1997 FORD EXPEDITION Complaints

DRIVING MY 97 FORD EXPEDITION HOME FROM WORK IT BLEW A SPARK PLUG AND THE VEHICLE ONLY HAS 76K. BROUGHT IT TO CROWLEY FORD IN PLAINVILLE, CT. AND THE PLUG WAS REPAIRED FOR $750.00. IT DID NOT CORRECT THE PROBLEM. WAS TOLD THAT THE ENGINE NEEDED REPLACING FOR THE PRICE OF $5200.00. THIS PROBLEM IS RELATED TO POOR DESIGN. I DID MY HOMEWORK. THERE ARE SEVERAL OTHER INDIVIDUALS WHO HAVE REPORTED THE SAME PROBLEM ACROSS THE COUNTRY. AT THIS TIME FORD IS NOT TAKING ANY RESPONSIBILITY FOR THIS. *NM

ABS LIGHT COMES ON AT RANDOM TIMES. BRAKE FAILURE AT SLOW TO MODERATE SPEEDS LIKE IN ANTILOCK MODE OR LIKE STOPPING ON GRAVEL. PEDAL STIFF AND CANNOT PUMP BRAKES WHILE FEELING AND SOUNDING JERKY. HAVE REPLACED WHEEL SPEED SENSOR AND ABS SOLENOID SENSOR. WILL FINALLY GRAB AND STOP AFTER APPROX. 20 FEET OF PUMPING. *NM

#3 SPARK PLUG EJECTED FROM THE ENGINE, WHICH RESULTED IN SIGNIFICANT POWER LOSS. I NEARLY WAS REAR-ENDED BY A GAS TRUCK, BUT WAS EVENTUALLY ABLE TO PULL OFF THE FREEWAY. THE SPARK PLUG THREADS WERE STRIPPED FROM THE HEAD, THE SPARK PLUG BOOT WAS SPLIT AND THE COIL MOUNT WAS BROKEN OFF. *NM

I HAD A INGNITOR BLOW COMPLETELY OUT OF THE HEAD ON MY EXPEDITION. . IT IMMEDIATELY SMELLED OF GAS AND SOUNDED LIKE A TRACTOR. THE INGNITOR THEN KEPT HITTING THE FUEL RAIL. WE WERE LUCKY THAT THE VEHICLE DID NOT START ON FIRE BECAUSE OF THE TWO HITTING AND STARTING A FIRE WITH A SPARK. WHEN I TALKED TO A FORD DEALER THEY SAID THAT YES IT DOES HAPPEN QUITE A BIT BECAUSE OF THE ON THE HEAD...THEY ONLY PUT 2 THREADS IN TO THREAD THE INGNITOR IN. I THINK THERE NEEDS TO BE A RECALL ON THIS IF THIS HAPPENS. SOME ONE COULD BE WORKING ON THE VEHICLE WHEN THIS HAPPENED AND COULD START A FIRE DUE TO THE GAS. IT WILL NOW COST ME $3000 TO FIX THIS DESIGN DEFAULT ONLY TO GET REPLACED BY THE SAME ISSUE!!! *JB

DT*: THE CONTACT STATED THE ELECTRICAL CONNECTORS TO THE EXTERIOR LIGHTS MELTED CAUSING THE LIGHTS TO BECOME INOPERABLE. THIS IS THE SECOND TIME THE CONNECTOR HAS BEEN REPLACED. THE FIRST TIME THE CONNECTOR FOR THE LOW BEAMS WAS REPLACED. AS A RESULT THE VEHICLE ONLY HAD DAY TIME RUNNING LIGHTS. THE SECOND TIME THE CONNECTOR FOR THE BLINKERS AND THE HAZARDS FLASHING WARNING LIGHTS WERE REPLACED. THE DEALERSHIP WAS ALERTED HOWEVER THEY ARE UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER HAS BEEN ALERTED.

ON NOVEMBER 11, 2005 DRIVING MY FORD EXPEDITION ON HIGHWAY 410 AND JONES MALTBERGER IN THE CITY OF SAN ANTONIO TEXAS. MY CAR WAS ON FIRE IN THE FRONT HOOD. I BELIEVE IT GOT CAUGHT ON FIRE BECAUSE IT HAS A DEFECTIVE SPEED CONTROL CAUSING ON THE VEHICLE CONTROL DEACTIVATION SWITCH BECAUSE IT OVERHEATED AND SMOKE AND BURNING UNDER THE HOOD HAPPENED. I CONTACTED FORD AND THEY DON'T WANT TO BE RESPONSIBLE TO MAKE REPAIRS. FORD SENT AN INSPECTOR ON JANUARY 4, 2006, WHO WAS IN CHARGE OF THE CASE FROM CONSUMER AFFAIRS. HE SENT A LETTER, AND CONCERN WAS REVIEWED AND WAS NOT ABLE TO VERIFY IT AS A MANUFACTURER'S DEFECT. ALSO, COULD NOT OFFER ASSISTANCE AT THIS TIME. *AK. UPDATED 4/6/2006 - *NM. UPDATED ON 05/16/2006- *AK

1997 FORD EXPEDITION - THE HINGES ON REAR GLASS LIFTGATE BROKE / FRACTURED CAUSING REAR WINDOW GLASS TO DISCONNECT FROM THE VEHICLES AND CRASH TO THE GROUND AND SHATTER. THIS SOUNDS VERY SIMILAR TO THE RECALL ALREADY IN EFFECT FOR 2002 FORD EXPLORERS NHTSA CAMPAIGN #04V442000. *JB

1997 EXPEDITION THROTTLE WAS STUCK OPEN. *TS ***NAR*** WHILE DRIVING IN BELOW ZERO TEMPS THE THROTTLE STUCK OPEN. THE VEHICLE WAS TAKEN TO AND AUTO CENTER WHO LOCATED A BULLETIN INDICATING THAT THE THROTTLE STICKS AFTER STEADY DRIVING IN COLD AMBIENT TEMPS. THE DATE ON THE BULLETIN WAS OCT 26, 1998.

DT*: THE CONTACT STATED THE CHILD SAFETY LOCKS ON THE REAR DOORS ENGAGED THEMSELVES. THE CONTACT MUST EXIT THE VEHICLE AND OPEN THE DOORS FOR PASSENGERS. THE DEALERSHIP REPAIRED THE PROBLEM, BUT IT IS OCCURRING AGAIN.

97 EXPEDITION THAT HAS MULTIPLE ELECTRICAL PROBLEMS, AIR BAG LIGHT STAYS ON, CLICKING UNDER DASH WET CARPET ON DRIVERS SIDE. LOCAL FORD DEALER TELLS ME OH THAT'S AN EASY FIX, ONLY $1200.00 TO REPLACE THE GENERIC ELECTRIC MODULE AND REMOVE AND REINSTALL THE WINDSHIELD! WENT ON TO TELL ME THEY DO THIS ALL THE TIME ON EXPEDITIONS! I ASKED WHY AND THEY TOLD ME THAT "THE FACTORY SCREWED UP WHEN THE WINDSHIELDS WERE INSTALLED AND THEY LEAK"! I THOUGHT THAT WAS WHY WE HAD RECALLS! IF THIS IS THE FACTORIES FAULT THEN WHY MUST I PAY FOR IT? *JB