1997 FORD EXPEDITION Complaints

THE STEERING ON THE VEHICLE IS LOOSE AND WONDERS ALL OVER THE ROAD CONTACTED A MECHANIC AND HE TOLD ME WHERE STEERING SHAFT SLIDES TOGETHER IS REALLY LOOS AND STEERING SHAFT NEEDS REPLACED

I KNOW FOR A FACT THERE WAS A MASSIVE RECALL ON THE MODEL. THE CRUISE CONTROL MALFUNCTIONS AND CATCHES ON FIRE WHEN THE KEY IS NOT IN THE IGNITION. MOST OF THE F-150 ENGINE FIRES WERE TRACED BACK TO A FAULTY CRUISE CONTROL. THE VEHICLES USUALLY BURNED WHEN THE VEHICLE HAS 160-180,000 MILES ON THE SPEEDOMETER. MY 2000 FORD EXPEDITION BURNED CAUGHT MY HOME ON FIRE AND NEARLY KILLED THREE PEOPLE AND SEVERAL PETS. THE VEHICLE IN QUESTION BELONGS TO A GOOD FRIEND. THEY MENTIONED IN PASSING THAT THE CRUISE CONTROL IS MALFUNCTIONING. THIS VEHICLE IS EXHIBITING THE EXACT SAME SYMPTOMS THAT MY EXPEDITION DID JUST BEFORE IT CAUGHT FIRE. I UNPLUGGED MY FRIENDS EXPEDITION CRUISE CONTROL. I AM SHOCKED THIS VEHICLE IS NO LONGER ON THE RECALL LIST. IF THIS VEHICLE WAS REPAIRED DURING THE RECALL IT WOULD NOT BE MALFUNCTIONING NOW.

STARTED VEHICLE AND IMMEDIATELY HEARD LOUD NOISE UNDER HOOD. FOUND SPARK PLUG HAD BLOWN OUT OF HEAD. VEHICLE WAS STATIONARY AT TIME, BUT HAD BEEN DRIVEN WITHOUT PROBLEM JUST A COUPLE OF HOURS EARLIER.

MY BRAKE WENT TO THE FLOOR WHEN I STARTED TO DRIVE MY VEHICLE LAST WEEK. I WAS GOING TO AVE MY BAKES REPLACED TODAY WHEN THE MECHANIC NOTICED THAT THE LOWER CONTROL ARMS WERE VERY RUSTED IT HAS PIECES BREAKING OFF AND THERE IS ACTUALLY A HOLE IN THE REAR DRIVER SIDE LOWER CONTROL ARM. THE METAL BRAKE LINES IS ALSO RUSTED IN TWO. HE LOOKED AT MY 1998 EXPIDITION AND THE LOWER CONTROL ARMS ON THE BACK OF IT ARE ALSO RUSTED OUT. HE SAIDIDN'T I SHOULD NOT DRIVE EITHER OF THEM UNTIL THEY ARE REPLACED. I'M WONDERING IF THERE IS A RECALL ON THESE.

TL* THE CONTACT OWNS A 1997 FORD EXPEDITION. WHILE DRIVING AT 10 MPH, AN ABNORMAL SOUND WAS HEARD FROM THE REAR DRIVER SIDE TIRE. THE FAILURE RECURRED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 96V252000 (SUSPENSION). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 220,000.

TL* THE CONTACT OWNS A 1997 FORD EXPEDITION. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE FAILED TO REMAIN IN POSITION. THE CONTACT HAD TO STEER THE VEHICLE IN EXCESS TO KEEP THE VEHICLE IN POSITION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE STEERING SHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 03V196000 (STEERING), BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 170,000.

MISCELLANEOUS ELECTRICAL PROBLEMS CAUSED BY WATER LEAKING FROM DRIVER'S SIDE WINDSHIELD INTO THE FUSE BOX CAUSING, WINDSHIELD WIPERS TO QUIT. DOOR LOCK WON'T WORK, RADIO QUIT. PROBLEM IS NEVER THE SAME, DEPENDS ON WHERE THE WATER LEAK OCCURS. VERY SCARY AND DANGEROUS WHEN DRIVING AT NIGHT IN THE RAIN.

TL* THE CONTACT OWNS A 1997 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY AT 35 MPH, THERE WAS A KNOCKING NOISE COMING FROM THE STEERING WHEEL AND NOTICED THE STEERING WHEEL WAS BECOMING LOOSE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE INTERMEDIATE SHAFT WAS LOOSE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V196000 (STEERING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 134,000.

TL* THE CONTACT OWNS A 1997 FORD EXPEDITION. THE CONTACT BOUGHT THE VEHICLE WITH A KNOWN SHIFT CABLE ASSEMBLY FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS REPAIRED, BUT THE DETAILS OF THE REPAIR WAS UNKNOWN. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 097V171000 (POWER TRAIN). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 220,000.

IN DRIVEWAY UPON DEPRESSING THE BRAKE PEDAL, TO PUT CAR IN GEAR, BRAKE PEDAL WENT TO THE FLOOR. NO BRAKES AT ALL. NO WARNING. NO LIGHTS INDICATING FAILURE AHEAD OF TIME. BOTH BRAKE LINES THAT GO FROM MASTER CYL, TO ABS UNIT RUSTED THROUGH. UPON FOR DEALER REPLACING BOTH LINES ON A TEST DRIVE FRT DRIVERSIDE BRAKE LINE FAILED DUE TO RUST. COST $976 FOR THOSE RUSTED OUT LINES AND STILL 3 ORE BADLY RUSTED, TO GO. HARDLY SAFE WITH SEVERELY RUSTED LINES. WHEN THOSE TWO LINES BURST,(AT SAME TIME) NO BACKUP BRAKE SYSTEM IN AFFECT.