitation, acceleration problem when shifting on highway or in situations when you need to slow down and or accelerate. This has happened many times while trying to get on the highway and switching lanes. I have almost been run over because it stalled someone is going to get killed. I have had the Powertrain control module pcm reprogramed twice and it keeps happening. Ford is aware of this. They need to get this trucks off of the road!

The contact owns a 2020 Ford Expedition. The contact stated while driving 65 MPH and depressing the accelerator pedal, the vehicle turned off and downshifted independently. The vehicle was not diagnosed by a dealer or independent mechanic. The vehicle was not repaired. The contact stated that the vehicle had experienced the failure listed in NHTSA Campaign Number: 20V197000 (Power Train); however, the VIN was not included. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 88,000.

The contact owns a 2020 Ford Expedition. The contact stated that occasionally, while putting the vehicle into drive or attempting to accelerate from a stop, the vehicle first hesitated or jerked before shifting into gear. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the CDF drums and seal in the transmission were faulty and needed to be replaced. Additionally, a transmission strategy download and transmission shift adapt tables needed to be performed. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 71,000.

The contact owns a 2020 Ford Expedition. The contact stated that upon entering the rear passenger’s side of the vehicle, the folding seat gap hider panel was missing, leaving a deep hole on the floor, approximately 19 inches deep. The contact believed that was a serious safety concern for a small child. No warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 87,000.

The contact owns a 2020 Ford Expedition. The contact stated that there was an abnormal rattling sound coming from the vehicle at start-up. There was no warning light illuminated. The vehicle was taken to a dealer and was diagnosed with a defective cam phaser. The manufacturer was notified of the failure and informed the contact that there were no recalls on the vehicle for the failure and a case was filed. The contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 97,000.

When accelerating quickly, such as to pass, the truck feels as if it is in neutral. when the gas pedal is pushed down, the RPMs jump up, but the truck doesn't accelerate. After letting off the gas, the RPMs will drop, there is a loud "clunk" in the rear end and then power will be restored. No codes are being stored to diagnose issue. Happens intermittently and all speeds.

The rear back up camera has recently been glitching and most times has a solid blue screen when car is in reverse. It was in for diagnostics, report came back stating: Verified customer concern; screen turns blue when vehicle is placed in reverse. Retrieved CMDTC B115E 08 stored current in IPMB. Verified gear selected matches commanded data in IPMB. Removed and tested circuit with known good camera, and rear view image works each time vehicle is placed in reverse, confirming circuit is good.